Table of Contents
Advertisement
Quick Links
0
Fire Garden™
Outdoor Linear Fire Pit Burner
36" Linear Fire Pit Burner
60" Linear Fire Pit Burner
96" Linear Fire Pit Burner
Omni-Test Laboratories, Inc.
Report # 0028GM127S
ANSI Z21.97-2017 /CSA 2.41-2017, CSA 2.17-2017
Outdoor Decorative Gas Appliances
DANGER
This appliance can produce carbon
monoxide which has no odor.
Using it in an enclosed space can kill
you.
Never use this appliance in an
enclosed space such as a camper,
tent, car, or home.
French language manuals at outdoorfiregarden.com. Manuels de langue Française à outdoorfiregarden.com
Travis Industries, Inc.
$10.00
By Travis Industries, Inc.
Manual
94900430
94900447
94900460
Listed by
CARBON MONOXIDE HAZARD
12521 Harbour Reach Dr., Mukilteo, WA 98275
Copyright 2022, T.I.
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
Shut off gas to the appliance.
•
Extinguish any open flame.
•
If odor continues, leave the area
•
immediately.
After leaving the area, call your gas
•
supplier or fire department.
Failure to follow these instructions
could result in fire or explosion, which
could cause property damage, personal
injury, or death.
WARNING
Do not store or use gasoline or other
flammable vapors and liquids in the
vicinity of this or any other appliance.
An LP cylinder not connected for use
shall not be stored in the vicinity of this
or any other appliance.
WARNING: For outdoor use only.
Installation and service must be
performed by a qualified installer,
service agency, or the gas supplier.
WARNING: Improper installation,
adjustment, alteration, service, or
maintenance can cause injury or
property damage. Read the installation,
operating, and maintenance
instructions thoroughly before
installing or servicing this equipment.
WARNING: If the information in this
manual is not followed exactly, a fire or
explosion may result causing property
damage, personal injury, or loss of life.
INSTALLER: Leave this manual with the
appliance.
CONSUMER: Retain this manual for
future reference
www.travisproducts.com
Part # 100-01538
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Travis Industries Fire Garden 94900460
Summary of Contents for Travis Industries Fire Garden 94900460
- Page 1 By Travis Industries, Inc. Fire Garden™ DANGER FIRE OR EXPLOSION HAZARD Outdoor Linear Fire Pit Burner If you smell gas: Shut off gas to the appliance. Manual • Extinguish any open flame. • If odor continues, leave the area •...
-
Page 2: Overview
Carbon Monoxide and Benzene, which are known to the State of California to cause cancer, birth defects, or other reproductive harm. For more information go to www.P65Warnings.ca.gov. © Travis Industries, Inc. 3/10/23 - 1538 Outdoor Linear Fire Pit Burners... -
Page 3: Table Of Contents
Warranty ................ 42 Wiring Installation ............22 Wiring Diagram .............. 43 Using More than One 24-volt Appliance ......24 Index ................44 Wiring Multiple Transformers to One Switch ....24 © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 4: Safety Precautions
Direct questions Travis Industries, Inc. grants no warranty, about the type of fuel used to your dealer. A label implied or stated, for the installation or is placed on the control panel to show which fuel maintenance of your appliance, and assumes the appliance is designed for. -
Page 5: Features
Input Rating 96" Input Rating (BTU/h) 185,000 185,000 Linear Fire Pit Burner Orifice Size (DMS) (2) - #30 (2) - #43 (1) - #29 (1) - #41 © Travis Industries, Inc. 3/24/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 6: Linear Fire Pit Burner Dimensions
Features and Specifications Linear Fire Pit Burner Dimensions: © Travis Industries, Inc. 4/4/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 7: Installation Warnings
The requirements listed below are divided into sections. All requirements must be met simultaneously. The order of installation is not rigid – the qualified installer should follow the procedure best suited for the installation. © Travis Industries, Inc. 4/4/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 8: Recommended Order Of Installation
LP Conversion Kit - see “LP Conversion” on page 20 for details. Wall Switch and wall switch cover. Gas Key Valve with Chrome Flange 3” & 18” Gas Key (2) Enclosure Vents © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 9: Additional Items Required
High voltage wire (from house circuit to transformer) Weatherproof enclosure for wall switch (only needed if the switch is to be installed outdoors). Media (Crushed Glass, Ember Rock, or Tumbled Stones) Travis Industries offers the following Crushed Glass Options: Platinum sku# 94500580 ... -
Page 10: Assembling The 96" Fire Pit Burner (96" Units Only)
3. Using the included center bracket, connect the two halves of the firepit as shown below. Use a ¼” nut driver to secure the two halves to the center bracket with the (20) stainless steel bolts included in the hardware pack. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... - Page 11 NOTE: Make sure to leak-test all gas connections before putting the appliance into service. 5. Connect the power from the 24VAC transformer to the two twisted pairs of wires that protrude from the end of side 1 of the appliance. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners...
