Element4 Summum 140 3 Installation, Operation And Owner's Manual

Direct vent gas fireplaces

Advertisement

Quick Links

HOT GLASS WILL
CAUSE BURNS.
DO NOT TOUCH GLASS
UNTIL COOLED.
NEVER ALLOW CHILDREN
TO TOUCH GLASS.
A barrier designed to reduce the risk of burns from the hot viewing glass is provided with this appliance and shall be installed
for the protection of children and other at-risk individuals.
Une barrière conçu pour réduire le risque de brûlure par le verre de visualisation chaude est fournie avec cet appareil et doit
être installé pour la protection des enfants et autres personnes à risque.
WARNING:
FIRE OR EXPLOSION HAZARD
Failure to follow safety warnings exactly could
result in serious injury, death, or property damage.
- Do not store or use gasoline or other flammable
vapors and liquids in the vicinity of this or any
other appliance.
- WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switch; do not
use any phone in your building.
• Leave the building immediately.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call
the fire department.
- Installation and service must be performed
by a qualified installer, service agency or the
gas supplier.
INSTALLER: Leave this manual with the appliance.
CONSUMER: Retain this manual for future reference.
Element4 Gas Fireplaces Rev#03242020
Installation, Operation and Owner's Manual
Summum 140 F
Summum 140 LC/RC
Summum 140 3/S
Summum 140 R
Summum 140 T
Direct Vent Gas Fireplaces
AVERTISSEMENT:
INCENDIE OU D'EXPLOSION
Le non-respect des avertissements de sécurité à la
lettre pourrait entraîner de graves blessures , la mort
ou des dommages matériels.
- Ne pas entreposer ni utilizer d'essence ni d'autres vapeurs
ou liquides inflammables dans le voisinage de cet appareil
ou de tout autre appareil.
- QUE FAIRE SI VOUS SENTEZ UNE ODEUR DE GAZ
• Ne pas tenter d'allumer d'appareil.
• Ne touchez á aucan interrupteur. Ne pas vous servir des
téléphones se trouvant dans le bátiment ou vous trouvez.
• Quitter immédiatement le bâtiment.
• Appelez immédiatment votre fournisseur de gaz depuis
un voisin. Suivez les instructions du fournisseur.
• Si vous ne pouvez rejoindre le fournisseur de gaz
appelez le service des incindies.
- Installation et l'entretien doivent être effectués par un
installateur qualifié, une agence de service ou le fournisseur
de gaz.
INSTALLATEUR: Laissez cette notice avec l'appareil.
CONSOMMATEUR: Conservez cette notice pour
consultation ultérieure.
1
4006611
Une surface vitrée chaude
peut causer des brûlures.
Laisser refroidir la surface
vitrée avant d'y toucher.
Ne permettez jamais á un enfant
de toucher la surface vitrée.
March 2020
EuropeanHome.com

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Summum 140 3 and is the answer not in the manual?

Questions and answers

Summary of Contents for Element4 Summum 140 3

  • Page 1 Installation, Operation and Owner’s Manual Summum 140 F Summum 140 LC/RC Summum 140 3/S Summum 140 R Summum 140 T Direct Vent Gas Fireplaces HOT GLASS WILL Une surface vitrée chaude CAUSE BURNS. peut causer des brûlures. DO NOT TOUCH GLASS Laisser refroidir la surface UNTIL COOLED.
  • Page 3: Table Of Contents

    Key Installation Points ......................7 Planning Your Gas Fireplace....................8 User Information ........................10 Specifications and Dimensions ..................11 Summum 140 F Summum 140 LC Summum 140 RC Summum 140 3/S Summum 140 R Summum 140 T Parts of the Fireplace Clearances ..........................20...
  • Page 4: Important Safety Information

    Do not place furniture or other objects within 36” of the fireplace glass. SAVE THESE INSTRUCTIONS Make yourself fully aware of all the following instructions and the many features of the Element4 direct vent gas fireplace appliance. INSTALLER: Leave this manual with the appliance.
  • Page 5 : Glass Handling jurisdiction for gas product installations to determine their specific requirements for high altitude installations. The glass must only be removed by a qualified person. Gloves should be worn when removing the glass. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 6 For convenience, the inches are rounded to the nearest 1/16” when converted. If greater accuracy is DO NOT USE abrasive cleaners on the panels. DO NOT required, use the metric dimensions. ATTEMPT to clean the glass panels when they are hot. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 7: Key Installation Points

