Table of Contents
Advertisement
Quick Links
P/N 506009-02 Rev. C 01/2012
This manual is one of a set of two supporting this product.
Refer to P/N 506010-02 for Care and Operation Instructions.
Ce manuel est disponible en francais, simplement
en faire la demande. Numéro de la pièce 506223-19.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
INSTALLATEUR : Laissez cette notice avec l'appareil.
CONSOMMATEUR : Conservez cette notice pour
consultation ultérieure.
WARNING / AVERTISSEMENT / AVISO
• HOT GLASS WILL CAUSE
BURNS.
• DO NOT TOUCH GLASS
UNTIL COOLED.
• NEVER ALLOW CHILDREN
TO TOUCH GLASS.
WARNING: If the information in these instructions
is not followed exactly, a fire or explosion may
result, causing property damage, personal injury,
or death.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any other
appliance.
- WHAT TO DO IF YOU SMELL GAS:
• Do not try to light any appliance.
• Do not touch any electrical switch; do not use any
phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call the fire
department.
- Installation and service must be performed by a
qualified installer, service agency or the gas supplier.
INSTALLATION INSTRUC TIONS
B-Vent Gas Fireplaces
SLBV 35/40 Models
MODELS
SLBV-35NM
SLBV-35PM
ITS Report No. 100017854
Please read and understand these instructions
• UNE SURFACE VITRÉE CHAUDE
PEUT CAUSER DES BRÛLURES.
• LAISSER REFROIDIR LA SURFACE
VITRÉE AVANT D'Y TOUCHER.
• NE PERMETTEZ JAMAIS À UN ENFANT
DE TOUCHER LA SURFACE VITRÉE.
AVERTISSEMENT : Assurez-vous de bien suivre les
instructions données dans cette notice pour réduire au
minimum le risque d'incindie ou d'explosion ou pour
éviter tout dommage matériel, toute blessure ou la mort.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ :
• Ne pas tenter d'allumer d'appareil.
• Ne touchez à aucan interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bâtiment où vous trouvez.
• Appelez immédiatement votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz,
appelez le service des incindies.
- L'installation et l'entretien doivent être assurés par un
installateur ou un service d'entretien qualifié ou par le
fournisseur de gaz.
MILLIVOLT:
SLBV-40NM
SLBV-40PM
BEFORE starting installation.
• EL VIDRIO CALIENTE
CAUSARÁ QUEMADURAS.
• USTED DEBE NUNCA
TOCAR EL VIDRIO CALIENTE.
• LOS NIÑOS DEBEN NUNCA
TOCAR EL VIDRIO.
ELECTRONIC:
SLBV-35NE
SLBV-40NE
Advertisement
Table of Contents
Related Manuals for Superior SLBV-35
Summary of Contents for Superior SLBV-35
- Page 1 INSTALLATION INSTRUC TIONS B-Vent Gas Fireplaces SLBV 35/40 Models P/N 506009-02 Rev. C 01/2012 This manual is one of a set of two supporting this product. MODELS Refer to P/N 506010-02 for Care and Operation Instructions. MILLIVOLT: ELECTRONIC: Ce manuel est disponible en francais, simplement SLBV-35NM SLBV-40NM SLBV-35NE...
-
Page 2: Table Of Contents
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® TABLE Of CONTENTS PACKAGING WARNING Packaging .........Page 2 The assembled vented gas fireplace is packaged Young children should be care- with the following items: Introduction ........Page 2 fully supervised when they are General Information ......Page 2... - Page 3 SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® GENERAL INfORMATION Installation must conform to local codes, or, in the absence of local codes, with the National (continued) Fuel Gas Code, ANSI Z223.1/NFPA 54 (latest WARNING edition), or the Natural Gas and Propane Instal- lation Code, CAN/CSA B149.1 (latest edition).
-
Page 4: Gas Pressure Requirements
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® ORIfICE SIzES GAS VALVE dIAGRAMS GAS PRESSURE REqUIREMENTS Sea Level to High Altitude (All Models) See Figure 1 for millivolt models and Figure 2 (All Models) for electronic models. -
Page 5: Cold Climate Insulation
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® COLd CLIMATE INSULATION LOCATION Combustion air kits are optional and must be installed before removing the securing screw allowing the movement of the combustion air In selecting the location, the aesthetic and For cold climate installations, seal all cracks actuator arm (see Step 5 on Page 14). -
Page 6: Vent Termination Clearances
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® VENT TERMINATION Termination Heights for Vents Gas Vent Rule CLEARANCES Above flat Or Sloped Roofs Ref. NfPA 54 / ANSI z223.1 Multiple Terminations Roof Pitch * feet * Meters... -
Page 7: Minimum Clearances To Combustibles Appliance And Vent Clearances
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® MINIMUM CLEARANCES TO COMBUSTIBLES At 14" minimum side At 8-1/4" side Appliance and Vent Clearances wall clearance, a wall clearance, a Top View of combustible wall can combustible wall... -
Page 8: Pre-Installation Steps (Remove Glass Enclosure Panel)
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® PRE-INSTALLATION STEPS Step 5. (Page 14) [OPTIONAL]: Install outside supplemental combustion (Remove Glass Enclosure Panel) Header air kit. Spacing Standoff The appliance is shipped with all gas controls... -
Page 9: Fireplace And Framing Specifications
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® fIREPLACE ANd fRAMING SPECIfICATIONS fIREPLACE fRAMING SPECIfICATIONS NOTE: Diagrams, illustrations and Construct framing with 2x4 or larger lumber. photographs are not to scale. Product designs, materials, dimensions, specifications, colors, and prices are subject to change or discontinuance without notice. - Page 10 SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® VERTICAL VENTING THROUGH CEILING frame Ceiling Opening: To locate the center of the vertical run, use a plumb line from the ceiling above the appliance. Flue Outlet for B-Vent Connection: 35 Models = 4 in.
