5.3.5 Front projector lamps replacement ..45 Gear lever ..........23 Adjustments that has to be done by a Instruments and warning lights ....24 Benelli Q.J. Authorized Workshop ..46 3.7.1 Multifunction display .......25 5.4.1 Clutch lever play ........46 Tornado Naked Tre 1130 Adjusting the rear suspension ....47...
Benelli Q.J. reserves the right to make any changes, whenever deemed, to its products and to this manual. Wherever you will find any dissimilarity between what is written on tihs Owner’s Manual and the specific fitting-out of your update version of the Owner’s...
Tornado Naked Tre 1130 1) vehicle identification number 2) engine serial number 3) homologation data Identification data 1. vehicle identification number 2. engine serial number 3. homologation data We recommend writing down the main numbers in the spaces provided below. FRAME No.
TORNADO NAKED TRE 1130! For any necessity or further information don’t hesitate to apply to your Benelli Q.J. Distributor or to the nearest Benelli Q.J. Authorized Workshop. You can find the Benelli Q.J. Distributor and the Benelli Q.J. Authorized Workshop list on the web site www.benelli.com or calling the Benelli Q.J.
As soon as possible and, kowever, before using your motorcycle after an accident, even if there are not any visible damages, it is necessary to have it inspected by a Benelli Q.J. Authorized Workshop, in order to erify the absence of defects and/or damages that the owner could not be able to detect.
To meet the passionate drivers numerous requests, Benelli Q.J. has designed a number of special components for use in competitions and/or sporting events. The use of such components is strictly limited to areas closed to traffic. Failure to observe this restriction constitutes a breach of the Highway Code for which Benelli Q.J. cannot be held responsible.
Tornado Naked Tre 1130 When riding down long hills, reduce the speed of your motorcycle by closing the throttle and using a low gear ratio to take advantage of engine braking. Use the front and rear brakes as little as possible to maintain your speed, in order to prevent brake overheating and fade.
Tornado Naked Tre 1130 WARNING Protective clothes do not afford complete protection against the risk of personal injury in the event of an accident. It is therefore essential not be deceived by the false sense of security that you might perceive by wearing protective clothing. When riding, always adopt a cautious attitude and follow the recommendations given in the previous paragraphs.
Tornado Naked Tre 1130 Controls and instruments Location of controls and instruments Instruments and warning lights Clutch lever Front brake lever Left handlebar electrical controls Throttle twist grip Ignition switch and steering lock Right handlebar electrical controls Fuel tank cap Left side Left side Left side...
Tornado Naked Tre 1130 Handlebar controls, left side Clutch lever Move towards/away from the handgrip to release/engage the clutch. High beam flasher button Press the button repeatedly. Control Lights Lights on Low or high beam on Control Turn indicator Shifting the lever to the left or right switches on the left or right turn indicators.
To avoid damaging the electrical equipment, be sure not to hold down the button for longer than 5 consecutive seconds. If, after some attempts, the engine does not start, contact your authorized Benelli Q.J. service center.
Tornado Naked Tre 1130 Ignition switch and steering lock WARNING Do not attach a ring or any other object to the ignition key as they may hinder the steering action. Never attempt to change the switch functions while riding,as you may lose control of the vehicle.
Tornado Naked Tre 1130 Gear lever WARNING Only operate the change gear with the clutch lever fully pulled. The N (neutral) position is indicated by the warning light on the instrument panel. To change into first gear, push the lever down. To change into second gear, lift the lever up.
• Improve our riding skills PROTECT THE ENVIRONMENT Benelli Q.J., in order to protect the interests of the community, awakens the Customers and the Technical Assistance operators to use the vehicle and dispose of its replaced parts respecting the laws in force concerning environmental pollution and waste disposal and recycling.
If any of the above-mentioned parts shows a failure during its operation, have it controlled and repaired by a Benelli Q.J. Authorized workshop before using the motorcycle. Check fluid level.
Page 17
Tornado Naked Tre 1130 Running-in Failure to observe the indications provided below can reduce performance and shorten the life of the motorcycle. Running-in is generally considered to apply only to the engine. In fact, it should be regarded as an essential phase for other important parts such as the tyres, the brakes and the drive chain.
Page 18
Tornado Naked Tre 1130 Resetting the trip mileage counters The value of the “Trip” function can be reset pressing two times the START button. NOTE: The instrument panel has an integrated memory which retains all the parameters even when the engine is not running.
Page 19
Tornado Naked Tre 1130 Set “Service” When the first 1000 Km (600Mi) will be reached and every 5000Km (3100Mi) you will see the flashing Service pilot light on the display, instead of the partial “Trip”rip” for 10 seconds during the vehicle starting. To reset the Service pilot light, press the START button for at least ten seconds until the pilot light is switched off.
Page 20
Tornado Naked Tre 1130 Saddle disassembly driver Insert the key. Press the end part of the saddle and, at the same time, turn the key counterclockwise. Slightly lift the saddle from the rear, slide it backwards and remove it. Keys supplied Saddle disassembly passenger and/or Cafè...
