Dometic 630025.331 Installation And Operating Instructions Manual
Dometic 630025.331 Installation And Operating Instructions Manual

Dometic 630025.331 Installation And Operating Instructions Manual

Roof-top heat pump used with 3106152.006 mechanical air distribution box

Advertisement

USA
SERVICE OFFICE
Dometic Corporation
509 South Poplar Street
LaGrange, IN 46761
260-463-4858
CANADA
Dometic Distribution
866 Langs Drive
Cambridge, Ontario
CANADA N3H 2N7
519-653-4390
For Service Center
Assistance Call:
800-544-4881
INSTALLATION & OPERATING
INSTRUCTIONS
Form No. 3309038.002 11/04
(French 3309039.000)
©2004 Dometic Corporation
LaGrange, IN 46761
MODEL 630025.331
Roof-Top Heat Pump
3106152.006 Mechanical Air Distribution Box
This manual must be read and un-
derstood before installation, ad-
justment, service, or maintenance
is performed. This unit must be in-
stalled by a qualified service tech-
nician. Modification of this product
can be extremely hazardous and
could result in personal injury or
property damage.
Important:
These Instructions
must stay with unit.
Owner read carefully.
used with
C
US
Lire et comprendre ce manuel avant de
procéder à l'installation, à des réglages,
de l'entretien ou des réparations.
L'installation de cet appareil doit être
effectuée par un réparateur qualifié.
Toute modification de cet appareil peut
être extrêmement dangereuse et
entraîner des blessures ou dommages
matériels.
1
RECORD THIS UNIT INFORMATION FOR
FUTURE REFERENCE:
Model Number
Serial Number
Date Purchased
Model
630025.331

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the 630025.331 and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Dometic 630025.331

  • Page 1 INSTRUCTIONS Important: Form No. 3309038.002 11/04 must stay with unit. (French 3309039.000) Owner read carefully. ©2004 Dometic Corporation LaGrange, IN 46761 MODEL 630025.331 Roof-Top Heat Pump used with Lire et comprendre ce manuel avant de procéder à l'installation, à des réglages, de l'entretien ou des réparations.
  • Page 2: Safety Instructions

    Read and follow all safety information and instruc- tions. 630025.331 Installation Instructions GENERAL INFORMATION Product features or specifications as described or illustrated are subject to change without notice. B. This Air Conditioner Is Designed For: 1.
  • Page 3 630025.331 Installation Instructions...
  • Page 4: Installation Instructions

    1. Read Installation and Operating Instructions care- fully before attempting to start your air conditioner installation. 2. Dometic Corporation will not be liable for any dam- ages or injury incurred due to failure in following these instructions. 3. Installation must comply with the National Electrical Code ANSI/NFPA-70 and CSA Standard C22.1...
  • Page 5: Roof Preparation

    RV. 630025.331 Installation Instructions FIG. 5 d. If the opening exceeds 14-3/8" x 14-3/8", it will be necessary to re-size the opening to 14-1/4"...
  • Page 6: Wiring Requirements

    Do not slide the unit. This may damage the roof gasket attached to the bottom and may create a leaky installation. 630025.331 Installation Instructions 4. Place the 3106152.006 Mechanical Air Distribution Box Kit. This box contains mounting hardware for the air conditioner and will be used inside the RV.
  • Page 7: Wiring The System

    Push the wires into the box. e. Install the cover onto the junction box. Plug the electrical conduit from the upper unit into the mating switch box connector. See FIG. 630025.331 Installation Instructions WARNING Plug Conduit Into Switch I n s t a l l...
  • Page 8: Operating Instructions

    C. Fan Operation: D. Heating Operation NOTE: The heat pump will not replace a furnace for heating your RV in cold weather. The intent is to warm the coach during mild winter weather. E. "OFF" Position G.
  • Page 9 Air Distribution Box Kit Part and Serial Number found on rating plate located on ceiling tem- plate. Observe this rating plate through the air box filter grill opening. 630025.331 Installation Instructions FIG. 16 Roof Mount Assembly Air Conditioner Roof Opening...
  • Page 10 60 HZ 1 PH USE COPPER USE COPPER CONDUCTORS ONLY ELEC CONN ELEC CONN FROM A/C FROM A/C GRN/YEL 3106220.001 630025.331 Installation Instructions PASSED DIELECTRIC DIELECTRIC 9 PIN CONN 9 PIN CONN GRN/YEL IN-LINE CONNECTOR 3308032.032 FIELD WIRING FIELD WIRING...

Table of Contents

Save PDF