Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for CardioQuip VivaCart VC-1000
Summary of Contents for CardioQuip VivaCart VC-1000
- Page 1 VivaCart ™ VC-1000 | Instructions for Use CardioQuip ® LBL-81 V0...
-
Page 2: Notices
Notices The information in this document may change without notice. CardioQuip makes no warranty of any kind regarding this material including, but not limited to, the implied warranty of merchantability and fitness for a particular purpose. CardioQuip cannot be held liable for errors herein or for consequential damages concerning the use of this material. -
Page 3: Table Of Contents
8. Removable Upper Shelf Assembly (Type E) 9. Pump Guard Mounting Bracket Installations VivaCart Operation ..........17 Directional Lock Swivel Caster Locking Lower Shelf VivaCart Maintenance ........19 Cleaning and Disinfection VivaCart Replacement Components VivaCart Replacement Accessories VivaCart Disposal LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 4: Vivacart General Information
CAUTION: In the event of visible damage to the power strip, it is essential to connect the equipment directly to wall outlets to ensure grounding integrity until a replacement power strip is obtained from the manufacturer. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 5: Limited Warranty
CardioQuip may, at its sole reasonable discretion, elect to repair the Equipment on site. (2) The Equipment must not have been repaired or altered outside of CardioQuip's factory in any way which, in the sole reasonable judgment of CardioQuip, affects its stability and reliability. The Equipment must not have been subjected to misuse, abuse or accident by Customer. -
Page 6: Device Labeling
To indicate acceptable maximum and minimum temperature limits for transport and storage. To indicate the acceptable upper and lower limits of relative humidity for transport and storage. To indicate the acceptable upper and lower limits of atmospheric pressure for transport and storage. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 7: Specifications
Upper Shelf — 18.1 kg (40 lbs) resting on the center of the shelf Soft-Close Drawer VC-R-RDR 13.6 kg (30 lbs) within the drawer fully open Lower Locking Shelf — 36.3 kg (80 lbs) fully open LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 8: Vivacart Overview
Upper Side Mounting Zone Rear Handle Mounts (Type A) (Type D) Removable Upper Shelf Middle Side Mounting Zone (Type D) Lower Side Mounting Zone (Type D) Total Lock Caster Lower Shelf Lock Directional Lock Casters LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 9: Vivacart Setup
VC-R-DLC VC-AA-HXS VC-AB-LKW Total Lock Caster & Directional Lock Hex Screw, 8mm (M8) Lock Washers, 8mm Mount Caster & Mount (M8) VC-AH-HXT VC-AC-WAS VC-AF-CMP Hex Tool (5mm) for Washers, 8mm (M8) Corner Mount Plunger assembly LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 10: Cart Accessories
Pole, 46 cm Single Hook Triple Hook VC-D-O2E VC-D-20A VC-R-RTS VC-E-PGM Side Mount Oxygen Side Mount Power Removable Upper Pump Guard Tank Holder (fits Strip, 20A Shelf Mounting Brackets type E cylinders) (set of 2) LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 11: Unpacking
(see fig. 1.3) before securing weight plate to base (see fig. 1.4). Fig. 1.2 Inserting Weight Plate Fig. 1.3 Securing M6 mounting screws. Fig. 1.4 Securing weight plate with M6 mounting screws. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 12: Swivel Caster Assembly
3. Press the caster mounting leg firmly into the cart body and tighten with a hex wrench (VC-AH-HXT) from the top down. 4. Repeat until both directional lock casters are Fig. 2.2 Securing mounting screws. secure. LBL-81 V0 ©2023 CardioQuip, LLC... - Page 13 M8 screw and four (4) side screws on the wheel mount and press firmly down on the wheel mount to lower the mounting position. Next, tighten the four (4) side screws in place before tightening the lower screw. LBL-81 V0 ©2023 CardioQuip, LLC...
-
Page 14: Handle Assembly (Type A)
(see fig. 4.3) fit over the middle side mounting zone. Wire Loops Lower Hooks Fig. 4.3 Storage Basket wire loops Fig. 4.2 Storage basket inserted to basket hook mounts wire loops and lower hooks LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 15: Corner Mount Assembly (Type C)
(see fig. 6.4). Next, insert hooks facing upward (see fig. 6.5) Fig. 6.4 Removing pole cap into each of the four slots and replace cap. Hand tighten pole cap to secure hooks. Fig. 6.5 Proper hook orientation. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 16: Side Accessory Assembly (Type D)
To re-insert, ensure the shelf is oriented properly and push into the cut out area until removable shelf locks into place. Once properly inserted, the removable shelf should be flush with the rest of the top shelf. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 17: Pump Guard Mounting Bracket Installations
(see fig. 9.2). Fig. 9.2 Pump Guard Mounting Brackets To remove: Pull or twist the mounting bracket with a large amount of force. Maquet Cardiohelp is a trademark of Maquet Cardiopulmonary GmbH. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 18: Vivacart Operation
PUSH Fig. 9.2 When pushing VivaCart from the front, Fig. 9.3 When pushing VivaCart from the rear, activate directional lock in the rear of the cart. activate directional lock in the front of the cart. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 19: Locking Lower Shelf
The locking lower shelf is able to be locked in three positions. WARNING! Keep the lower shelf completely retracted and locked during transport. Do not attempt to move VivaCart with the lower shelf in the unlocked position or with the shelf out. LBL-81 V0 ©2023 CardioQuip, LLC... -
Page 20: Vivacart Maintenance
VivaCart Replacement Components The following is a list of replacement components that can be purchased through a local representative. For ordering information, visit the CardioQuip website, www.cardioquip.com/sales. Replacement Components Description... -
Page 21: Vivacart Replacement Accessories
VivaCart Replacement Accessories The following is a list of replacement accessories that can be purchased through a local representative. For ordering information, visit the CardioQuip website, www.cardioquip.com/sales. Replacement Accessories Description VC-A-WP Weight Plate (includes Hardware) VC-A-H04 Compact Handle, 4 cm... -
Page 22: Vivacart Disposal
WARNING! PROPER DISPOSAL. VivaCart must be properly disposed of in accordance with all applicable local, state, and federal regulations. Improper disposal can result in environmental harm and potential legal consequences. Contact your local waste management authority for information on the proper disposal of this cart. LBL-81 V0 ©2023 CardioQuip, LLC...