    Gas pressures MUST be read with a manometer and confirmed with what is required in the installation manual. FINISHING 1/8” gap between the flange and the enclosing wallboard MUST be maintained to prevent cracking from heat expansion and contraction. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 8: Planning Your Gas Fireplace

    PLANNING YOUR GAS FIREPLACE Before You Begin Since the Element4 fireplaces are vented gas appliances they must be installed by a qualified installer. • Your sales representative can help you choose the appropriate professional. Overall Design • One of the many features of the Element4 fireplace is its use of convective air flow.
  • Page 9 If the venting falls outside of the vent graphs, a power vent is available. • The next question to ask is, “Can I get my gas pipe to the fireplace?” The Element4 fireplaces burn either Important Points natural gas (NG) or propane gas (LP.) Your sales representative will ask you for your requirement at the •...
  • Page 10: User Information

    WARMTH AND BEAUTY - HOW IT WORKS The Element4 fireplaces are direct vent fireplaces and, as such, the intake and exhaust are both handled through the vent pipe. The fireplace also provides convection air to your room. The illustration shows one of the unique features of the Element4 fireplaces - its use of warm, convection air flow.
  • Page 11: Specifications And Dimensions

    A sample listing label image is shown A - 12 Volt Adaptor above. A metal listing label is attached B - Receiver/Control Module to every Element4 fireplace and contains C - 6 Volt Adaptor important certification information. The D - LED Module...
  • Page 12: Summum 140 F

    This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Figure 6 Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com www.EuropeanHome.com PDE4B95MKII-170807 A downloadable DWG file is available at www.europeanhome.com for dimensions not shown. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 13: Summum 140 Lc

    Figure 7 Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com Summum 140 LC shown. Summum 140 RC is a mirror image. www.EuropeanHome.com A downloadable DWG file is available at www.europeanhome.com for dimensions not shown.
  • Page 14: Summum 140 Rc

    This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com Summum 140 RC shown. Summum 140 LC is a mirror image. www.EuropeanHome.com A downloadable DWG file is available at www.europeanhome.com for dimensions not shown.
  • Page 15: Summum 140 3/S

    This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Conversions from millimeters are rounded to the nearest fraction. A DWG file is available at www.europeanhome.com www.EuropeanHome.com PDE4B95MKII-170807 A downloadable DWG file is available at www.europeanhome.com for dimensions not shown. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 16: Summum 140 R

    This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Figure 10 Conversions from millimeters are rounded to the nearest fraction. This DWG file is available at www.europeanhome.com SUMMUM 140 R PDE4L140RDMKII-170803 A downloadable DWG file is available at www.europeanhome.com for dimensions not shown. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 17: Summum 140 T

    This information is for reference only. Please consult the Installation Manual for all details prior to making any design decisions. Conversions from millimeters are rounded to the nearest fraction. This DWG file is available at www.europeanhome.com Figure 11 SUMMUM 140 T PDE4L140TMKII-170803 A downloadable DWG file is available at www.europeanhome.com for dimensions not shown. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 18: Parts Of The Fireplace

    SPECIFICATIONS and DIMENSIONS PARTS OF THE FIREPLACE The various parts of the 140 Series fireplaces are shown below. These parts are typical of any Element4 fireplace. 14 14 13 13 Figure 12 Table of Fireplace Parts Outer Frame Face - surrounds the glass panels and limits the non-combustible wall board Exterior Glass Panel(s) - (1 ea.) 140 F, 2 ea.
  • Page 19 SPECIFICATIONS and DIMENSIONS 13 13 Figure 14 Fireplace from below Table of Fireplace Parts Support Feet - four adjustable feet allow the fireplace to be levelled Pilot Assembly Figure 15 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 20: Clearances

    YOUR RESPONSIBILITY TO ENSURE THE SAFETY OF THESE CRITICAL COMPONENTS THROUGHOUT THE INSTALLATION CRITICAL COMPONENTS THROUGHOUT THE INSTALLATION PROCESS. REMOVE AND DISPOSE OF ALL WRAPS AND TIES. PROCESS. REMOVE AND DISPOSE OF ALL WRAPS AND TIES. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 21: Clearances To Combustibles

