Engine Warter Cooler; Checking Coolant Lever; Replenishment Of Coolant; Replenishment Of Anti-Freeze - DAELIM ET-300 - SERVICE MANUAL BIS Service Manual

ENGINE WARTER COOLER

The engine coolant is cooled by an external
radiator located at the front of the unit. It is
important that the radiator fins be kept free of
dirt build up to prevent the engine from over
heating which can cause sever damage to the
engine. Remove any build up of dirt or mud from
the radiator fins with a pressurized spray of water.
Maintaining the coolant will allow the cooling
system to work properly and prevent freezing,
overheating,and corrosion.
Checking Coolant
Main radiator cap
Reserved tank
1.Stops ATV in the level place.
2.Remove the front cover.
3.Check reserved tank from viewing window
to see if coolant level is between the upper
limit and lower limit mark.
4.Add coolant up to upper mark if coolant is
close to the lower mark.
WARNING: The radiator coolant is under pressure
when hot. NEVER REMOVE the radiator cap until
the unit has cooled for at least 1 hour or server
injury or burns may result!

Replenishment Of Coolant

1.Park the vehicle on level ground.
2.Remove the front cover.
a.Open reserved tank cap, refill coolant
until reaches the upper limit.
b.To avoid radiator getting rusty, do not use
coolant other than those recommended.
Lever
Reserved tank cap
Upper
Lower
PLEASE PAY SPECIAL ATTENTION that using
poor quality coolant may shorten the service life
of the radiator.
Concentration:50%.(Use distilled water when
mixing coolant)
Radiator capacity: Main radiator:800c.c.
Reserved tank:350c.c.
Coolant should be changed once a year normally.
Removing the radiator cap while the engine is
hot can cause the coolant to spray out,seriously
scalding you.Always let the engine and radiator
cool down before removing the radiator cap.

Replenishment Of Anti-freeze

Please refer to table showing what percentage
of anti-freeze should be used under different
temperatures if the vehicle is to be operated in
the low temperature areas.(below 0 c)
A reference table for anti-freeze concentration
percentage under differert temperatures
1.Radiator anti-freeze specification for this ATV
is H68.
2.Proper anti-freeze percentages for different
frozen temperatures are as follows:
3.If the specified anti-freeze is unavaiable,use
an equivalent with the same high quality.
4.Increase radiator maintenance intervals
when the weather is extremely cold.
Anti-freeze percentage Freezing temperature
20%
30%
40%
50%
50% CONCENTRATION is used for all ATV
before delivery to ensure the effectiveness
of anti-freeze.

Check Cooling System For Leaks

If low coolant levels occur often or if coolant is
seen under unit after being parked it may indicate
a leak in your coolant system.
Inspect radiator and piping for leaks and damage.
Replace or repair any leaking radiator and piping
before starting the engine.
o
-8
-15
-24
-36