Page 1: Table Of Contents
Contents Safety belt precautions ........13 Chapter 1 Brief Introduction Protection of safety belt ........15 Safety protection ..........2 Pregnant woman ..........15 Environmental protection ........2 Child restraint system ........16 Regulations of break-in period for new vehicle .. 3 Three-point type seat belt........
Page 2 Brief Indroduction Horn button Sun visor ........29 Turn engine on/off ..........41 Sun visor ............29 Warming the engine up ........42 Vanity mirror ............. 30 Operation of automatic transmisssion错误！未定义书签。 Auxilary handle ..........30 Interior light ............31 Operation of hand brake........
Page 3 Contents How to save fuel and make your vehicle last Front fog light/rear fog light switch ....67 longer, too? ......错误！未定义书签。 Turn signal lamp switch ........68 Chapter 5 Instruments and Controls 58 Headlight switch ..........68 Warning lights system ........60 High beam switch ..........
Page 4 Brief Indroduction Front window defrostter/defogger vent ..... 77 Performance ............97 Temperature control switch ....... 77 Overall .............. 97 Airblower switch ..........78 Case ..............97 Airflow distribution switch ....... 78 Caring for your cassette player and tape ... 97 Internal circulation switch .........
Page 5 Contents Chapter 8 Maintenance and Upkeep 112 Maintenane of battery ........126 Engine compartment ........113 Brake pedal ............. 127 Maintaining & protective measures ....114 Clutch pedal ............ 127 Safety attention ..........115 Hand brake ............127 Checking list for the driver......115 Ternary catalytic converter......
Page 6 Brief Indroduction Front/rear fog lamp ......... 138 Common technical characters ......154 Brake lamp, the third brake lamp ....139 Wheel .............. 155 Reversing lamp /vehicle plate lamp ....139 Tire pressure ........... 155 Rear turn signal lamp ........140 Official VIN of vehicle ........
Page 7: Chapter 1 Brief Introduction
Brief Indroduction Chapter 1 Brief Introduction - 1 -...
Page 8: Safety Protection
Chery authorized waste The earth is our living homeland; every attention to the following matters. disposal institution. one has an unshirkable duty to protect ☆...
Page 9: Regulations Of Break-In Period For New Vehicle
Brief Indroduction ☆ Battery after having being used *Avoid full-speed drive for every gear. Regulations of break-in period contains sulphur and lead. You Break-in regulations between 1000 should not abandon it as common km and 1500 km: for new vehicle household rubbish.
Page 10 Brief Indroduction to drive when the coolant temperature influence the normal use of engine. Drive the vehicle safely! ！Notice: Pay attention to the break-in goes up to normal state, otherwise the It is necessary to drive at low speed, engine will be worn at an earlier stage. during the first 100 km.
Page 11: Explanation On Regular Reminder Indicators Of
Brief Indroduction Explanation on Regular Reminder Indicators of Motor Vehicle Symbols Definition Symbols Definition Symbols Definition Anti-lock brake Door open Parking lamp system (ABS) warning light warning light Glass moving Audible alarm Brake system forbidden switch warning light Low fuel level Rear fog lamp warning light Danger...
Page 12 Brief Indroduction Symbols Definition Symbols Definition Symbols Definition Malfunction Wiper switch Head light switch indicator light/ indicator engine self-check Rear windshield light Horn switch heating-up indicator Discharge warning light ！Notice radiator fan Interior light switch indicator Low oil pressure Outside rearview warning light Windshield...
Page 13: Chapter 2 The Need-To-Know Before Driving
The Need-to-Know before Driving Chapter 2 The Need-to-Know before Driving - 7 -...
Page 14: Keys
The Need-to-Know before Driving with keys from outside. You can turn Keys ！Notice: the key counter-clockwise to unlock Do not leave the key in the vehicle. the door, and turn the key clockwise to 1. Lock the door while you leave the Your vehicle is supplied with three lock the door.
Page 15: Central Control Door Lock System
The Need-to-Know before Driving side of car window. It is to pull the outside door You can lock all the doors except handle outward, if you want to open driver‘s side door from outside, by means of pressing the secured handle, the door from outside.
Page 16: Safety Lock For Children Use
The Need-to-Know before Driving the button of door lock. tongue mounted on lower position of two rear doors‘ locks if you don‘t want ！Notice: to open the rear door from inside. Please lock all the doors and the trunk lid if no body is on watch, before you Inside door handle is fixed in the leave the vehicle.
Page 17: Front Seat Sliding Adjustment
The Need-to-Know before Driving will stop the seatback at that position and make sure the seatback is locked ！Notice: Please use this device when there is a properly. child sitting in the rear row. For it is very dangerous for child opening the ！Notice rear door accidentally, esp.
Page 18: Folding The Rear Seat Backrest
The Need-to-Know before Driving · It is ok to take the head restraint out, Folding the rear seat backrest by means of pushing button of the left guide casing set Fold the backrest down to expand the luggage compartment space, if you want to accommodate large objects.
Page 19: Safety Belt Precautions
Safety belt precautions · In order to make the seat backrest upright, please pull the backrest up, Chery recommends that the driver and then push it to the ―locked‖ position, passengers in the vehicle be properly and confirm it is locked properly.
Page 20 Do not use a influence the operation of safety belt. use, or contact your Chery Authorized Damaged safety belt could not be used Service Station...
Page 21: Protection Of Safety Belt
If the safety belt is not suitable, it may be lead to Chery recommends to replace the belt more severe injury. Protection of safety belt...
