Advertisement
SERVICE AND ADJUSTMENTS
TO REPLACE
BATTERY
(See Fig, 30)
WARNING: Do not short batteryterminals
i
by allowing a wrench or any other object
to contact both terminals at the same time.
Before connecting
battery, remove metal
bracelets,
wristwatch
bands, rings, etc I
Positive terminal must be connected first to prevent spark-
ing from accidental grounding.
Lift seat pan to raised position.
Disconnect BLACK batterycabtefirst then RED battery
cable and carefully remove battery from tractor.
Install new battery with terminals in same position as
old battery.
First connect RED battery cable to positive (+) terminal
with hex bolt and keps nut as shown. Tighten securely.
Slide terminal cover over terminal
Connect BLACK grounding cable to negative (-) ter-
minal with remaining hex bolt and keps nut. Tighten
securely.
SEAT
TERMINAL
COVER
BOLT
(BED)
NEGATIVE
CABLE
(BLACK)
CABLE
Fig. 30
TO REPLACE
HEADLIGHT
BULB
Raise hood.
Pull bulb holder out of the hole in the backside of the
grill.
Replace bulb in holder and push bulb holder securely
back into the hole in the backside of the grill,
Close hood.
TO REPLACE
FUSE
Replace with 20 amp automotive-type
plug-in fuse. The
fuse holder is located behind the dash,
TO REMOVE
HOOD
AND
GRILL
ASSEMBLY
(See Fig. 31)
Raise hood.
Unsnap headlight wire connector.
Stand in front of tractor. Grasp hood at sides, tilt toward
engine and lift off of tractor.
To replace, reverse above procedure.
HEADLIGHT
WIRE
CONNECTOR
Fig. 31
ENGINE
TO ADJUST
THROTTLE
CONTROL
CABLE
The throttle control has been preset at the factory and
adjustment should not be necessary. If adjustment is nec-
essary, see engine manual.
TO ADJUST
CHOKE CONTROL
The choke control has been preset at the factory and ad-
justment should not be necessary. If adjustment is neces-
sary, see engne manual.
INTERLOCKS
AND
RELAYS
Loose or damaged wiring may cause your tractor to run
poorly, stop running, or prevent it from starting.
Checkwiring. See electrical wiring diagram in the Repair
Parts section.
TO ADJUST
CARBURETOR
Your carburetor is not adjustable. If your engine does not
operate properly due to suspected carburetor problems,
take your tractor to an authorized service center for repair
and/or adjustment.
23
Advertisement
