Table of Contents
Advertisement
Quick Links
ASSEMBLY & OPERATING INSTRUCTIONS
Important: Read these instructions for use carefully so as to familiarize yourself with the
appliance before connecting it to its gas container. Keep these instructions for future
reference. Megamaster reserves the right to make changes to this manual without prior
Manufactured in China · Distributed by Mega Group · PO Box 15, Woodlands, 0072, South Africa · Tel: +27 (0) 12 802 1515
WARNING
This grill is not intended to be
installed in or on recreational
vehicles and/or boats.
SIZZLER 320
Patio Gas Braai
Product code: 720-0929GA
Permit number (1185-66/1-RSA-12-A)
www.megamaster.co.za
WARNING
To reduce the risk of fire, burn hazard or other injury,
read the manual carefully and completely before
using your grill.
notice.
WARNING
FOR OUTDOOR USE ONLY.
1
Advertisement
Table of Contents
Related Manuals for Megamaster SIZZLER 320
Summary of Contents for Megamaster SIZZLER 320
- Page 1 Important: Read these instructions for use carefully so as to familiarize yourself with the appliance before connecting it to its gas container. Keep these instructions for future reference. Megamaster reserves the right to make changes to this manual without prior notice.
-
Page 2: Table Of Contents
TABLE OF CONTENTS Safety Information ......................3 Package Contents List ...................... 7 Preparation ........................8 Assembly Instructions ....................... 11 Installation Instructions...................... 23 Operating Instructions ....................... 25 Care and Maintenance ...................... 26 Troubleshooting ........................ 28 Warranty ........................... 30 Replacement Parts List ..................... 31 DANGER WARNING If you smell gas:... -
Page 3: Safety Information
SAFETY INFORMATION WARNING Do not try lighting this appliance without first reading WARNING the “LIGHTING INSTRUCTIONS” section of this manual. WARNING – Hazards or unsafe practices which COULD result in severe personal injury or death. WARNING Maximum LP gas cylinder size is 30cm in diameter by CAUTION 52cm tall. - Page 4 WARNING WARNING Spiders and insects can nest inside the burners Do not leave the grill unattended while cooking. of the grill and disrupt gas flow. Inspect the grill at least twice a year. WARNING CAUTION Failure to properly place the burner over the Before cleaning, make sure the gas supply and orifice could cause a fire to occur behind and control knobs are in the “OFF”...
- Page 5 SAFETY PRACTICES TO AVOID INJURY When properly cared for, your grill will provide safe, reliable service for many years. However, extreme care must be used as the grill produces intense heat that can increase accident potential. When using this appliance basic safety practices must be followed, including the following: Do not repair or replace any part of the grill unless specifically recommended in this manual.
- Page 6 Do not operate the grill under unprotected combustible constructions. Use only in well ventilated areas. Do not use in buildings, garages, sheds, breezeways or other such enclosed areas. This unit is intended for outdoor use only. Keep the areas surrounding the grill free from combustible materials including, fluids, trash, and vapors such as gasoline or charcoal lighter fluid.
-
Page 11: Assembly Instructions
ASSEMBLY INSTRUCTIONS... - Page 22 Burners Gas Cylinder position:...
-
Page 23: Installation Instructions
INSTALLATION INSTRUCTIONS GAS HOOK-UP Only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. This grill is configured for LP Gas. Do not use a Natural Gas supply. Total gas consumption (per hour) with all burners set on “HI”: Main burners 48,000 BTU/Hr. - Page 24 LEAK TESTING GENERAL Although gas connections on the grill are leak tested prior to shipment, a complete leak test must be performed at the installation site. Before each use, check all gas connections for leaks using the procedures listed below. If the smell of gas is detected at any time, you should immediately check the entire system for leaks.
-
Page 25: Operating Instructions
OPERATING INSTRUCTIONS General Use of the Grill Each main burner is rated at 12,000 BTU/Hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are flame tamers. The igniter knobs are located on the center portion of the valve panel. -
Page 26: Care And Maintenance
TO MATCH LIGHT THE GRILL If a burner will not light after several attempts using the control knobs, the burners may be lit with a match. WARNING CAUTION When lighting, keep your face and hands as far When using a match to light the grill make sure to away from the grill as possible. - Page 27 To remove the main burners for cleaning: 1. Locate the burner screw at the rear of the firebox. 2. Remove the screw and lift the burner out of the firebox. To clean the grill burners: 1. Clean the exterior of the burner with a wire brush. 2.
-
Page 28: Troubleshooting
TROUBLESHOOTING Problems Possible Solutions Grill will not light. 1. Push and turn the knob and check for sparks. 2. If there is a spark, check to make sure gas is supplied to the burner. a. Purge the line of any trapped air. b. - Page 29 Problems Possible Solutions Burner blows out. 1. Check for any burner defects. 2. Check for proper burner installation. 3. Make certain the fuel mixture is not too lean. 4. Make sure the gas supply is sufficient. 5. See if the LP gas cylinder is empty. Low heat, LP gas.
-
Page 30: Warranty
Warranty This grill has a one (1) year limited warranty. The warranty period is valid from the date of purchase. This is subject to correct assembly, use, storage and regular maintenance of the product. Please refer to page 29 of this manual for list of replacement parts. Please Note: the main burner has a warranty of one (1) year. - Page 32 EXPLODED VIEW...
- Page 33 Sizzler 320 PATIO GAS BRAAI FOR OUTDOOR USE ONLY WARNING Read and follow all Safety, Assembly, and Use & Care Instructions in this guide before assembling and cooking with this grill. Failure to follow all instructions in this Use & Care Guide may lead to fire or explosion, which could result in property damage, personal injury or death.
Need help?
Do you have a question about the SIZZLER 320 and is the answer not in the manual?
Questions and answers