Page 22: Child Restraint System
· Fasten it with seat belt or take it away Chery vehicles are all equipped with the front seat, so we recommend you from the vehicle if you do not use it.
Page 23: Using The Seat Belts
！Notice sudden collision or impact. If the seat belts get caught or pinched, rewrap it once more, then take it out until you get desired length (this work should performed Chery - 17 -...
Page 24: Power Window Switch
The Need-to-Know before Driving Adjustment of seat belt altitude: move the tab to the suitable position, ！Notice You can slide the adjustable anchor up fasten your belt. Failure to use seat belt correctly could increase the chance of severe injury. and down, to adjust the seat belt If the belt is not short enough for you, The belt should be kept away from...
Page 25: Glass Forbidden Switch
The Need-to-Know before Driving through the switch. Push the button If the switch is locked, only the driver down if you want to open the window. can control window glass elevation, Pull the switch up if you want to close window glass of the passenger side the window.
Page 26: Outside Rearview Mirror
The Need-to-Know before Driving rearview mirror is a convex mirror Outside rearview mirror with a curved surface. Any object seen in a convex mirror will look nearer Adjust the mirror so you can see both than when seen in a flat mirror; you side of your vehicle in the mirror, can see the roadway behind the vehicle suitable position rearview mirror is...
Page 27: Inside Rearview Mirror
The Need-to-Know before Driving ensure driving safely, please see the ！Notice There are two positions of day and back field of vision with outside In order to keep rear version range of night. Place the lever at ―day‖ position rearview mirror and inside rearview the driver, you can select daylight mirror simultaneously.
Page 28 You should have the airbag disposed you wear seat belts, even if the the chassis maybe damaged, but it and replaced by Chery Authorized deployment of airbag is normal, so it is maybe results in airbag explosion. Service Station. Do not put objects on...
Page 29: Airbag For The Driver
Move the seat backward as authorized permission, you should possible as you can, and seated have these work done by Chery The driver‘s airbag is located in the Special Service Centre. yourself backward as possible as you center flange of steering wheel pad.
Page 30: Engine Compartment Hood
！Notice Do not repair the instrument panel without authorized permission, you should have these work done by Chery 2. Push the buckle backwards; lift the Special Service Centre. engine hood, shown illustrations.
Page 31: Open Trunk Lid
The Need-to-Know before Driving 4. Take the supporting lever out, before operate the open handle of engine following matters while checking the closing the engine hood, press the hood while driving, because not only bottom of engine compartment hood: spacer, in order to avoid vibration of the driver‘s field of version will be Put the transmission to neutral gear, supporting lever and producing noise.
Page 32 The Need-to-Know before Driving vehicle with the trunk lid open. Insert the key to trunk key hole, the Open trunk lid will be opened if you turn the Fuel filler port is located in right side Lock wing of the vehicle. key counter-clockwise, the trunk lid will be closed if you turn the key clockwise, pull the trunk down to...
Page 33 The Need-to-Know before Driving Unlock the interior cap of fuel tank clockwise if you want to open the fuel paint surface, please wash the paint with vehicle key. trunk cap, turn it clockwise if you want surface with cold water as soon as to close the fuel trunk cap.
Page 34: Chapter 3 Operation And Adjustment Of
Operation and Adjustment of Equipment inside Vehicle Chapter 3 Operation and Adjustment of Equipment inside Vehicle - 28 -...
Page 35: Adjustment Of Steering Wheel
Operation and Adjustment of Equipment inside Vehicle Sun visor Adjustment of steering wheel ！Notice: Adjusting steering wheel is strictly forbidden while driving. You Sun visor can be rotated up and down, can drive only after the adjustment is This equipment is designed according performed and the steering wheel is or can be rotated laterally, protect locked properly, otherwise it may...
Page 36: Vanity Mirror
Operation and Adjustment of Equipment inside Vehicle Vanity mirror Auxiliary handle The vanity mirror is mounted on the back of right side sun visor. Auxiliary handle is mounted on the The right side sun visor has same upper position of right front door and function and operation methods as the back row door, it make things left one but not like the left one, the...
Page 37: Interior Light
Operation and Adjustment of Equipment inside Vehicle Interior light Passenger‘s reading light is on the control Door Open right: lamp In order to make things convenient for the passenger, passenger‘s reading light is installed, press to the left if you want to turn it on, press to the right if you want to turn it off.
Page 38: Rear Ceiling Lamp
Operation and Adjustment of Equipment inside Vehicle Shown as the illustration, push the Rear ceiling lamp Front cup holder outer cover of cup holder; you can open it. In order to make things convenient for The cup holder is mounted on the front rear row passengers, rear personal light controls panel;...
Page 39: Front Ashtray
Operation and Adjustment of Equipment inside Vehicle ！Notice: it open completely, shown as the Front ashtray illustrations. To remove the ashtray, Do not touch the heating wire of the pull the ashtray upward. Install the cigarette lighter for it may be catching ashtray in reverse orders.
Page 40: Front Armrest Box
