Advertisement
Quick Links
General Information
Thank you for purchasing this product. The purpose of this
manual is to assist you in operating and maintaining your lawn
& garden spot sprayer.
BEFORE RETURNING THIS PRODUCT
FOR ANY REASON, PLEASE CALL
1-800-831-0027
MONDAY-FRIDAY, 8:00 AM TO 5:00 PM CST
If you should have a question or experience a problem with
your Fimco Industries Product: Visit our website @
www.fimcoindustries.com or call the Toll free number above. Our
technical support representatives will be happy to help you.
In most cases a customer service rep. can resolve
the problem over the phone.
To obtain prompt, efficient service, always remember to give the
following information....
• Correct Part Description and/or part number
• Model number and Serial Number
Part descriptions and numbers can be obtained from the
illustrated parts list section(s) of this manual.
Retain a copy of your receipt for your
unit, as it will be required to validate
any warranty service.
Warranted against manufacturer or
workmanship defects from date of
purchase with copy of receipt:
Homeowner Usage: Sprayer-One Year and Pump-Two Years.
Commercial Usage: Sprayer and Pump-90 Days.
OWNER'S MANUAL
Model:
LG-40-DLX-CL-SP
(5302939)
(40 Gallon Deluxe Lawn & Garden
Spot Sprayer)
Technical Specifications
40 Gal. Corrosion-Resistant Polyethylene Tank
12 Volt Diaphragm Pump, 2.4 GPM - 60 PSI
15 Ft. Handgun Hose (3/8" I.D.)
25 Ft. max. vertical throw, 35 Ft. max. horizontal throw
Assembly Instructions
Your sprayer has been mostly assembled at the factory.
Remove the pressure gauge from the parts bag and thread it
into the manifold assembly. Use a good grade of thread seal-
ant or plumber's tape to ensure no leaks.
Remove the handgun clips from the parts bag and place them
onto the tank as shown.
One requirement will be for you to hook up your battery leads
to a fully charged 12 Volt battery before operation.
CAUTION: When fully filled with water, this sprayer will
weight approximately 365 Lbs. Always check the vehicle
load rating before using this sprayer. Do not exceed the
recommended rating.
www.fimcoindustries.com
1000 FIMCO Lane, P.O. Box 1700, North Sioux City, SD 57049
Toll Free Phone: 800-831-0027 : Toll Free Fax: 800-494-0440
[5195130
(02/19)]
Page 1
Advertisement
Troubleshooting
Related Manuals for Fimco LG-40-DLX-CL-SP
Summary of Contents for Fimco LG-40-DLX-CL-SP
- Page 1 1000 FIMCO Lane, P.O. Box 1700, North Sioux City, SD 57049 Homeowner Usage: Sprayer-One Year and Pump-Two Years. Toll Free Phone: 800-831-0027 : Toll Free Fax: 800-494-0440 Commercial Usage: Sprayer and Pump-90 Days.
- Page 2 Drain and then refill half full, add the recommended amount of a good quality tank cleaner, such as FIMCO Tank Neutralizer and Cleaner. (If no tank cleaner is available, you may substitute dish soap for this step, about 1-2 oz. per gallon). Turn pump on and circulate through system for 15 minutes and then spray out through handgun nozzle.
-
Page 3: Troubleshooting The Pump
3/8” Hose Barb Port Kit Fitting #5168836 DON’T Use to pump bleach. Clean and rinse your pump after each use with Fimco Tank Use to pump petroleum products such as diesel fuel, Neutralizer gasoline or kerosene ... -
Page 4: Troubleshooting
Checking the Pressure Switch If your motor is not running and you’ve checked the following: for loose wiring connections, fuse, the switch on the lead wire was “ON” and made sure you were connected to a fully charged battery and everything is fine, but the motor won’t run, then it’s time to check to see if the pressure switch is bad. -
Page 5: Exploded View And Parts List
See Detail A Exploded View & Parts List LG-40-DLX-CL-SP (5302939) Detail A Page 5... -
Page 6: Warranty
WHAT REMEDIES ARE AVAILABLE UNDER THIS LIMITED WARRANTY. If the conditions set forth above are fulfilled and the Equipment or any part thereof is found to be defective, Fimco, Ind. shall, at its own cost, and at its option, either repair or replace the defective Equipment or part.