    We recommend that the fireplace be set into its final location before building the enclosure. Please refer to the “Reduced Clearance to Existing Combustible Wall” section for use of combustibles inside of the above clearances. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 22: Mantel Clearances

    Mantel Depth NON COMBUSTIBLE 12” (300 mm) MATERIAL CONSTRUCTION BEAMS NON- COMBUSTIBLE (TYPICAL) DETAIL C ETAIL C 1” (25 mm) ALE 1 : 10 TOP OF FIREPLACE OPENING GLASS CONVECTION GAP Figure 19 Figure 20 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 23: Convection Clearances

    Air Outlet Area by Model Minimum Distances Square Square Model Inches Centimeters Room ceiling to 72” Summum 140 F appliance bottom 1830 Summum 140 C Figure 22 Summum 140 3/S Summum 140 R Summum 140 T Figure 23 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 24: Gas And Electric

    Remove batteries after use to avoid battery corrosion. Battery corrosion will damage the receiver. Electrical work must be performed by a qualified, licensed electrician. WARNING All wiring shall be in compliance with all local, city, and state codes. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 25: Venting

    EXCELDirect (ICC - Industrial Chimney Company) Pro-Form (BDM - Bernard Dalsin Manufacturing) Direct-Temp (Selkirk Corporation) AmeriVent Direct Vent (Hart & Cooley Inc.) Ventis Direct Vent (Olympia Chimney Supply, Inc.) Figure 25 Please visit www.europeanhome.com/technical-support/ for the power venting installation manuals Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 26 Calculate the Total Vertical Section by adding up all vertical (upward) sections in your vent design. CALCULATING THE TOTAL HORIZONTAL SECTION (THS) Calculate the Total Horizontal Section by adding up all horizontal sections in your vent design. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 27 Loosen the screws on either side and slide the restrictor as desired. Do not modify the restrictor(s). Please use the graph above to determine if you will need to use a restrictor. Loosen these two Phillips head screws to slide the restrictor on/off. Figure 32 Figure 31 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 28: Venting Charts

    5' (1.5 m) 6'-7" (2 m) 8'-3" (2.5 m) 9'-10" (3 m) 11'-6" (3.5 m) 13'-2" (4 m) Figure 34 configuration allowed, no restrictor required configuration allowed, 35mm restrictor required configuration NOT allowed Figure 35 ments Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 29: Venting Clearances

    VENTING CLEARANCES HORIZONTAL VENT TERMINATION CLEARANCES AND REQUIREMENTS Figure 36 Figure 37 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 30 National Fuel Gas Code (ANSI Z223.1 in the USA) or the current standard of CAN/CSA-B149.1 in Canada. Figure 38 Figure 39: Termination Heights A second termination may be no closer than 12”/305 Figure 40: Multiple Termination Clearance Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 31: Enclosing The Fireplace

    Figure 41: * The listed brand names are trademarks of their respective companies. Skamol Americas, Inc. (844) 475-2665 E-mail: skamotec225@skamol.com www.skamotec225.com Promat Inc. (865) 681-0155 E-mail: sales@promat.us www.promat.us/en James Hardie Building Products (888) 542-7343 www.jameshardie.com Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 32 ENCLOSING the FIREPLACE BUILDING THE ENCLOSURE/FRAMING A safe installation of your Element4 fireplace requires that three things be clearly understood. 1. Most important, these fireplaces are NOT zero-clearance fireplaces. Unlike zero-clearance fireplaces, there is not an outer metal box around the Element4 fireplaces which increases the framing dimensions.
  • Page 33 Gap MUST BE Gap MUST BE MAINTAINED MAINTAINED 1” (25 1” (25 Minimum Air Gap MUST BE MAINTAINED Minimum Air Gap MUST BE MAINTAINED Figure 42 OMbuSTIbLE hIELd INIShEd hIELd INIShEd OMbuSTIbLE Figure 44 Figure 45 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 34: Rough Opening Dimensions

