Table of Contents
Advertisement
Quick Links
• Hot! do not touch! the glass and
surfaces of this appliance will be hot
during operation and will retain heat
for a while after shutting off the appli-
ance. severe burns may result.
• carefully supervise children in the
same room as appliance.
• if small children are present in the home, it is
recommended that this appliance be fitted with
a screen door or screen panel kit. see Page 14
for ordering information.
WarninG: iF tHe inForMation in tHis ManuaL
is not FoLLoWed eXactLY, a Fire or eXpLo-
sion MaY resuLt causinG propertY daMaGe,
personaL inJurY or Loss oF LiFe.
For Your saFetY: do not store or use gasoline
or other flammables or liquids in the vicinity of
this or any other appliance.
For Your saFetY: What to do if you smell gas:
• do not light any appliance.
• do not touch any electrical switches.
• do not use any phone in your building.
• immediately call your gas supplier from a
neighbor's phone. Follow your gas suppliers
instructions.
• if your gas supplier cannot be reached, call
the fire department.
installation and service must be performed by
a qualified installer, service agency or the gas
supplier.
US
A French manual is available upon request. Order P/N 725,045CF
Ce manuel d'installation est disponible en francais, simplement en
faire la demande. Numéro de la pièce 725,045CF
WarninGs
otL report no. 6-F-29-5
NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
care and operation
instructions
DIRECT VENT
SSDV-3328 SERIES
direct-Vent Gas FirepLace Heaters
p/n 725,045M reV. n/c 09/2007
MODELS
Millivolt Models
ssdVt-3328cnM
ssdVr-3328cnM
instaLLer: Leave this manual with the appliance.
consuMer: retain this manual for future reference.
aVertisseMent: assureZ-Vous de Bien
suiVre Les instructions donnÉ dans cette
notice pour rÉduire au MiniMuM Le risQue
d'incendie ou pour ÉViter tout doMMaGe
MatÉrieL, toute BLessure ou La Mort.
pour Votre sÉcuritÉ: ne pas entreposer ni
utiliser d'essence ni d'autre vapeurs ou liquides
inflammables dans le voisinage de cet appareil ou
de tout autre appareil.
pour Votre sÉcuritÉ: Que faire si vous sentez
une odeur de gaz:
• ne pas tenter d'allumer d'appareil.
• ne touchez à aucun interrupteur. ne pas vous
servir des téléphones se trouvant dans le bati-
ment où vous vous trouvez.
• evacuez la piéce, le bâtiment ou la zone.
• appelez immédiatement votre fournisseur de
gaz depuis un voisin. suivez les instructions
du fournisseur.
• si vous ne pouvez rejoindre le fournisseur de
gaz, appelez le service dos incendies.
L'installation et service doit être exécuté par un
qualifié installeur, agence de service ou le fournis-
seur de gaz.