-
Page 11: Step 2. Route The Gas Line
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 2. Route the Gas Line Note: WARNING • All appliances are factory-equipped with Route a 1/2" (13 mm) gas line to either side a flexible gas line connector and 1/2 inch Sharp Edges. -
Page 12: Step 4. Install Field Wiring
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® ON/OFF switch, the switch may be mounted onto the Style View Door per instructions provided in kit. • The gas valve is set in place and pre-wired at... -
Page 13: Wiring Diagrams
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® J-BOX/RECEPTACLE WIRING MILLIVOLT WIRING dIAGRAM J-BOX / RECEPTACLE WIRING 120V, 60Hz, 1PH 120V, 60HZ, 1PH CAUTION: WHEN SERVICING CONTROLS, LABEL ALL WIRES PRIOR TO dISCONNECTION. WIRING ERRORS CAN CAUSE IMPROPER ANd dANGEROUS OPERATION. -
Page 14: Step 5. [Optional] Install Outside
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 5. Install Outside INSTALLATION ACCESSORIES Failure to do so may result in extensive and [OPTIONAL] costly rework. Before the operation of the vent Combustion Air Kit system can be tested, the lever securing screw The following accessory items are available for must be removed. -
Page 15: Step 6. Connect The Gas Line
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 6. Connect the Gas Line Gas Flex Line Connector All codes require a shut-off valve mounted in 3/8" NPT x 1/2" x 3/8" Flare the supply line. The orientation of the shut-... -
Page 16: Step 7. Verify Appliance Operation
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Test All Connections for Gas Leaks Millivolt Appliance Checkout Step 7. Verify Appliance (factory and field) Operation The pilot flame should be steady, not lifting or floating. Flame should be blue in color with... -
Page 17: Step 8. Install Volcanic Stone, Glowing
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 8. Install Volcanic Stone, 4. Place the glowing ember material 5. Install the Logs. (rockwool). Glowing Embers (Rockwool), The logs have locating notches or slots to Note: The bag of Glowing Embers and Logs help ensure that they are properly positioned. -
Page 18: Slbv-35 Log Placement
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® SLBV-35 LOG PLACEMENT INSTRUCTIONS Note: Left Rear Log Right Rear Log • Ceramic fiber logs are FRAGILE! Handle carefully to prevent breakage. • Install volcanic stone and glowing embers BEFORE installing logs. -
Page 19: Slbv-40 Log Placement
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® SLBV-40 LOG PLACEMENT INSTRUCTIONS Note: Ember Chunk • Ceramic fiber logs are FRAGILE! Handle carefully to prevent breakage. Left Rear Log Right Rear Log • Install volcanic stone and glowing embers BEFORE installing logs. -
Page 20: Step 9. Install The Glass Enslosure
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 9. Install the Glass Enclosure Step 10. Burner Air Shutter 3. Install the hood. Note the location of the three clips inside the top air channel above... - Page 21 SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Burner Air Shutter Adjustment Procedure Adjustment Set-Screw Adjustment WARNING Rod Up (fully Open Burner Position) • Air shutter adjustment should only be performed Tube by a qualified professional service technician.
-
Page 22: Step 11. Perform Spillage Test
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 11. Perform Spillage Test After appliance installation, perform this spillage Lintel Screw Hole test to verify proper venting conditions: in Cabinet Top 1 - Place unit in its normally-operated condi- tion, that is, with the glass enclosure panel in place. -
Page 23: Step 12. Install Hood
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 12. Install Hood NOTE: All models must have a hood installed prior to operating. Combustible finished Wall Materials Refer to Figure 30. Install hood by sliding it into 1 in (25 mm) min. -
Page 24: Step 14. Attach Safety-In-Operation Warnings
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Step 14. Attach Safety-In-Operation Warnings It is the installer’s responsibility to ensure these warning labels are properly affixed during installation. These warning labels are a critical step in informing consumers of the safe operation of this appliance. -
Page 25: Gas Conversion Kits
SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® GAS CONVERSION KITS Electronic dEXEN Systems Natural Gas To Propane Gas Conversion Kits WARNING Models Catalog No. SLBV-35 H8268 This conversion kit shall be installed by a qualified service agency in accordance with the manufacturer’s instructions and all applicable codes... - Page 26 SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® All Models Electronic Appliances Burner Assembly Step 8. dexen Electronic Valves: Refer to Note the following: Figure 34 and the instructions pro- Use pipe joint compound or Teflon tape on vided with the kit.
- Page 27 SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Notes NOTE: DIAGRAMS & ILLUSTRATIONS ARE NOT TO SCALE.
- Page 28 SUPERIOR B-VENT GAS FIREPLACES • MODELS SLBV-35, SLBV-40 • INSTALLATION INSTRUCTIONS ® Lennox Hearth Products reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information.