Operation and Adjustment of Equipment inside Vehicle Front armrest box Front armrest box is located between the front seats; you can make the armrest slide both forward backward, according different occupant‘s requests. Push the armrest Armrest box is bi-level, push switch A, frontward or backward;...
Page 41: Glove Box
Operation and Adjustment of Equipment inside Vehicle not leave the valuables in it. Make sure To close: Close the glove box shown ashtray, pull the switch backward, to lock the door and take the valuables as the illustration. shown as the illustration. ！Notice: all with you while you leave the vehicle.
Page 42: Stand-By Power Supply Interface
Operation and Adjustment of Equipment inside Vehicle ！Notice Stand-by power supply This power interface only supports D.C. electrical appliance of 12V interface (Power 120 W), please check the rated voltage and power of the electrical appliance which you want to join up, in order to avoid dangerous accident.
Page 43 Operation and Adjustment of Equipment inside Vehicle vehicle, take the valuables all with you and lock the door. If the lid is forcibly pulled up, the drink may spill over the seat occupants, so do not leave the cup lid open while driving. To use the cup holder, pull the cup holder forward.
Page 44: Chapter 4 Starting Up And Operating
Starting up and Operating Chapter 4 Starting up and Operating - 38 -...
Page 45: Fuel
Chery‘s new vehicle very ground; it is possible to generate performance. Engine damage caused warranty. large amount of static electricity. If you drive your Chery in other by use of improper fuels is not covered Grounding pump pipe countries, be sure to pay attention to under Chery‘s new vehicle warranty.
Page 46: Before Starting The Engine
Starting up and Operating Position 1-Turn off the ignition switch turn the steering wheel slightly, in and the steering wheel is locked. order to relax the locking mechanism In order to lock the steering wheel, of steering wheel. please turn the steering wheel pull out the key, until you hear a click.
Page 47: Turn Engine On/Off
If · Check coolant level. seconds first time not, please contact your nearest Chery · Check brake fluid level. temperature is lower than -12C, you should turn the key to ―1‖ position, Authorized Service Station for service.
Page 48: Warming The Engine Up
Starting up and Operating ！Notice: For the vehicles with CVT P = Parking while stop the car. Turn of ignition R = Reverse Gear switch while the engine is idling. transmission, the gearshift lever must be shifted to N or P position to start the N = Neutral Gear 6.You should not turn off the engine vehicle normally.
Page 49 Starting up and Operating downshift the transmission to the shift the gear selector lever to Drive out Sand and Snow nearest low gear. whichever drive gear. 4. Under manual mode, the up shift The vehicle will travel itself slowly If the drive wheel is entrapped in the can be performed at any vehicle speed;...
Page 50 Starting up and Operating Driving Essentials of Vehicle speed and gear so as to achieve Forced Downshift with Automatic Transmission predominant acceleration capability. under Various Road The automatic transmission can supply Conditions enhanced torque at upward steep Notice: slopes or at overdrive. In order to For small gradient flat roads, it‘s achieve the forced downshift effects, 1.
Page 51 Starting up and Operating of stroke, it‘s impossible to obtain please use gear 1 * under manual mode overheating. At that time, the engine sufficient acceleration horsepower and do not use gear D. It can obtain brake * should be fully utilized to slow (torque), even though it can obtain the immediate acceleration performance the vehicle.
Page 52: Operation Of Hand Brake
Starting up and Operating transmission. The low gear can be on the clutch pedal, shift the lever to Operation manual shifted to only when the vehicle neutral gear, then shift speed is lowered to the speed corresponding low-speed gear, release transmission allowed for downshift.
Page 53: Braking System
Starting up and Operating push releasing button of lever top that will obstruct Braking system down if you want to release hand movement of the pedals and the pad brake. should not be sliding easily. The movement of every pedal should ·...
Page 54 Chery seconds, it is off, while the vehicle together to generate heat, in order to Authorized Service Station, according with ABS system is started. let the moisture evaporate and recover to the regulated mileage in the the braking performance.
Page 55: Brake Servo Unit
―MAX‖ and ―MIN‖ lines. is something wrong with ABS system, greatly to recover the supplement at this time, conventional braking Braking system of Chery vehicle is performance of the brake servo unit. performance is still exist, but you equipped with friction gasket braking...
Page 56: Replacement Of Brake Fluid
5000 km. short time, you should have braking to apply the parking brake securely. system checked and repaired by Chery ！Notice: Brake fluid is poisonous! Be · Shift the selector lever to neutral gear Authorized Service Station, as soon as...
Page 57: Anti-Lock Brake System (Abs)
Starting up and Operating avoid vehicle moving. · Bring the vehicle to a complete stop. operative after vehicle 3. Release the parking brake. accelerated to a speed, it stops 4. Drive the vehicle slowly for a while. ！Notice: It may cause fire because the operating when the vehicle decelerates exhausting parts are very hot, before parking, make sure that there is no...
Page 58: Braking With Anti-Lock Brake System
Contact your Chery providing directional stability and ABS self check Authorized Service Station as soon as steering performance of the vehicle.
Page 59: Steering System
Drive the vehicle cautiously and 1. Parking the car and contact your slowly, if you have to drive through Chery Authorized Service Station as lightly pressing the brake pedal for water, especially you do not know soon as possible.
