Weber Summit S-460-LP Owner's Manual
Weber Summit S-460-LP Owner's Manual

Weber Summit S-460-LP Owner's Manual

Built-in lp gas grill
Hide thumbs Also See for Summit S-460-LP:

Advertisement

Quick Links

S-460 T"- LP
YOU MUST READ THIS OWNER'S
GUIDE
BEFORE
OPERATING
YOUR GAS GRILL
Z_ DANGER
if you smell
gas:
1. Shut off gas to the appliance.
2.
Extinguish
any open flames.
3. Open lid.
4. if odor continues,
keep away from the
appliance
and immediately
call your
gas
supplier
or your fire department.
Leaking
gas may cause a fire or explosion
which
can cause
serious
bodily
injury or
death,
or damage
to property.
z_ WARNING:
1. Do not store or use gasoline
or other
flammable
liquids or vapors
in the
vicinity
of this or any other appliance.
2. An LP cylinder
not connected
for use
shall not be stored
in the vicinity
of this
or any other appliance.
Z_ WARNING:
Follow
all leak-check
procedures
carefully
in this manual
prior
to barbecue
operation.
Do this even if the
barbecue
was dealer-assembled.
NOTICE TO iNSTALLER:
These instructions
must be left with the owner and the owner
should
keep them for future
use.
THIS GAS APPLIANCE
IS DESIGNED
FOR
OUTDOOR
USE ONLY.
/k WARNING:
Do not try to light this
appliance
without
reading
the "Lighting
instructions"
section of this manual.
1
MEMBER
Nati0naIPROPANEGAS Ass0¢iali0n
43255 US 08/06/08
LP
US ENGLISH

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Summit S-460-LP and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Weber Summit S-460-LP

  • Page 1 S-460 T"- LP YOU MUST READ THIS OWNER'S GUIDE Z_ WARNING: Follow all leak-check BEFORE OPERATING YOUR GAS GRILL procedures carefully in this manual prior to barbecue operation. Do this even if the barbecue was dealer-assembled. Z_ DANGER if you smell gas: 1.
  • Page 2 Combustible materials should never be within 24 inches (61 cm) of the back or sides of your Weber _ gas barbecue. z_ Do not put a barbecue cover or anything flammable on, or in the storage area under the barbecue.
  • Page 3 3-years no rust through or burn through Porcelain-enameled Weber is not liable for any special, indirect or consequential damages. Some regions do not allow the Flavodzer bars, 2-years no rust through or burn through...
  • Page 4 $460 LP US 17-- 30 m...
  • Page 5 Shroud Hardware Battery Housing Smoker Box Shroud Water Baffle/Heat Shield Smoker Bar Thermometer Sear Station Burner Disposable Drip Pan Thermometer Bezel Drip Tray Smoker Burner Handle Catch Pan Cookbox Grill Out TMHandle Light Catch Pan Holder Bulkhead Rotisserie Motor Left Rear Panel Manifold Hose Rotisserie Bracket...
  • Page 6: Storage And/Or Nonuse

    This regulator is set for 11 inches of water column (pressure). This Weber _ gas barbecue is designed for use with liquid propane (LP) gas only. Do not use with natural (piped in city) gas. The valves, orifices, hose and regulator are for LP gas only.
  • Page 7 CONNECTING THE LIQUID PROPANE CYLINDER All Weber ¢ liquid propane gas grill regulators are equipped with a UL-Listed tank connection as per the latest edition of ANSI Z21.58. This will require a liquid propane tank that is similarly equipped with a Type 1 connection in the tank valve.
  • Page 8 One series of tanks mount with the valve facing front (a). The other tanks mount with the valve facing away from the fuel scale (b). Weber recommends the use of cylinder manufacturer's Manchester and Worthington, with a 47.6 Ib water capacity.
  • Page 9: Check For Gas Leaks

    The burners have been flame-tested. As a safety precaution however, you should recheck all fittings for leaks before using your Weber _ Gas Barbecue. Shipping and handfing may loosen or damage a gas fitting. WARNING: Perform these Jeak checks even if your barbecue...
  • Page 10: Reinstall Control Panel

    DO NOT OPERATE THE GRILL. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®. Hose to regulator connection. Regulator to cylinder connection. Valves to manifold connections. z_ WARNING: if there is a leak at connections (5, 6 or 7 ), turn off the gas.
  • Page 11 REFILLING THE LIQUID PROPANE CYLINDER We recommend that you refill the LP cylinder before it is completely empty. Removal of the LP cylinder Close cylinder valve (turn clockwise). Unscrew regulator coupling by turning counterclockwise, by hand only. Loosen cylinder lock wing nut and turn cylinder lock up out of the way. Lift cylinder o11.
  • Page 12: Snap Ignition Operation

    SNAP iGNITiON OPERATION Z_ Always open the lid before igniting the burners Each control knob has its own igniter electrode built in. To create a spark you must push the control knob in (A) and turn to "START/High" (B). This action will generate gas flow and a spark to the burner lighting tube (C).
  • Page 13 Replace using only Weber _ authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.
  • Page 14: Flavorizer®System

    MAiN BURNER MANUAL MGHTING DANGER Failure to open the lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame=up which can cause serious bodily injury or death.
  • Page 15: Indirect Cooking

