Physio Control LIFEPAK 11 Service Manual

Defibrillator/pacemaker

Hide thumbs

Table Of Contents

Table of Contents

Table of Contents
Safety Information
General Information
Parts List
Figure 1-1 LIFEPAK 11 Defibrillator/Pacemaker
Figure 1-2 LIFEPAK 11 Defibrillator/Pacemakerand LIFEPAK 11 Diagnostic Cardiac Monitor
Specifications
Table 1-1 Specifications
Functional Description
Power Selection
Low Voltage Power Supply
Microprocessor and Memory
Capacitor Energy Management
10-Bit Analog-To-Digital Converter
ECG Isolation Amplifier
A2 Pacer PCB
Isolated Power Supply
Pacer Pads-Off Detection
High Voltage Switch and Current Limiter
Trans-Admittance Output Amplifier
Pace Echo
A3 Keypad PCB
Operating Controls
Operating Indicators
A4 Transfer Relay Assembly
Transfer Relay
Dump Relay
Figure 1-4 Edmark Defibrillation Pulse
Operation
Introduction
Controls, Indicators, and Connectors
Input Power
Table 2-1 Defibrillatorcontrols, Indicators, and Connectors
Figure 2-3 Standard Paddles Module Controls and Connectors
Table 2-3 Standard Paddles Module Controls and Connectors
FASTPAK Battery
AC and DC Auxiliary Power Supplies
Installing/Removing a Therapy Module
Installing a Therapy Module
Removing a Therapy Module
Figure 2-4 Installing a Module
Connecting the Defibrillator to the Monitor
Figure 2-5 Module Removal Tool
Figure 2-6 Connecting the Defibrillatorand Monitor
Figure 2-7 Disconnecting the Monitor and Defibrillator
Service Mode
Software Version
Figure 2-8 Service Mode Functions
Defibrillator Discharge Log
Pacer Pulse Log
Therapy Module Type
Error Log
Keypad Tests
Figure 2-9 Error Log
Defibrillator Energy Calibration
Figure 2-10 Keypad Tests
Figure 2-11 Defibrillation Energy Calibration
Pacer Current Calibration
Figure 2-12 Pacer Current Calibration
Testing and Troubleshooting
Introduction
Performance Inspection Procedure (PIP)
PIP-Scope and Applicability
PIP-Resource Requirements
PIP-Equipment
PIP-Test Equipment Verification
PIP-Workstation Power
PIP-Personnel
Figure 3-1 QUIK-COMBO Test Post Adapter
PIP-General Instructions
PIP-Testing with the QUIK-COMBO Module
PIP-Physical Inspection
PIP-Service Mode and Power on
PIP-Keypad
PIP-Defib Energy Output
Table3-2 Defibrillation Energy Levels (QUIK-COMBO Module)
Table 3-3 Pacing Output Current (QUIK-COMBO Module)
Figure 3-2 Defibrillator Slide Contacts (QUIK-COMBO Module)
Figure 3-3 Connectionsfor Defibrillator Insulation Check
Table 3-4 Maximum Leakage Current for Patient Contact Tests
Table 3-5 Maximum Leakage Current for Chassis Leakage Tests (QUIK-COMBO Module)
Standard Paddles Module
PIP-Defib Energy Dump
PIP-Defib Charge Time
PIP-Open Air Discharge
PIP-Hold-Up Time
PIP-Synchronized Cardioversion
PIP-Pacer Output Current (Ifpacemaker Option Installed)
Table 3-7 Pacingoutput Current (Standard Paddles Module)
Pip-Quik-Look
Figure 3-4 Defibrillator Slide Contacts (Standard Paddles Module)
Figure 3-5 Connections for Defibrillator Insulation Check
Maximum Leakage Currentforchassis Leakage Tests (Standard Paddles Module)
Figure 3-6 Pacer Source and Sink Connections (Standard Paddles Module)
Figure 3-7 Patient Source and Sink Connections
Defib Energy Output
PIP Checklist for QUIK-COMBO Module
PIP Checklist for Standard Paddles Module
Test and Calibration Procedures
TCP-Scope and Applicability
TCP-Definitions
TCP-Workstation Power
TCP-Personnel
TCP-Defibrillation Calibration
Table 3-10 Test Equipment Required for the TCP
Table 3-11 Defibrillation Energy Levels
TCP-Pacer Current Calibration
Troubleshooting Aids
Defibrillation Output Waveform
Service Mode Error Codes
Figure 3-9 Energy Output Waveform
Service and Maintenance
Introduction
Maintenance and Testing Guidelines
Useful Life
Product Support Policy
Battery Maintenance
Nicad Battery Performance Factors
Temperature
Voltage Depression
Self-Discharge Rate
Charging a Battery with the Battery Support System
The FAULTY Light
Use the Battery Support System to Maintain Batteries
Figure 4-1 Reconditioning Procedure Form
Perform Shelf Life Test Every Six Months
Use Battery Maintenance Log
Figure 4-2 Shelf Life Test Form
Receiving New Batteries
Figure 4-3 Battery Maintenance Log
Storing Batteries
Discarding Batteries
Recycling Batteries
Disassembly Procedures
Special Handling for Static Sensitive Devices
Look for SSD Symbol
Use Static-Dissipative Mat
Wear Wrist Strap
Transport and Store Pcbs Properly
Keep Work Area Static-Free
Test Work Area Routinely
Power Disconnection
Case Separation
Main PCB Assembly Removal
Pacer PCB Assembly Removal
Keypad Assembly Removal
Transfer Assembly Removal
Figure 4-5 Pacer PCB
Capacitor Removal
Inductor Removal
Figure 4-6 A4 Transfer Relay
Therapy Connector Removal
Monitor Interface Connector Removal
Reinstallation Procedures
W9 Monitor Interface Connector
W1 Therapy Connector
L1 Inductor
A4 Transfer Relay
Figure 4-7 Monitor Interface Connector Reinstallation
A3 Keypad PCB
A2 Pacer PCB
A1 Main PCB
Battery Connector Pin Replacement
Fuse Replacement
Figure 4-9 Inspecting and Removing Battery Connector Pin
Inspection
Exterior Inspection
Table 4-2 Exterior Inspection
Interior Inspection
Cleaning
Warranty
Preparation for Shipping
Parts Lists and Schematics
Exploded Views
How to Order Parts
Table 5-1 Major Assemblies and Cables
Table 5-2 Reference Designator Key
Table 5-3 Supplies, Trainingtools, and Accessories
Figure 4-4 Main PCB Assembly
Figure 5-1 LIFEPAK 11 Defibrillator/Pacemaker Final Assembly
Figure 5-2 Interconnect Diagram

Quick Links

Download this manual

Service Manual

LIFEPAK ® 11 defibrillator/pacemaker

Manual No. 3006038-00

January 1996

PHYSIO

CONTRO

Corporate Headquarters:

11811 Willows Road Northeast

Post Office Box 97006

Redmond. WA 98073-9706 USA

Telephone: 206.867.4000

Toll Free:

(USA only) 800.426.8047

Telex:

990211 D PHYSIO RDMD

Fax:

206.867.4161

Table of Contents

Troubleshooting

Need help?

Do you have a question about the LIFEPAK 11 and is the answer not in the manual?

Physio Control LIFEPAK 11 Service Manual

Quick Links

Troubleshooting

Need help?

Questions and answers

Related Products for Physio Control LIFEPAK 11

Physio Control LIFEPAK 11 Service Manual

Quick Links

Troubleshooting

Need help?

Questions and answers

Related Manuals for Physio Control LIFEPAK 11

Related Products for Physio Control LIFEPAK 11

Table of Contents