Page 60 Have all maintenance work done by gasoline. condition or any other abnormal Chery Authorized Service Station. All In the case of vehicle with catalytic phenomenon indicating ignition components...
Page 61 Starting up and Operating · Drive at low speed on uneven road of cruise control system, do not shift to Electrical Cruise Control surface. the idle running status unless the · Keep your tires inflated at the correct clutch pedal stepped down;...
Page 62 Starting up and Operating Also, driver can increase the vehicle Deceleration Setup Button switch B Button switch A speed by stepping down the accelerator pedal as driver would normally. After It can change the speed setting by the accelerator pedal is released, the pressing the button switch B.
Page 63 Starting up and Operating the slide switch A towards the ―RES‖ If the button B is released, the Temporary Turn-Off memory will be cleared if the cruise direction and then the vehicle will speed is lower than 45 km/h. It can drive at constant speed in accordance Resumption re-set the vehicle speed by means of...
Page 64: Chapter 5 Instruments And Controls
Instruments and Controls Chapter 5 Instruments and Controls - 58 -...
Page 65: Instruments And Controls
Instruments and Controls Head light switch Combination meter Turn signal switch Wiper switch Front fog switch Hazard warning light switch Lighting regulation Rear lamp switch switch - 59 -...
Page 66: Warning Lights System
Instruments and Controls please have it checked by your Chery Authorized Service Station. If some Warning lights system warning light is still on or flickering after the engine is started, please have Warning system is used to see if there...
Page 67: Engine Coolant Temperature Gauge
Instruments and Controls as soon as possible. ignition is not on. After filling the fuel Engine coolant temperature tank, the fuel gauge reading will get ！ Notice: When the needle gets into the red zone, it shows that the engine into the new level slowly, when the gauge maybe successive hot.
Page 68: Fuel Warning Light
Instruments and Controls Door Open Warning Light Fuel warning light Engine malfunction indicator light This light remains on until all the doors are completely closed. Please This light comes on when the fuel in check if all the doors are closed the tank becomes nearly empty.
Page 69: Low Oil Pressure Warning Light
！Notice Nevertheless, you should contact with Chery Authorized Service Station for If oil pressure warning light remains on, troubleshooting immediately. it indicates malfunction. You should Engine Malfunction Indicator Light check it to see whether or not it is lack of may comes on briefly and then goes oil.
Page 70: Brake System Warning Lamp
· Check brake fluid level. If necessary, malfunction. If the bulb is normal, you add Chery recommended brake fluid, should check the brake system. It and let the level between ―MAX‖ and...
Page 71: Abs Warning Light
ABS system. But the brake system can ABS warning light will come on and charging system. you should have the still operates normally. In spite of this system checked by the nearest Chery - 65 -...
Page 72: Safety Belt Warning Light
You should have your vehicle checked by Chery Authorized Service Station as When the ignition is in position ―2‖, soon as possible. safety belt warning light will be on, if...
Page 73: High Beam Indicator Light
Instruments and Controls but the green arrow is not on. Position 2: turn on both front fog light and rear fog light, or only turn on the High beam indicator light rear fog light. When the switch is in position 2, the indicator light will be on.
Page 74: Turn Signal Lamp Switch
Instruments and Controls Turn signal lamp switch Turn signal can work only if the ignition is turned on. Move the switch upward, if you want to send out right turn signal. Headlight switch Move the switch downward, if you want to send out left turn signal. The headlight will come on, only if the ！Notice After turning is performed, the switch...
Page 75: High Beam Switch
Instruments and Controls At that time, the light switch should be Be sure to comply with relevant traffic always in ― ‖position. regulations, while above-mentioned turn signal light and illumination equipments. High beam switch After the headlight for high beams Meeting lamp switch comes on, move the lever towards the dashboard direction if you want to turn...
Page 76: Windshield Washer Switch
Instruments and Controls windshield is dry. It may scratch the The wiper has 4 gears, from top to glass and will result in wiper blade bottom; there are automatic updrift, wear too early. automatic downshift, offdrift intervalshift. Windshield washer switch From left to right, interval control of wiper has 4 gears;...
Page 77: Headlight Beam Adjustment Switch
Instruments and Controls Headlight beam adjustment Danger warning light switch switch Press the danger warning light switch on the dashboard, then you can turn Turn on the low beam headlight, adjust the danger warning light on, all the the light beam range to see clear the turn signal lights will come on Rear Window Defroster Switch front way.
Page 78: Digital Clock
Instruments and Controls An indicator light will illuminate to clear.When it snows,wipe snow off the the hour digital will flicker frequently. indicate the defroster is operating. window first,then turn on the rear The digital will increase one hour Push the switch once again to turn the defroster off.
Page 79: Ventilation System And Air
第六章通风和空调系统 Chapter 6 Ventilation System and Air Conditioning System - 73 -...
Page 80 Ventilation System and Air Conditioning System Front windshield defrosting vent Front window defrosting vent Side vent Central vent Foot vent Control panel - 74 -...
Page 81 Ventilation System and Air Conditioning System - 75 -...
Page 82: Control Panel