    When enclosing the Summum 140 C fireplace there is a minimum clear area which must be maintained. Nothing except the Summum 140 may be within this area. When enclosed, the Summum 140 LC is against the left wall or the Summum 140 RC is against the right wall.
  • Page 35 (A, B and C) shown above. Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 36 (A, B and C) shown above. Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 37 (A, B, C, D and E) shown above. Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. We recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 38 (A, B, C, D and E) shown above. Your installation will use more than this minimum cabinet space in order to accommodate controls, venting, air openings, etc. We recommend that the fireplace be set into its final location before building the enclosure. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 39 James Hardie Building Products HardieBacker® 500 1/2” Cement Board 1/2” (12 James Hardie Building Products HardieBacker® 1/4” Cement Board 1/4” (6 Figure 51 Fireplace Trim Figure 53 Minimum Wall Thickness = 1/2” (12 Figure 52 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 40: Convection Air Opening

    Figure 59: Summum 140 3/S with Air Outlet Area by Model Air Outlets in Wall Air Outlet in Reveal Square Square Model Inches Centimeters Summum 140 F Summum 140 C Summum 140 3/S Figure 60 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 41 (angled ceiling in enclosure helps heat move up through chase) Figure 62: Summum 140 R with Endwall Outlets Warm Air Outlet Area by Model Model Square Inches Square Centimeters Summum 140 R Summum 140 T Figure 63 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 42 Summum 140 3/S 3-Sided Figure 64 Use the adjustable feet to ensure that the fireplace is level prior to enclosing it. Do NOT lift the fireplace by the face frame but by the bottom of the cabinet. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 43 These MUST be loosened by one turn BEFORE the appliance is fired. Figure 66 Use the adjustable feet to ensure that the fireplace is level prior to enclosing it. Do NOT lift the fireplace by the face frame but by the bottom of the cabinet. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 44: Cold Climate Installation

    39” 39” Figure 68 12” 9” When measured at the level of the feet, the controls will reach no farther from the cabinet edge than shown. The drawing is not to scale. 39” Figure 69 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 45 Once the system stays lit for at least one full minute, turn the fireplace off, fix the glass panels in place and operate the fireplace for at least 45 minutes to ensure the system works properly when heated. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 46: Installing The Fire Media

    - Three bags of black chips - Three bags of grey chips Real Flame burners are elevated rectangles. The specific logs (1, 3, 4, and 7) have recessed notches so they fit perfectly over each burner. Figure 73 Figure 74 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 47: Screen Installation

    Figure 82: Short Screen Place the two Lower Tabs on the trim, with the short side against the glass, about 2-3” from each corner of the glass. Place a magnet on the front of each tab. Figure 84 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 48 Figure 86 This is what the screen will look like when it is attached correctly to the Upper Tabs (view from inside of the standoff frame). Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 49 This is what the screen will look like when it is attached correctly to the Lower Tabs (view between the screen and the glass). Figure 88 The screen is installed properly in the photo above. Please make sure that all magnets are in the correct position and the tabs are secured. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 50: Operating The Fireplace

    ON when the fireplace is Figure 90 turned on. Note! For normal operation the MANUAL knob on the gas valve cannot be in the MAN position; it must be fully in the ON position. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 51 OPERATING the FIREPLACE Figure 91 Figure 92 Figure 93 Figure 94 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 52 OPERATING the FIREPLACE Figure 96 Figure 97 Figure 95 Figure 98 Figure 99 Figure 100 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 53 OPERATING the FIREPLACE Figure 102 Figure 101 Figure 104 Figure 103 Figure 105 Figure 106 Figure 107 Figure 109 Figure 108 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 54 OPERATING the FIREPLACE Figure 110 Figure 111 Figure 112 Figure 113 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 55 OPERATING the FIREPLACE Figure 114 Figure 115 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 56 • CHILD PROOF (To activate press buttons simultaneously. displayed and the handset is rendered inoperable (except for off functi- on). • PROGRAM MODE • THERMOSTATIC MODE (also deactivates Program Mode) • ECO MODE • MULTI-BURNER FEATURE • COUNTDOWN TIMER Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 57 Since it is a metal fireplace, the heat-up and cool-down cycles may produce some noises caused by the expansion and contraction of these metals. The premium materials and build quality of your fireplace will keep these sounds to a minimum. Figure 117 To see an Element4 fireplace starting and running normally please visit the link below. WWW.EUROPEANHOME.COM/RESOURCES/VIDEOS/ Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 58: Maintenance