Electronic Models
ssdVt-3328cne
ssdVr-3328cne
Advertisement
Table of Contents
Troubleshooting
Related Manuals for Superior SSDVT-3328CNM
Summary of Contents for Superior SSDVT-3328CNM
-
Page 1: Care And Operation
SSDV-3328 SERIES direct-Vent Gas FirepLace Heaters p/n 725,045M reV. n/c 09/2007 MODELS Millivolt Models ssdVt-3328cnM ssdVr-3328cnM instaLLer: Leave this manual with the appliance. consuMer: retain this manual for future reference. aVertisseMent: assureZ-Vous de Bien suiVre Les instructions donnÉ dans cette notice pour rÉduire au MiniMuM Le risQue... -
Page 2: Table Of Contents
In selecting this SUPERIOR Direct-Vent Gas Appliance you have chosen the finest and most dependable fireplace to be found anywhere. A beautiful, prestigious, alternative to a wood burning fireplace. Welcome to a Family of tens of thousands of satisfied SUPERIOR Fireplace Owners. -
Page 3: Gas Controls Access
Manifold Gas supply pressure (millivolt models) Fuel # High natural (Lo) 2.2" Wc (Hi) 3.5" Wc (.55 kpa) (.87 kpa) (Lo) 6.3" Wc (Hi) 0.0" Wc propane (.57 kpa) (2.49 kpa) Table 4 Manifold Gas supply pressure (electronic models) Fuel # Manifold pressure natural Gas 3.5"... -
Page 4: Operation And Care Of Your Appliance
If your millivolt appliance is equipped with an optional remote switch kit (wall switch, remote control or wall thermostat) and the pilot is lit, the appliance main burner may be turned on and off using the optional switch. When using an optional remote switch, turn off the standard OFF/ON switch. -
Page 5: Maintenance
Maintenance (see Maintenance schedule, Page 20) Refer to the maintenance schedule for maintenance tasks, procedures, periodicity and by whom they should be performed. Always verify proper opera- tion of the appliance after servicing. Before re-lighting the fireplace, refer to the lighting instructions in this manual. -
Page 6: Front Glass Enclosure Panel, Removal And Installation
Do not attempt to repaint the appliance until the finish is completely cured (see Burn-In Period on Page 3). If the surface later becomes stained or marred, it may be lightly sanded and touched up with spray paint. Front Glass enclosure panel, removal and installation WarninG do not operate appliance with... -
Page 7: Embers & Logs
instaLL LoGs, VoLcanic stone and GLoWinG eMBers Carefully position the ceramic fiber logs and twigs over the burner according to the following steps, while referring to Figure 7. . Set the rear log on the raised log support brackets at the rear of the firebox, fitting the slots in the logs over the brackets. - Page 8 notes: NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
-
Page 9: Burner Flame Appearance & Sooting
Burner adJustMents (QuaLiFied tecHnicians onLY) Flame appearance and sooting Proper flame appearance is a flame which is blue at the base and becomes yellowish-orange in the body of the flame. When the appliance is first lit, the entire flame may be blue and will gradually turn yellowish-orange during the first 15 minutes of operation. -
Page 10: Millivolt Appliance Checkout
Burner air shutter adjustment adjustment setscrew adjustment rod up (Fully open position) Burner tube air shutter ref. air shutter patent: adjustment rod down u.s. pat. 5,553,603 (minimum air opening position) Main Burner Factory air shutter opening setting - inches (millimeter) Model natural propane... -
Page 11: Wiring Diagrams
We recommend that you record the following important information about your fireplace. Please contact your Superior dealer for any questions or concerns. For the number of your nearest Superior dealer, please call: 1-800-9-LENNOX. - Page 12 notes: NOTE: DIAGRAMS & ILLUSTRATIONS NOT TO SCALE.
-
Page 13: Accessory Components
Cat. Model Ship. Ship.Vol. Wt.(lbs) (inches) H6898 SSDVT-3328CNM 115 lbs 37W x 17D x 36H (13.1 cu.ft). H6899 SSDVT-3328CNE 115 lbs 37W x 17D x 36H (13.1 cu.ft). H6896 SSDVR-3328CNM 115 lbs 37W x 17D x 36H (13.1 cu.ft). - Page 14 H523 LK-400Bs ssdV-3328 * Superior Nameplate Logo, 56L93, is not included. polished Brass & Brushed stainless Louvers Kits These kits include a top 4-louver assembly and a bottom 4-louver assembly. They provide a touch of elegance. These kits can be retrofitted to previously installed appliances.
- Page 15 accessorY coMponents Arch Door Kit - Polished Brass cat. no. Model Fireplace Model 99L56 adK-4B ssdV-3328 Arch Door Kit - Brushed Stainless Steel cat. no. Model Fireplace Model 99L57 adK-4Bs ssdV-3328 arch door Kits The arch door kits are easy to install and do not require hardware to attach them to the standard door frame. The decorative arch kits can not be used in conjunction with the screen panel kit.