Ventilation System and Air Conditioning System on the air-blower. Control panel Central vent 1. Airblower switch 2. Temperature control switch Air after adjustment can flow in the 3. Airflow distribution switch vehicle through two central vents; you 4. A/C switch change direction airflow...
Page 83: Front Wiper Defroster /Defogger Vent
Ventilation System and Air Conditioning System side window through this vent; it can get rid of moisture on the glass. Temperature control switch You can adjust the temperature of out-flow air stepless through Front window temperature control switch. When Front wiper defroster /defogger cold-producing system is working, turn defroster/defogger vent switch to the left if you want to...
Page 84: Airblower Switch
Ventilation System and Air Conditioning System while driving, if you want to feel more comfortable. Airblower switch Airflow distribution switch is used to select direction of airflow. Airblower switch has airblower speed There are 4 positions on this switch: Airflow distribution switch under control (There are 4 gears in all), Panel turn the switch in ―0‖...
Page 85: Internal Circulation Switch
Ventilation System and Air Conditioning System Internal circulation switch ！Notice: You‘d better use internal circulation mode in a short time, for successive You can push this switch (the indicator using internal circulation mode will make inside vehicle sweltering and is on), in order to avoid waste gas or make the vehicle window atomizing.
Page 86: A/C System
The strongest refrigeration ） Floor（ To cool off your Chery after it has Air flows out mainly from the floor been exposed in the sun. Make the vents. windows open for a few minutes, which vents the hot air.
Page 87 Ventilation System and Air Conditioning System A/C switch: Press button of A/C Temperature control switch: Turn the Internal circulation switch: Press switch to requested position button of （） Airblower switch: at will Airflow distribution switch: （） Temperature control switch: Turn to ！Notice: Do not use ―the strongest the end counter clock-wise (blue) heating‖...
Page 88 Ventilation System and Air Conditioning System windshield glass. temperature control switch Temperature control switch: Turn to between cold (blue) and warm (red). desired heating position A/C switch: ON/OFF Airblower switch: Put on gear 1 or Air distribution switch: （） gear 2 Temperature control switch: Turn the ！Notice:...
Page 89: Operating Tips
In order to minimize the In order to cool off your Chery after it turned off. running time of air conditioning has been exposed in the sun, you Make sure the air intake grilles in front...
Page 90: Chapter 7 Audio System
Audio System for Songs (Optional) Chapter 7 Audio System - 84 -...
Page 91: Vdo Audio System
Audio System VDO Audio System - 85 -...
Page 92: Vdo Audio Panel Function
Audio System VDO Audio Panel Function - 86 -...
Page 93 Audio System 1. Preset key 1 8. Power switch 13. Preset key 5 RANDOM ： CD random play/stop 9. Display 14. Preset key 4 ： DISC+ Select disc 10.BAND：Wave band 2. Preset key 2 backward SCAN ： Radio frequency 15.►►FF 3.
Page 94: Audio System
Audio System music you are listening to, such as jazz, select sound effect mode you like. pop music, vocal, classical or rock Audio system —BASS (in BASS-TREB mode) music. —TREBLE (in BASS-TREB mode) · Short-time press SOUND key, if you On/off —BALANCE：Volume balance want to select a kind of sound effect...
Page 95: Radio
Audio System plays the next station up or down the known the frequency of desired radio Radio station band. station) Automatic seeking · If you want to enter manual tune-up Wave band To seek a station, push the ―∧‖or ―∨‖ mode: see item ―TUN‖...
Page 96: Cassette Player
Audio System While setting radio station, again. REW/FF (Rewind/Fast forward) —You can begin to listen to the radio ·Press ►►to fast forward a cassette corresponding RDS information and AF mode (on/off) are set together. station set in preset key 1. tape: —...
Page 97: Cd (Compact Disc)
Audio System ·Press ▲key to eject a cassette. ·Press ◄key or►key, if you want to regularly (once or twice every month). select desired programmes. —It begins to play from the selected Caring for your cassette tapes programme. CD (Compact Disc) ...
Page 98: Clock Setting
Audio System hours mode) or ―AM 12:00‖ (12 hours Repeat feature You may change the original setting of · Press and hold RANDOM key at least mode) the player if you like. —Hour digital begins to flicker. 2 seconds, in order to activate or turn ·...
Page 99 Audio System for Songs (Optional) ◄or► [Setting] RADIO [EUROPE，LATAM Select the tuning according to European, Latin American, AMERICA，ASIA] American and Asian standards. Select quantity of preset station, in FMA mode. [6，12，18] Select ‗OFF‘ if you want to turn MW (AM) off. MW（AM）...
Page 100: Audio System For Songs (Optional)
Audio System Audio System for Songs (Optional) - 94 -...
Page 101: Audio Panel Function (Optional)
Audio System for Songs (Optional) Audio panel function (optional) Cassette tape slot Display - 95 -...
Page 102 Audio System for Songs (Optional) 1.Up and down（ and ） station）key DISC key 16.RPT(Repeat）key 9.（） Exit key 17.SCN （ Beginning 2. Function key programme scan）key 10.REW（◄◄Rewind） 3. Knob 18. Preset key 11. PROG 4.A-M（Frequency mode） 19. Function key 2 12.FF（►►Fast Forward）...
Page 103: Performance
Audio System for Songs (Optional) Lock FF/REW Holographic liquid crystal display Performance Permalloy double crack cassette head Monitor mode DIN case Tuning Audio frequency Electric quartz locks PLL tuning Electric frequency control Case AM/FM wave band-: one AM wave band, four FM wave bands. (VOL/BASS/TREB/BAL/FADE) DIN case with ISO supporting capacity 20 FM radio station/5 AM radio station...
Page 104: Operation Method