    PANEL(S) BEFORE LIGHTING THE FIRE! Remove the ROPE GASKET starting from one end down to the other end To see how to remove the glass from an Element4 fireplace please visit the link below. WWW.EUROPEANHOME.COM/RESOURCES/VIDEOS/ Figure 121 The ROPE GASKET will be...
  • Page 59 Adjust the remaining glass panels left to right until there is no corner gap. Step 4. While ensuring that the glass panels are tight and square to each another, carefully install the remaining rope gaskets. PROPERLY PLACE ROPE GASKET(S) AND SEAL THE GLASS PANEL(S) BEFORE LIGHTING THE FIRE! Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 60: Burner

    The pilot has two distinct flames, one engulfing the thermocouple on its left, the other reaching across to the burner. The area around the pilot should be inspected for cleanliness. Lint or foreign material must be removed with a brush or vacuum. Figure 122 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 61: Thermocouple

    MAINTENANCE THERMOCOUPLE MAINTENANCE The Element4 fireplaces have two thermocouples; one next to the pilot and one opposite the pilot side of the burner. The completeness and operation of both must be checked. A qualified installer must confirm that both thermocouples are in place and not damaged.
  • Page 62: Replacement Parts

    Front Glass (Long) E4-GLASS-140-FRONT Side Glass E4-GLASS-140-SIDE-02 Safety Screen E4-SS-5616-IM and E4-SS-1613-IM All Tabs with Magnets (Kit) E4-SA-SS-HWK-5/15 Lower and Side Trim Repl-E4-TRIM-BID-140-MKII-02 Foot with nut Repl-E4-CP-FT Hearth Panel Repl-E4-CP-HEARTH-140-SUM Hearth Panel Screws Repl-E4-CP-HPS-01 Figure 124 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 63 Part Number Item Desription (Required) (Each) Glass E4-GLASS-140-FRONT Safety Screen E4-SS-5416-IM All Tabs with Magnets (Kit) E4-SA-SS-HWK-3/9 Lower and Side Trim Repl-E4-CP-TRIM-MOD-140-02 Foot with nut Repl-E4-CP-FT Hearth Panel Repl-E4-CP-HEARTH-140-SUM Hearth Panel Screws Repl-E4-CP-HPS-01 Figure 126 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 64 Front Glass (Long) E4-GLASS-140-FRONT Side Glass E4-GLASS-140-SIDE-02 Safety Screens E4-SS-5616-IM and E4-SS-1613-IM All Tabs with Magnets (Kit) E4-SA-SS-HWK-7/21 Lower and Side Trim REPL-E4-CP-TRIM-TRI-140-MKII Foot with nut Repl-E4-CP-FT Hearth Panel Repl-E4-CP-HEARTH-140-SUM Hearth Panel Screws Repl-E4-CP-HPS-01 Figure 128 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 65 Repl-E4-GP-LC-2GCS-01 (w/ screws) Window Clamp Screws Repl-E4-GP-GCS-01 Glass Clamp Screws Repl-E4-GP-GCS-01 Foot with nut Repl-E4-CP-FT Foot with Nut Repl-E4-CP-FT Hearth Panel Repl-E4-CP-HEARTH-LUC-140-MKII Hearth Panel Repl-E4-CP-HEARTH-140-SUM Hearth Panel Screws Repl-E4-CP-HPS-01 Hearth Panel Screws Repl-E4-CP-HPS-01 Figure 130 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 66 Hearth Panel Repl-E4-CP-HEARTH-140-SUM Hearth Panel Screws Repl-E4-CP-HPS-01 Hearth Panel Repl-E4-CP-HEARTH-LUC-140-MKII Long Glass Clamp Repl-E4-GP-LC-2GCS-01 Hearth Panel Screws Repl-E4-CP-HPS-01 (w/ screws) Long Window Clamp Glass Clamp Screws Repl-E4-GP-GCS-01 Repl-E4-GP-LC-2GCS-01 (w/ screws) Figure 132 Window Clamp Screws Repl-E4-GP-GCS-01 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 67 Figure 134 Figure 135 DETAIL DETAIL SCALE 2 : 7.5 SCALE 4 : 7.5 Item Description Quantity Part Number Pilot Assembly E4-GS-PABT-01 Ignitor Rod E4-GS-TIBT-01 1st Thermocouple E4-GS-1T-01 2nd Thermocouple E4-GS-2TC-01 LEDs E4-GS-SUM-LED Figure 136 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 68 2nd and 3rd Burner 5a-b 4th and 5th Burner Pilot Assembly E4PGS-PABT-01 Second Thermocouple E4-GS-2TC-01 Quad Burner Module E4-GS-BM-01 LED Module E4-GS-BM-SUM-01 Wifi-Box (Optional) E4-GS-Wifi Figure 138 LED Light System E4-ES-LED-SUM 10 Button Remote Repl-E4-GS-RC-10B-02 Figure 139 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 69: Warranty

