Table of Contents
Advertisement
VCH SERIES
OVENS
MODELS:
VCH5
ML-126365
VCH8
ML-126366
VCH16
ML-126367
VCH88
ML-126368
VRT SERIES
OVENS
MODELS:
VRT32I
ML-138024
For additional information on Vulcan-Hart or to locate an authorized parts
and service provider in your area, visit our website at
VULCAN-HART
DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC
www.vulcanhart.com
INSTALLATION &
OPERATION MANUAL
©
Vulcan
2009 All Rights Reserved
www.vulcanhart.com
3600 NORTH POINT BLVD.
BALTIMORE, MD 21222
F-38055 (11-09)
Advertisement
Table of Contents
Related Manuals for Vulcan-Hart VCH16 ML-126367
Summary of Contents for Vulcan-Hart VCH16 ML-126367
- Page 1 VRT SERIES OVENS MODELS: VRT32I ML-138024 For additional information on Vulcan-Hart or to locate an authorized parts and service provider in your area, visit our website at www.vulcanhart.com VULCAN-HART 3600 NORTH POINT BLVD. DIVISION OF ITW FOOD EQUIPMENT GROUP, LLC BALTIMORE, MD 21222 www.vulcanhart.com...
-
Page 2: Important For Your Safety
VCH & VRT SERIES OVENS F-38055 (11-09) IMPORTANT FOR YOUR SAFETY THIS MANUAL HAS BEEN PREPARED FOR PERSONNEL QUALIFIED TO INSTALL ELECTRICAL EQUIPMENT, WHO SHOULD PERFORM THE INITIAL FIELD START- UP AND ADJUSTMENTS OF THE EQUIPMENT COVERED BY THIS MANUAL. FOR YOUR SAFETY DO NOT STORE OR USE GASOLINE OR OTHER FLAMMABLE VAPORS OR LIQUIDS IN THE... -
Page 3: Table Of Contents
VCH & VRT SERIES OVENS F-38055 (11-09) TABLE OF CONTENTS IMPORTANT FOR YOUR SAFETY ........1 GENERAL . -
Page 4: General
VCH & VRT SERIES OVENS F-38055 (11-09) GENERAL shipment. Immediately after unpacking, INTRODUCTION check for possible shipping damage to the oven. Vulcan-Hart Ovens are produced with quality workmanship material. If the oven is found to be damaged, Proper installation, usage,... -
Page 5: Electrical Requirements
VCH & VRT SERIES OVENS F-38055 (11-09) diagrams and Specification Chart in the ELECTRICAL REQUIREMENTS back of this manual. ELECTRICAL CODES & STANDARDS: The cord and plug supplied is a suitable durable cord with a proper strain relief. oven must installed accordance with: WARNING: All 110/120 volt ovens are... -
Page 6: Operation
VCH & VRT SERIES OVENS F-38055 (11-09) OPERATION Cooking Time Knobs: CONTROLS Cooking time knobs set the desired cooking time. POWER HOLDING COOKING ON / OFF TEMPERATURE TEMPERATURE Hours knob: 0 to 99 SWITCH & KNOB - LIGHT KNOB - LIGHT Minutes knob: 0 to 99 LIGHT Seconds knob: 0 to 99... -
Page 7: Operating Instructions
VCH & VRT SERIES OVENS F-38055 (11-09) Check that the Oven Circulating OPERATING INSTRUCTIONS Fan(s) are running. Turn On/Off Switch Check that Holding position. On/Off indicator Light Temperature Indicator Light is and Holding Temperature Light illuminated. will illuminate. NOTE: Turn Holding Temperature knob Each Oven is equipped with cooling to desired holding temperature. -
Page 8: Extended Shutdown Instructions
VCH & VRT SERIES OVENS F-38055 (11-09) Turn On/Off Switch to OFF Remove the Interior Side Racks position. Take the Interior Side Racks to a sink or dishwasher for a thorough EXTENDED SHUTDOWN cleaning. Use a mild soap and water solution to clean these Perform the following procedure to shut items. -
Page 9: Maintenance
VCH & VRT SERIES OVENS F-38055 (11-09) Never use any metal tools, the protective film to thicken. This is scrapers, files, wire brushes, unsightly, but is not a sign of permanent or scouring pads (except for damage. stainless steel scouring pads,) which will mar the surface. -
Page 10: Lockout / Tagout Procedure
SERVICE & PARTS INFORMATION To obtain Service and Parts information concerning this model, contact Vulcan-Hart Service Department at the address listed on the front cover of this manual or refer to our website: www.vulcanhart.com... -
Page 11: Troubleshooting
VCH & VRT SERIES OVENS F-38055 (11-09) TROUBLESHOOTING SYMPTOMS POSSIBLE CAUSES REMEDY Oven not connected to Connect oven to power power source source ON/OFF switch not Press Power ON/OFF switch Oven not operating to ON Check circuit breaker No power Check GFCI Moisture problem Dry moisture problem... -
Page 12: Specifications
VCH & VRT SERIES OVENS F-38055 (11-09) SPECIFICATIONS MODEL NEMA SHIP QTY. SIZE DEPTH WIDTH AMPS PLUG HEIGHT WEIGHT VOLTS WATTS VCH8 18" x 26" 2160 18.0 5-15 44.5" 37.25" 26.25" 334 lbs. 8 ea. 12"x20" x 1 1/2" 3800 6-30 1130mm 947mm... -
Page 13: Wire Diagrams
VCH & VRT SERIES OVENS F-38055 (11-09) WIRING DIAGRAMS VCH8 & VCH88 (208 V) Page... - Page 14 VCH & VRT SERIES OVENS F-38055 (11-09) VCH8 (120 V) Page...
- Page 15 VCH & VRT SERIES OVENS F-38055 (11-09) VCH16 (208 V) Page...
- Page 16 VCH & VRT SERIES OVENS F-38055 (11-09) VCH16 (208 V – 3 PH) Page...
- Page 17 VCH & VRT SERIES OVENS F-38055 (11-09) VCH5 (120 V) Page...
- Page 18 VCH & VRT SERIES OVENS F-38055 (11-09) VCH5 (208 V) Page...
- Page 19 VCH & VRT SERIES OVENS F-38055 (11-09) VRT32I (208 V) Page...
Need help?
Do you have a question about the VCH16 ML-126367 and is the answer not in the manual?
Questions and answers