Audio System for Songs (Optional) You should pay special attention while Radio→cassette Player→CD Operation method using C-90 or prerecording cassettes. Changer→radio 2. Please use cassettes with a total ！Notice: Basic operation playing time of C-30 to C-90. Avoid The operation mode will not be selected if you fail to connect the parts.
Page 105 Audio System for Songs (Optional) BASS→TREB→BAL→FAD-previous Press A-M of key 4, if you want strengthen sound of the left to select ―TREB‖. mode loudspeaker. 2. Turn knob 3 to increase the TREB ！Notice: BASS adjustment clockwise; Turn it counter clockwise to Factory default setting is ―0‖.
Page 106 Audio System for Songs (Optional) →―Z-ENHANCER OFF‖ display mode. →―Z-ENHANCER 1‖…… 3. After adjustment, press A-M of key Press BAND of key 6, at the same 4 until it is in operational mode. Z-ENHANCER 1：Bass enhanced time, press DISP of key 14 for at 2 ：...
Page 107: Cassette Player Operation
Audio System for Songs (Optional) Press stop key 9, and the cassette will Cassette player operation Radio reception be ejected. *The audio system will in radio mode Insert cassette FM reception 4 seconds after cassette being ejected. In order to improve the reception effect, You can turn on the cassette player by the tuning contains signal stimulous inserting a cassette tape.
Page 108 Audio System for Songs (Optional) 3. Use corresponding preset key 18, if selected. Press corresponding preset key 18 you want to select desired radio Use up or down key 1 to select for at least 2 seconds; store the station. desired high or low frequency.
Page 109: Cd Changer Mode Operation Method
Audio System for Songs (Optional) → Press PS key 8,preset memory number from the previous song. Programme number Programme → will flicker; stations will be tuned in at REW/FF time Programme number 7 seconds interval, accordingly. Press  ：Fast forward PS key again to cancel the preset scan Stop (pause) ：Rewind...
Page 110: Rpt (Repeat)
Audio System for Songs (Optional) player will play the next track for 10 programme. process will be continued until you seconds. This process will push the button again to turn off the continued until you push the key again repeat feature. RPT (Repeat) to turn off the scan feature.
Page 111: Baisc Operation Of Record Changer For 6 Cd
Audio System for Songs (Optional) Actual flexibility: 11dBf 8kHz（0+2/-7 dB） *50mm*152mm 50dB non-noise flexibility: 17dBf Power amplifier ！Notice Alternation selection: 70dB Maximum power output: 160W This regulation is up to the EIA standard, we will not inform you Stereophonic sound separation (40W*4 way) separately, if the design and regulation...
Page 112: Operating Guide
Audio System for Songs (Optional) Do not touch the signal side with your finger, while taking CD out. Seat Operating guide 1.2 Eject the CD from the box. 2.2 Put CD in the slot with label side For safety, insert a cassette tape or Eject compact disc into the slot, after 2.3 Push the seat in until it is ok.
Page 113: Specifications
Audio System for Songs (Optional) The slot is very important for the wires while audio system is working, Weight: 1.65Kg player. The parts will be damaged for it will damage the parts. if there is so much dirt in. So, you 5.
Page 114: Caring For Your Compact Disc Player And Discs
Audio System for Songs (Optional) ！Notice or CD with stabilization apparatus. Caring for your compact disc Do not play any other discs, for this They may be pressed inside the player is designed only for CD with mechanism and damage the CD player. player and discs disc mark.
Page 115: Error Display
Audio System for Songs (Optional) Error display In order to protect the system, this player has self-check function. If there is malfunction, it will warn you by means of various error display. Please correct it accordingly to fix the breakdown. Error display Troubleshooting It indicates that there is a malfunction of mechanism of mainframe or CD changer (such as, you cannot...
Page 116: Trouble-Shooting
Audio System for Songs (Optional) Trouble-shooting Phenomenon Cause Troubleshooting Power supply The fuse is blown out. Replace the burnt fuse; use a new one of same amperage. malfunction （or there is no There is something wrong Check the connections of the wires. with the wiring.
Page 117 Audio System for Songs (Optional) Phenomenon Cause Troubleshooting power There is something wrong with the wiring. Please check the wiring. supply There is something wrong with the disc box inserting Insert it correctly. method. Disc box cannot be inserted. Disc box has already been inserted in the player. Let it exit, and insert another one.
Page 118: Chapter 8 Maintenance And Upkeep
Maintenance and Upkeep Chapter 8 Maintenance and Upkeep - 112 -...
Page 119: Engine Compartment
Maintenance and Upkeep Engine compartment - 113 -...
Page 120: Maintaining & Protective Measures
Maintenance and Upkeep Always use solid supports for Maintaining & protective 1.Power steering liquid safety, if it is necessary for you to bank be under the vehicle. In addition, measures 2. Front bin relay box 1 somebody should be with you for 3.
Page 121: Safety Attention
Maintenance and Upkeep it may be running suddenly. distinctively. accident taking place, unless it is Be careful not to touch the running ▪ Be sure to maintain ignition cables, necessary for the ignition to be on. parts with the ignition on. high-pressure cables and high load When the engine is running, keep ！Notice:...
Page 122: You Should Check The Engine Oil Level By The
Maintenance and Upkeep ▪Wheel nuts‘ degree of tightness ▪ Check the instrument or warning Engine compartment ▪ Sensitivity of vehicle operation ▪ Check the engine oil level. light of the indicator. ▪Check to see whether or not there is ▪ Check the fuel gauge, for ▪...
Page 123 Maintenance and Upkeep oil for your vehicle engine. A certain amount of oil is consumed while the engine is running; therefore you You should also check the cleaness of should check the engine oil level at oil on the dipstick; replace oil if the regular intervals.