    Model Summum 140 F 140 C 140 3/S 140 R 140 T (check one) Purchased From Date of Purchase Installed By Date of Installation Fireplace Serial Number Fuel Type Total Venting Horizontal Total Venting Vertical Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 70: Massachusetts Certification

    This appliance is approved for installation in the Commonwealth of Massachusetts. The following must be observed when installing the Element4 fireplaces within the Commonwealth of Massachusetts: (a) For all side wall horizontally vented gas fueled equipment installed in every dwelling, building or structure used in whole...
  • Page 71: Troubleshooting Flowchart

    Confirm proper connection/operation of latching sound. SW-cable the SW-cable at gas valve and receiver. disconnected. Motor not operating Replace gas valve. properly. Micro switch not Replace gas valve. operating properly. (continued) Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd...
  • Page 72 Check that ceramic seen) shield or ignition wire is not defective. Short between interrupter block and TC- Check connection to interrupter block. cable. Sparking stops after pilot is lit. Electronic measuring amplifier defective. Replace the receiver. (continued) Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 73 Manual knob is in the “MAN” position. positive latch is required. Main burner is lit. Confirm correct gas pressure. Increase pilot Pilot flame is too low. flame if necessary. (continued) Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd...
  • Page 74 Test the batteries, replace if necessary. Receiver batteries low. Quality 1.5V AA alkaline recommended. Magnet unit drops Ensure magnet unit is operating while motor turns. Test the receiver output to the magnet unit. normally. Receiver makes 3 beeps. (continued) Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 75 Check venting for complete integrity. Reduce the primary air opening until flames have blue Too much primary air. base and yellow upper two-thirds. Flames are stable but too small and blue. NORMAL OPERATION Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com I:\DEPARTMENTS\Technical Support\Troubleshooting\Guides\20181205_Troubleshooting Flow Chart_E4_8btn Edition.indd...
  • Page 76: Connecting To A Smart Home System

    • Mode 2 - The remote control must be set to the manual mode if the external source is to control the room temperature. If the handset is placed in the thermostatic mode it will override the external source. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 77: Installing The Optional Black Glass

    Step 3. Using the provided suction cups, carefully put the top end of the glass into the top channel first. Push up until the bottom end of the glass clears the bottom channel. Lower the glass into the bottom channel. Figure 144 Step 4. Reinstall clear glass. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 78 No communication between receiver and Wi-Fi Contact service No control possible by the electronics module Contact service No temperature display in the App • No remote control connected “N.a. ” in the App • Batteries in remote control empty Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 79 2x 1.5 V AAA 4 sec. No reaction from the fireplace No or bad connection between the receiver and Interrupted responses remote control No electronic control No voltage on the receiver Low communication range, AC adapter Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 80 Try to keep jammers as far away as possible devices can not connect via the 5GHz band, the ProControl from the router. Neighboring wireless networks also play a module is not suitable for 5GHz band. role in the Wi-Fi area. Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 81 NOTES Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 82 FIRST FIRE 57 TROubLEShOOTING Appendix Two nstaLLing the vENTING ressures onfiguration orizontaL erMinations erticaL erMinations KEY INSTALLATION pOINTS 7 estrictor Learances LISTING LAbEL 11 WALL ACCESS DOOR 44 WARRANTY 69 MAINTENANCE urner Lass iLot herMocoupLes MANTELS 22 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...
  • Page 84 Imported and distributed in North America by: EUROPEAN HOME a division of Europa Ja, Inc. 30 Log Bridge Road Building 300 - Suite 303 Middleton, MA 01949 www.europeanhome.com IGE410II-181029 Element4 Gas Fireplaces Rev#03242020 EuropeanHome.com...

Table of Contents