Electrical Battery - DAELIM ET-300 - SERVICE MANUAL BIS Service Manual

Transmission
Oil Drain
•• •••
• ••• • •• • •• • •••• •••
2.Remove the tr ansmission b ox d rain p lug
located on the bottom of the transmission
box on the underside of the unit.
3. R . emove t he t ransmission box f ill hole plug locate
on top of the transmission box on the right hand
side of the engine.
4. A llow the o il to d rain completely (15-30 min).
5. Reinstall the d rain p lug a nd tighten.
Torque to 7-101bf-ft.
6. Fill t he t ransmission box with of SAE 85W-140
gear oil 250cc engine = 650cc /22oz.
7. Reinstall t he f ill hole plug and t orque t o 2-31bf-ft.
8. Dispose of used oil at a proper recycling
station as required by law.

ELECTRICAL BATTERY

Seat Latch
The unit's battery is located under the seat and
supplies electrical power to the unit. The battery
is a 12 volt jell acid type that contains no liquid
electrolyte. The battery should be removed from
the vehicle when stored for extended periods
and charged before being replaced in the unit.
Use a trickle charger set at 12 volts to recharge
the battery to full charge before replacing it in
the unit.
Battery GTX12-BS
When reinstalling the battery, be sure to connect
the red cable to the positive (+) terminal and the
black cable to the negative (-) terminal.
The battery should be replaced every three years
or when it no longer holds a charge.
Do not expose the battery, for extended periods of
time, to freezing temperatures. If the battery has
been frozen it will need to be replaced. There are
inline fuses on the positive lead of the battery to
protect the wiring system from over loads. If your
starter motor will not turn over and the battery is
fully charged, check the inline fuse on the unit.
Amperage
Color
Rating
15A
10A Red
Green
30A
15A
For anothers series items of electrical units,
please refer to the fuse as shown in list.
Series Items
Blue
Head Lamp
Fan Motor
Battery
Position Lamp
Stop&Tail Lamp
Blue
License Lamp
Illumi Lamp
Winke Lamp