Oki CX2032MFP Safety And Warranty Manual page 7

Hazardous Ingredients _____________________
Carbon Black (about 4% by weight)
CAS#: Trade Secret.
OSHA PEL: Not established.
ACGIH TLV:Not established.
LD : Not available.
50
LC : Not available.
50
Silica dioxide (about 2% by weight)
CAS#: Trade Secret.
OSHA PEL: Not established.
ACGIH TLV: Not established.
LD : Not Available.
50
LC : Not Available.
50
Physical Data_____________________________
Physical State: Solid.
Melting/Freezing Point: Not available.
Boiling Point: Not available.
PH: Not available.
Vapor Pressure: Not available.
Vapor Density (Air=1): Not available.
Evaporation Rate (Butyl Acetate=1): Not available.
Specific Gravity (H O=1): 1.1 to 1.2 at 20°C (68°F).
2
Solubility in Water: Not available.
Solubility in Solvents: Some components are soluble in
toluene, chloroform and tetrahydrofuran.
Coefficient of water/oil Distribution: Not available.
Appearance and Odor: Black powder, no odor.
Odor Threshold: Not available.
Fire and Explosion Hazard Data_______________
Minimal fire hazard. Large quantities may cause risk of
dust explosion.
Flash Point (Method Used): Not applicable.
Flammable Limits
Lower Explosive Limit: Not available.
Upper Explosive Limit: Not available.
Auto-Ignition Temperature: Not available.
Explosion Data
Sensitivity to Mechanical Impact: Not available.
Sensitivity to Static Discharge: Not available.
Extinguishing Media: In case of small fire, use CO
case of large fire, shut off air by spraying with water or
foam.
Special Fire Fighting Procedures: Fight fire from
upwind position. Avoid inhalation of smoke or gases.
Wear self-contained breathing apparatus.
Hazardous Combustion Products: Carbon monoxide,
oxides of nitrogen.
Toxicological Properties ____________________
Routes of Entry: Inhalation, Ingestion, Eyes, Skin.
Effects of Acute Exposure: Not available.
Effects of Chronic Exposure: Not available.
Exposure Limits: Not available.
Irritancy: Not available.
Sensitivity: Not available.
Carcinogenicity
IARC
Silica Dioxide: Group 3. Not classifiable.
Carbon Black: Group 2B "Possible Carcinogen."
NTP: No components are listed.
OSHA: Carbon black is designated hazardous according
to OSHA 29 CFR 1910.1200.
Reproductive Toxicity: Not available.
Teratogenicity: Not available.
Mutagenicity: Not available.
Name of Toxicologically Synergistic Products: Not
available.
Reactivity Data____________________________
Stability: Stable in general.
Conditions to Avoid: Avoid excess heat and all sources
of ignition.
Polymerization: Will not occur.
Hazardous Decomposition or Byproducts:
Combustion products include harmful gases such as
carbon monoxide and nitrogen oxides.
Incompatibility: Not available.
Preventive Measures _______________________
Personal Protective Equipment
Respiratory Protection: Not normally required. For
large spills, use dust respirator during cleanup.
Protective Gloves and/or Eye Protection: Not
normally required. For large spills, use rubber gloves and
safety goggles during cleanup.
Engineering Controls
Ventilation: Outside of normal ventilation, not normally
required.
Other Protective Equipment and/or Hygienic
Practices: None.
Spill Cleanup
Small Spills
1. Remove sources of ignition.
2. Carefully clean up the spill with a wet cloth, avoiding
inhalation of fine dust.
Large Spills
1. Remove sources of ignition and keep unnecessary and
unprotected personnel away from area.
2. Wear protective gear: respirator, rubber gloves, safety
. In goggles.
2
3. Vacuum the spill, then wipe up remainder with a wet
cloth.
Waste Disposal
• Prevent release of material into natural waters and
sewers.
• Follow appropriate federal, state and local regulations.
• Small amounts can be incinerated.
Careful! Combustion can create harmful gases such
as carbon monoxide and nitrogen oxides.
• Large amounts must be passed to a licensed waste
contractor.
Precautions
Precautions for Handling or Storage: Protect from
the sun. Store in a cool room, under 104°F (40°C). Keep
out of reach of children.
Other Precautions: None.
7 - English