-
Page 12: Weatherproofing The Installation
In places where the controls beneath the appliance may be submerged underwater. Submerging any part of its controls may require the complete replacement of the controls. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 13: Clearances
Installation (qualified installers only) Clearances © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 14: Minimum Framing Dimensions
Installation (qualified installers only) Minimum Framing Dimensions © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 15: Landscaping Block Enclosures
96" Linear Fire Pit Burner Burner Burner Standard Install 36-1/4” x 12-1/4” 60-1/4” x 12-1/4” 96-1/4” x 12-1/4” Recessed Install 37-3/4” x 13-3/4” 61-3/4” x 13-3/4” 97-3/4” x 13-3/4” © Travis Industries, Inc. 3/22/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 16: Enclosure Finish Material - Minimum Dimensions
NOTE: The dimensions shown below are the MINIMUM to accommodate the glass wind guard. You may choose to make the top surface larger to create more of a usable table surface. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 17: Enclosure Ventilation Requirements
< 9" (the minimum) NOT LARGE ENOUGH Example: If (w) = 12" and (h) = 2" 2" x 12" = 24 square inches 24" > 9" (the minimum) LARGE ENOUGH © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 18: Enclosure Ventilation Grills
The grills must be kept free from vegetation or debris that can restrict the flow of air. The assemblies must be installed directly opposite each other. © Travis Industries, Inc. 3/22/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 19: Gas Line Requirements
The appliance comes with a 34” flex. Connect the incoming gas line to the flex (the flex accepts 3/4” MPT) © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 20: Lp Conversion
(if already installed). Remove the media trays (see “Removing the Media Trays” section on page Convert the appliance using the instructions to the right. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 21: Electrical Connection Requirements
120VAC at approximately 0.9 amps - make sure the circuit and wiring is appropriately sized. The power supply must be routed through a switch to turn the appliance on and off (see pg. 43). Multiple Travis Industries, Inc. 24-volt appliances may be placed on a single circuit. Each appliance uses 24VAC at approximately 1.6 amps - Make sure the circuit and wiring is appropriately sized (see diagrams starting on pg. -
Page 22: Wiring Installation
(below the pilot). Use listed low voltage wiring. Make sure to provide slack in the electrical line for removal and service. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... - Page 23 The appliance uses approximately 40 watts during startup (1.6 amps at 24 VAC). Make sure the circuit and wires are sized appropriately. The appliance requires a minimum of 22 VAC to operate (if the voltage drops below this, the appliance may not start). © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners...