    The m ost important thing toknow about grilling iswhich cooking method touse f or a specific food, Direct or Indirect. The d ifference is simple: place the food directly over the 4 burnsl' fire, orarrange the f ire on either side o fit. U sing the right method isthe s hortest route to great results--and...
  • Page 16: Usingthe Sear Station

    & WARNING: Check hose before each use of barbecue for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the barbecue. Replace using only Weber _ authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.
  • Page 17 Open the lid. ARRI_T_: EN MARCHE Make sure all burner control knobs are turned off. (Push control knob in and turn OFF O ® ON clockwise to ensure that it is in the "OFF" position.) Z_ WARNING: The burner control knobs must be in the "OFF"...
  • Page 18 SEAR STATION'" BURNER MANUAL MGHTING ARRI_TI_ EN MARCHE OFF O DANGER APAGADO ENCENDIDO Failure to open the lid while igniting the barbecue's burners, or not waiting 5 minutes to allow the gas to clear if the barbecue does not light, may result in an explosive flame=up which can cause serious bodily injury or death.
  • Page 19: Lighting The Smoker Burner

    Replace using only Weber _ authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®. Open the grill lid. Open smoker box lid. *The grill illustrated may have slight Fill smoker with water soaked wood chunks or chips.
  • Page 20: Manually Lighting The Smoker Burner

    Contact the Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®. Open the lid. DANGER Failure to open the lid while igniting the grill, or not waiting 5 minutes to allow the gas to clear if the grill does not light, may result in an explosive flare=up which can cause serious bodily injury or death.
  • Page 21: Using The Rotisserie

    Representative in your area using the contact information Read all instructions before using your rotisserie. our web site. Log onto www.weber.com ®. This rotisserie is for outdoor use only. Remove motor and store in a dry place when not in use.
  • Page 22: Lighting The Rotisserie

    Contact Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®. Open the lid. Remove the warming rack and the cooking grates from the cookbox. Make sure all burner control knobs are turned off. (Push control knob in and turn clockwise to ensure that it is in the "OFF"...
  • Page 23 WARNING: The burner control knobs must be in the "OFF" position before turning on the liquid propane cylinder tank valve, if they are not in the "OFF" position, when you turn on the LP cylinder valve, the "excess gas flow control" feature will activate, limiting the flow of gas from the LP cylinder,...
  • Page 24: Manually Lighting The Rotisserie Burner

    Check hose before each use of grill for nicks, cracking, abrasions or cuts. If the hose is found to be damaged in any way, do not use the grill. Replace using only a Weber _ authorized replacement hose. Contact the Customer Service Representative in your area using the contact information on our web site.
  • Page 25 See assembly illustration. Is the lid in the up position with the power button ON? Light will activate when lid is open. Is the Weber Grill Out Handle Light activated? Press the power button. Is the Weber Grill Out Handle Light positioned...
  • Page 26 Customer Service Representative in your area using the contact information on our web site. Log onto www.weber.com ®. WEBER ® SPIDER/INSECT SCREENS Your Webe_ gas barbecue, as well as any outdoor gas appliance, is a target for spiders and other insects.
  • Page 27: Main Burner Cleaning

    MAIN BURNER CLEANING PROCEDURE Turn off the gas supply. Remove the manifold (See "Replacing Main Burners"). Look inside each burner with a flashlight. Clean the inside of the burners with a wire (a straightened-out coat hanger will work). Check and clean the air shutter opening at the ends of the burners. Check and clean the valve orifices at the base of the valves.
  • Page 28 Be careful not tobreak or disconnect the wires for t he control panel lights. Rest the control panel against the left side o f t he grill (A) e xposing the v alves, burners, igniter, and m anifold. 8) Remove the two s crews that secure the manifold...
  • Page 29: Annual Maintenance

    Log onto www.weber.com ®. BURNER FLAME PATTERN The Weber ¢ gas barbecue burners have been factory set for the correct air and gas mixture. The correct flame pattern is shown. Burner tube Tips occasionally flicker yellow...
  • Page 30 Greece; Smokey Joe, Ireland; Kettle Silhouette_, Smokey Joe, Italy; Smokey Joe, Weber, Japan; Smokey Joe, Weber, Korea; Smokey Joe, Weber, New Zealand; Weber, Smokey Joe, Nigeria; Weber, Norway; Smokey Joe, Weber, Portugal; Weber, South Africa: Smokey Joe, Weber, Kettle Configuration, Spain;...
  • Page 31 No, this is my first Weber grill / No, 6ste es mi primer asador Weber '_ / Non, il s'agit de mon premier grill Webe: Where did you buy your grill? / 6D6nde cornprb el asador? / Ok avez-vous achet6 votre grill? PLEASE CONTINUE ON BACK / POR FAVOR CONTINUE EN EL REVERSO / VEUILLEZ CONTINUER AU VERSO.
  • Page 32 Thanks for sharing your contact information with us. Again, it all stays strictly For purchases made in the U.S,: Product Registration RO. Box 1999 between us -- Weber does not share customers' names with anyone else. if Para compras hechas en los Estados Unidos: Pour les achats effectu_s aux Etats-Unis:...

This manual is also suitable for:

Summit s-460Summit 43255

Table of Contents