Page 124: Replacement Of Engine Oil And Filter
Maintenance and Upkeep maintenance). Maintenance Replacement of engine oil and Capacity intervals Filter elements should be replaced, filter Replace it 1.6DOHC-EE479： too, at the same time. every 5,000 3.75L km or 6 TRITEC1.6L477： Replace engine oil according to time months, every and mileage intervals, for engine oil 3,000 km or 3 changes along with the running of...
Page 125: Coolant Level
Service Station assistance, if you want frequent level is satisfactory if it is between ignition off, and contact your Chery refilling. Please check the cooling the ―MAX‖ and ―MIN‖ lines on the Authorized Service Station for system. Please use the recommended anti-freezing agent and coolant by reservoir.
Page 126: Brake Fluid
If the engine is leaking, stop the Brake fluid is hygroscopic, the engine immediately; contact the presence of moisture in the brake nearest Chery Authorized Service fluid will do harm to hydraulic brake Station for consultation as soon as system. Therefore, the brake fluid possible.
Page 127: Gearbox Oil
Make it clean before filling brake shell. You should use Chery recommended fluid. Remove the cap, fill brake fluid Remove the oil filler plug; check the until it reaches ―MAX‖ line of the brake fluid, for brake fluid of any oil level;...
Page 128: Power Steering Fluid Level
Maintenance and Upkeep ！Notice After driving, oil temperature of gearbox may be very high. Please let the gearbox oil and oil filler plug cool before you check the oil level. In order to protect the environment, please deposit the waste oil and container properly to the appointed place.
Page 129: Spark Plug
Maintenance and Upkeep ！Notice had better check the sparking plug, at the spark plug with spark plug If the air filter is not replaced for a regular intervals and remove the spanner. long time, engine performance will not be in a good condition, some carbon.
Page 130: Drive Belt
10mm. If the belt is too loose, please you let it too tight. 2. While have it adjusted and repaired by the removing or tightening the spark nearest Chery Authorized Service plugs, make the sockets aligned with Station. the spark plugs rightly. 3. Install the ！Notice...
Page 131: Windshield Washer Fluid
So ！Notice please Chery recommended windscreen; polishing compound will Solvent, fuel and paint diluent will all detergent. produce strip trace, which influences damage the wiper blade, so you should keep these matters away from your field of version.
Page 132: Maintenane Of Battery
3. In order to clean and tight. protect the environment, have the · If electrolyte leaks, please wash with waste battery disposed by Chery water and soda solution immediately. Authorized Service Station or place Maintenance of battery ·...
Page 133: Brake Pedal
Chery Authorized Service Station or Turn the engine off, step on the brake have it checked by Chery Authorized repair shop. pedal for several times, so as to make Service Station or repair shop.
Page 134: Wheels And Tires
Have all maintenance work done by filler gun to insert. abnormal phenomenon indicating Chery Authorized Service Station. ignition system malfunction occurs, All components of electrical control you should drive at low engine system, injecting system and ignition speed in a short time.
Page 135: Tire Inflating
Maintenance and Upkeep Service Station for consultation and every two weeks at least. And do not hot. After checking, you should be technical support, before you replace forget the spare! Check the tire sure to reinstall the tire inflation with tires and wheels or any other pressures before a long journey, too! valve caps tightly.
Page 136: Tire Condition
Do not let habit. construction, the same type and tread, the tires press concave and convex The tires on your Chery have built-in as originally installed. edge, while you stop the car. tread wear indicators to help you...
Page 137: Exchange Of Tires
Never use wear tires, enough. pressure. second-hand tires or damaged tires on your Chery, for it is very ！Notice dangerous. It will result in accident. It may be disadvantageous for safety and flexibility of vehicle operation if - 131 -...
Page 138: Ignition System
Maintenance and Upkeep you use snow tires. You should use Install the chains on the front tires. Ignition system standard tires of same size and same Don not use chains on the rear tires. model. As long as the road surface condition permits, do not use snow Retighten chains...
Page 139: Replacement Of Fuse
6.Install the miscellany box properly. fuses to make things convenient for ！Notice replacement. If the new fuse immediately blows out, contact your nearest Chery Authorized Service Station Replacement of fuse assistance. Fuse is non-reusable, if...
Page 140: Fuse Box
Maintenance and Upkeep engine rear part. Fuse box Total ABS/ Engine power Starter supply - 134 -...
Page 141: Front Relay Box 1
Maintenance and Upkeep Front relay box 1 Front relay box 2 Lamp relay A/C relay A11-3735035 A11-3735015 Left Left Left Right Right Right high-speed low-speed high position high position relay relay beam lamp beam beam lamp beam lamp lamp lamp lamp Downshift Upshift 30A...
Page 142: Chapter 9 Car Light
Car Light Chapter 9 Car Light - 136 -...
Page 143 Car Light Rear turning lamp/ brake lamp Side turning lamp high-level lamp The third brake lamp Combination headlamp Vehicle plate lamp Front fog lamp Reversing lamp/rear fog lamp - 137 -...
Page 144: Combination Headlight
Driving light is used at dusk, Chery clearly, in order to avoid traffic daybreak or in environment whose accident. visibility is not good. Front/rear fog lamp...
Page 145: Brake Lamp, The Third Brake Lamp
Chery‘s information. The third brake lamp is used for Reversing lamp reminds other drivers supplement. and pedestrian behind you, to know...
Page 146: Rear Turn Signal Lamp