-
Page 24: Using More Than One 24-Volt Appliance
(qualified installers only) Using More than One 24-volt Appliance Travis Industries, Inc. manufactures additional 24-volt appliances that can add to the ambiance of your outdoor space (Tempest Torch™, Tempest Lantern™. Visit tempesttorch.com for more details). If using more than one appliance, make sure to think about how the appliances will be used and if they need to be able to be controlled separately or if it would be more convenient to control them all using one switch. -
Page 25: Wiring Multiple Appliances To One Transformer
The manner in which you wire the appliances to the transformer affects the maximum length of wire and wire gauge. Make sure to determine the wire configuration before installation. NOTE: You may use both direct-run and daisy-chain configurations. Daisy-Chain Example Direct-Run Example © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 26: Daisy-Chain Wire Length Chart
Daisy-Chain Wire Length Chart This type of wire configuration allows for multiple Travis Industries 24-volt products to be wired in a series, reducing the amount of wire used. Use the charts below to determine the correct wire gauge and length. In the example below, the transformer has 2 Linear Fire Pit Burners and a lantern on one branch. -
Page 27: Direct-Run Wire Length Chart
The wire will also be printed with a gauge number (e.g. AWG#14 = 14 gauge, 10AWG = 10 gauge, etc.). Do not use wires of dissimilar gauges (do not use 14 gauge & 10 gauge wire on the same transformer). © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 28: Steps For Finalizing The Installation
Crushed Glass Installation Crushed glass is placed over the burners and center media trays. Use only ¼” crushed glass from Travis Industries and/or other media specifically approved by Travis Industries. Placing Crushed Glass on the Burner and Center Media Trays 36"... -
Page 29: Rock Ember Installation
Rock Ember Installation Rock embers can be placed over the burners and center media trays. Use only the Rock Ember material from Travis Industries and/or other media specifically approved by Travis Industries. Placing Rock Embers on the Burner and Center Media Trays 5 lbs. -
Page 30: Tumbled Stone Installation
Tumbled Stone may be placed over the burners and media trays. Only use the Tumbled Stone media kit from Travis Industries. The amount of stone indicated on the chart below refers to the small stones used to cover the burner and media tray. Large stones may be placed anywhere over the media tray but should not be installed over the burner and are not included in the recommended weights in the chart below. -
Page 31: Assembling The Glass Wind Guard (36" & 60" Units)
Linear Fire Pit Burner. Measure the distance from the edges of the pit to the edges of the glass to ensure that it is centered. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 32: Assembling The Glass Wind Guard (96" Units)
Repeat this step with the second end piece of glass. NOTE: Make sure the logo is readable when looking at the outside of the wind guard. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... - Page 33 Linear Fire Pit Burner. Measure the distance from the edges of the pit to the edges of the glass to ensure that it is centered. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners...
-
Page 34: Before The First Fire
Inspect the appliance, burner, and supply lines for any damage prior to operation. The burner must be replaced prior to the appliance being put into operation if it is evident that the burner is damaged. Use only Travis Industries replacement burners. It may be difficult to see the burner operating in direct sunlight. -
Page 35: Location Of Controls
If the wall switch will be located where it is not protected from precipitation, it must be installed in a weather resistant enclosure (not included). © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 36: Maintaining Your Appliance
The glass may be cleaned with a non- abrasive cleaner. To clean the inside of the glass, remove the glass place it on a non- scratching surface, and clean the inside surface. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 37: Accessing Components
Remove all the screws from the media tray(both sides) and remove the trays. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 38: Accessing The Pressure Tap
Once maintenance or testing of components is complete, follow the above steps in reverse to return the appliance to its proper configuration. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 39: Winterizing The Appliance
Start the main burner. After 15 minutes, the flames should be orange/yellow. If the appliance is not burning correctly, contact your dealer for service. If the igniter is not getting hot or lighting the appliance properly contact your dealer for service. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 40: Replacement Parts List
Maintenance Replacement Parts List Caution: Use only Travis Industries replacement parts. Do not use substitute materials. Warning: Do not operate the appliance with the glass wind guard removed, cracked, or broken. Replacement of the glass should be done by a licensed or qualified service person. -
Page 41: Troubleshooting Table
(spider webs, etc.) from the burner and dirty or blocked orifice area. Glass is Sooting Wind will influence the flame quality and, if Windy Condition persistent, may lead to sooting on the glass. © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 42: Warranty
Register your TRAVIS INDUSTRIES, INC. Limited 7 Year Warranty online at traviswarranty.com. TRAVIS INDUSTRIES, INC. warrants this gas appliance (appliance is defined as the equipment manufactured by Travis Industries, Inc.) to be defect-free in material and workmanship to the original purchaser from the date of purchase as follows: Check with your dealer in advance for any costs to you when arranging a warranty call. -
Page 43: Wiring Diagram
Wiring Diagram Wiring Diagram © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners... -
Page 44: Index
Winterizing the Appliance ........ 39 Installation Warnings .......... 7 Yearly Service Procedure ........ 39 Index © Travis Industries, Inc. 3/10/2023 - 1538 Outdoor Linear Fire Pit Burners...
Need help?
Do you have a question about the Fire Garden 94900460 and is the answer not in the manual?
Questions and answers