-
Page 16: Lighting Instructions - Millivolt
LiGHtinG instructions – HoneYWeLL and sit MiLLiVoLt Gas VaLVe WarninG: iF You do not FoLLoW tHese instructions eXactLY, a Fire or eXpLo- sion MaY resuLt causinG propertY daMaGe, personaL inJurY or Loss oF LiFe. a. This appliance has a pilot which must be lighted with a piezo igniter. - Page 17 INSTRUCTIONS D’ALLUMAGE – VANNE GAZ MILLIVOLT HONEYWELL ET SIT POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE aVertisseMent : si Vous ne suiVeZ pas ces instructions À La Lettre, iL pourrait s’en suiVre un incendie ou AVERTISSEMENT : SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU UNE une eXpLosion causant des doMMaGes MatÉrieLs, des BLessures corporeLLes ou MÊMe des pertes de Vie.
-
Page 18: Lighting Instructions - Electronic
WarninG: iF You do not FoLLoW tHese instructions eXactLY, a Fire or eXpLo- sion MaY resuLt causinG propertY daMaGe, personaL inJurY or Loss oF LiFe. a. When lighting the appliance, follow these instructions exactly. B. BEFORE OPERATING smell all around the appliance area for gas. - Page 19 INSTRUCTIONS D’ALLUMAGE — ELECTRONIC POUR VOTRE SÉCURITÉ, LISEZ CES INSTRUCTIONS AVANT L’ALLUMAGE aVertisseMent : si Vous ne suiVeZ pas ces instructions À La Lettre, iL pourrait s’en suiVre un incendie ou AVERTISSEMENT: SI VOUS NE SUIVEZ PAS CES INSTRUCTIONS À LA LETTRE, IL POURRAIT S’EN SUIVRE UN INCENDIE OU une eXpLosion causant des doMMaGes MatÉrieLs, des BLessures corporeLLes ou MÊMe des pertes de Vie.
-
Page 20: Maintenance Schedule
Maintenance scHeduLe annually (Before the onset of the Burning Season) Maintenance tasK Inspecting/Cleaning Burner, Logs and Controls Check Flame Patterns and Flame Height Inspecting/Cleaning Pilot and Burner Checking Vent System Appliance Checkout Replacing Rockwool Ember Materials periodically (After the Burning Season) Maintenance tasK Cleaning Firebox Interior Check Flame Patterns and Flame... -
Page 21: Troubleshooting Guide - Millivolt
trouBLesHootinG Note: Before troubleshooting the gas control system, Ensure external gas shut off valve, located at gas supply inlet, (and wall switch, iff applicable), is in the “ON” position. Important: Valve system troubleshooting should only be accomplished by a qualified service technician. TROUBLESHOOTING GUIDE - MILLIVOLT GAS CONTROL SYSTEM sYMptoM . -
Page 22: Troubleshooting Guide - Electronic
trouBLesHootinG procedure - eLectronic iGnition sYsteM start • turn off Gas supply. • ensure Valve switch is in on position. • disconnect control Harness. • set thermostat to call For Heat. insert a end View of control Harness connector 24 Volt 24 Volt Hot common 24 Volt... -
Page 23: Replacement Parts List
REPLACEMENT PARTS LIST DESCRIPTION Gas Fireplace Assembly r, (Upper) Lower) Enclosure, Glass Front (Complete) Nameplate (Brand) Catch, Door, Magnetic Log Set (Complete) , r e , r e Orifice, Main Burner Flex Gas Line (Optional) GAS CONTROLS — SIT MILLIVOLT t i n t o l t o l... - Page 24 repLaceMent parts diaGraMs LHP reserves the right to make changes at any time, without notice, in design, materials, specifications, prices and also to discontinue colors, styles and products. Consult your local distributor for fireplace code information. Printed in U.S.A. © 2007 by LHP p/n 725,045M reV.