Car Light your Chery‘s driving direction, in rear side know your driving direction. direction. order to avoid unnecessary traffic confusion. You‘d better get out of the vehicle to see road surface condition behind you while backing the vehicle, in order to avoid unnecessary collision Side turning lamp or being caught in soft roadbed.
Page 147: Chapter 10 In Case Of An Emergency
In Case of an Emergency Chapter 10 In Case of an Emergency - 141 -...
Page 148: Tools In The Trunk And Spare Tire
In Case of an Emergency very jack; 3 Be sure not to start the a rubber ribbon. Tools in the trunk and spare tire engine after lifting the vehicle, in case Tools in the trunk include jack, accident takes place; 4 Be sure to use suitable bracket to support the vehicle wheel spanner,...
Page 149: Procedures Of Replacement
In Case of an Emergency ignition key. direction of the flat tire. Rotate Procedures of replacement - Turn on your emergency flashers, jackscrew clockwise by hand, firmly set the parking brake, if until jack top touches the vehicle necessary, put into gear 1 or reverse bottom.
Page 150: In Case Of An Emergency
In Case of an Emergency ！Notice: Do not raise the vehicle too hand. Reinstall the wheel ornament high - Rotate jack handle counter clockwise, If you fail to use the wheel bolts or so as to make the vehicle come back to bolts not being tightened properly, will the ground.
Page 151: Jump Starting The Engine
Chery Authorized Service Do not make battery close to fire vehicle is supported by a jack. 4. Have Station for assistance.
Page 152 In Case of an Emergency electrical appliance. but not flat. Vehicle engine which provide jump Don‘t touch the battery while · Connect one end of the second starting can be normally working jump starting. jumper cable to the negative (-) on during period of jump starting.
Page 153: Towing Vehicle
If towing is necessary. We recommend transmission. Therefore you should contact your nearest Chery adopt lifting front wheels to tow the Authorized Service Station vehicle. The vehicle can be towed by Professional Rescue Centre...
Page 154 In Case of an Emergency fixed on the towing hook tightly. Pull -Put gear lever to neutral gear position, the towing cable to check if it is tight release hand brake. enough. 3. Use rear towing hook to tow other -Place ignition switch on ―II‖...
Page 155 In Case of an Emergency ！Notice: The vehicle may be caught while driving on snow, sand or mud field. Under this circumstance, idling engine will damage the driving elements; therefore, do not drive your vehicle at high speed. - 149 -...
Page 156: Chapter 11 Technical Requirements And Data
Technical Requirements and Data Chapter 11 Technical Requirements and Data (Data in common use, only for reference) - 150 -...
Page 157 Technical Requirements and Data Oils for vehicle use: Engine oil Oil viscosity for this vehicle use is 10W-30 (not lower than grade SG); selected oil viscosity for vehicle use in winter is 5W-30 (not lower than grade SG). We recommend shell brand engine oil according to the actual condition in China at present. Don‘t confuse engine oil of different brands from different manufacturers together.
Page 158: Dimension Of Vehicle
Technical Requirements and Data Dimension of vehicle Length 4573 Minimum ground clearance Width 1682 Approach angle 14.0° Height（Empty vehicle） 1424 Departure angle 18.0° Wheelbase 2648 Camber angle (front wheel) -30′±20′ 1°30′±30′ Front suspension Kingpin caster angel 0′±10′ Rear suspension 1041 Front wheel toe in Front tread 1425...
Page 159: Parameters Of Engine
Technical Requirements and Data Parameters of engine Paramenters of performance Model SQR480ED SQR480EC TRITEC1.6L SQR477F 4-cylinder, in-line, water 4-cylinder, in-line, 4-cylinder, in-line, 4-cylinder, in-line, cooling, in-line overhead water cooling, in-line water cooling, water cooling, Type camshaft overhead camshaft 16-valve, single 16-valve, single overhead camshaft overhead camshaft...
Page 160: Common Technical Characters
Technical Requirements and Data Rated power Maximum torque Rotational speed of rated 5500 5500 6000 6000 power r/min Common technical characters Vehicle model SQR7162L SQR7162TL Fuel capacity（L） Cooling system capacity（L） Engine oil capacity（L） Maximum speed（km/h） - 154 -...
Page 161: Wheel
Technical Requirements and Data Kerb weight（kg） 1130 1170 Total weight（kg） 1505 1545 Wheel Tire model Rim model 185/60 R14 82H 6J 14 Tire pressure Item Front Rear Spare Small spare Empty load/Half load Full load - 155 -...
Page 162 Technical Requirements and Data ！Notice: You should check the tire pressures at least once a month; tire pressure is especially important while high-speed driving. Pressure values listed in the schedule are applicable for cold tire pressure; it is not necessary to reduce the pressure if the pressure slightly goes up while tire being heated.
Page 163: Official Vin Of Vehicle
Technical Requirements and Data Official VIN of vehicle Engine No. Vehicle data plate VIN CODE Vehicle data plate It is mounted on the main body of right Engine No. Engine No. front wheel hood. Engine No is printed on the lower part There is also vehicle data in the Official VIN of engine cylinder.

This manual is also suitable for:

Sqr480ec Tritec1.6l Sqr477f Sqr7162l Sqr7162tl

Chery SQR480ED User Manual

Chapter 1 Brief Introduction

Chapter 2 The Need-To-Know before Driving

Chapter 3 Operation and Adjustment of

Equipment Inside Vehicle

Chapter 4 Starting up and Operating

Chapter 5 Instruments and Controls

Chapter 6 Ventilation System and Air

Conditioning System

Chapter 7 Audio System

Chapter 8 Maintenance and Upkeep

Chapter 9 Car Light

Chapter 10 In Case of an Emergency

Chapter 11 Technical Requirements and Data

Quick Links

Related Manuals for Chery SQR480ED

Summary of Contents for Chery SQR480ED

This manual is also suitable for:

Table of Contents