Page 21
Tornado Naked Tre 1130 WARNING Petrol and its fumes are highly toxic and flammable. Avoid contact and inhalation. When refuelling, switch off the engine, avoid smoking, and keep away from flames, sparks and heat sources. Perform refuelling in the open air or in a well ventilated area. Overfilling the tank may cause the fuel to overflow as a result of the expansion due to the heat from the engine or to exposure to sunlight.
Page 22
All adjustments must be performed when the vehicle is stationary and, where not otherwise provided in this manual, they have to be done only by Benelli Q.J. Authorized Workshop; in fact, some of these operations can cause a danger for the user’s safety if they are...
Tornado Naked Tre 1130 Rearview mirrors adjustment Front brake lever adjustment Gear lever adjustment Headlight adjustment Front suspension Back foot brake pedal regulation adjustment Drive chain adjustment Clutch lever adjustment Rear suspension adjustment Tornado Naked Tre 1130 Recapitulatory table of adjustments TYPE OF ADJUSTMENT COMPETENCE Adjusting rear...
Page 24
Tornado Naked Tre 1130 Adjustments that can be done by user WARNING Never perform the adjustment while rid- ing. 5.3.1 Front brake lever adjustment Push the lever forward to neutralize the spring thrust and, at the same time, adjust its position in one of the four possible directions by turning the ring nut clockwise or anticlockwise.
Page 25
Tornado Naked Tre 1130 Adjustments that has to be done by a Benelli Q.J. Authorized Workshop WARNING – The following adjustments are reserved to the Benelli Q.J. Author- ized Workshops. Never perform the ad- justment while riding. B 5.4.1 Clutch lever play Remove the adjustment cover cap.
Page 26
Tornado Naked Tre 1130 Adjusting the rear suspension - Tornado Naked Tre 1130 and Cafè Racer Spring preload Rebound damper hydraulic device Tornado Naked Tre 1130 WARNING The high temperature of the exhaust pipes can cause burns. Before adjusting the rear suspension, shut off the engine and wait until the exhaust pipes have thoroughly cooled.
Tornado Naked Tre 1130 5.5.1 Adjusting rear suspension spring preload Adjust the spring preload by means of the two ring nuts (A and B) shown in the figure. Unloose the ring nut (A) and adjust the preload using the ring nut (B). Turn clockwise for a stiffer preload.
Owner’s Manual. In any other case have the operations performed by a Benelli Q.J. Authorized Workshop, whose list is available on the web site www.benelli.com or calling the Benelli Q.J. Coustomer Service dialling +39 0721.418740.
Page 29
Tornado Naked Tre 1130 Tornado Naked Tre 1130...
Page 30
Tornado Naked Tre 1130 Tornado Naked Tre 1130...
Page 31
Tornado Naked Tre 1130 Tornado Naked Tre 1130...
Page 32
Tornado Naked Tre 1130 Tornado Naked Tre 1130 Hose clamp...
For the availability of the suggested product, Benelli Q.J. suggests to directly apply to the Authorized Dealers or Workshops. If the above described lubricant is not available, Benelli Q.J. suggests to use a fully synthetic engine oil having characteristics equal or better than the ones prescribed in the following standards: •...
Tornado Naked Tre 1130 6.4.1 Topping up the engine oil level Oil filler plug To top up the engine oil level, remove the oil filler plug and pour an appropriate amount of engine oil of the recommended type. Never exceed the MAX level mark. At the end of the operation, place back the oil filler plug.
Topping up the coolant level WARNING This operation has to be performed only by a Benelli Q.J. Authorized Workshop. Perform the topping up of the coolant when the engine is off and cold. Never attempt to remove the coolant filler cap when the engine is hot, in order to avoid the risk of burns. The cooling system is under pressure! Under certain conditions, ethylene glycol contained in the coolant can become flammable.
If the brake pads are excessively worn out, the effectiveness of the braking system decreases, increasing the risk of accidents. Check frequently, from a Benelli Q.J. Authorized Workshop, the wear and tear of the linings and, wherever need, make them replaced.
The level of the brake fluid decreases as the brake pads wear down. Ensure that the fluid level is always between the MAX and MIN marks. If the level falls below the MIN mark, contact a Benelli Q.J. authorized service center and have the brake system overhauled.
If you make a provisional or emergency repair to a tyre, you must ride at very low speed until you reach the nearest Benelli Q.J. authorized service center and have the tyre replaced. With a provisionally repaired tyre, never exceed 60 km/h (37.2 Mph).
Before riding, always verify the absence of cracks, bending or buckling on the wheel rims. WARNING If you find that the wheel rim is damaged, have it replaced by a Benelli Q.J. authorized service center. Never attempt to repair the wheel rim, even in case of slight damage.
Correctly dispose of exhaust kerosene, in order to avoid environmental pollution. If you are not sure that you can use kerosene in complete safety, don’t use it and, when you can go to a Benelli Q.J. authorized service center ask for the drive chain cleaning.
Page 41
Replacing the fuses The replacement of the fuses has to be performed only by a Benelli Q.J. authorized service center. Only in case of extreme urgency and if it is not possible to have a special- ized technical assistance, the operation can be carried out by the owner according to the indications provided below.
In case of prolonged inactivity, to avoid shortening the life of the battery, it is essential to have it recharged by a Benelli Q.J. authorized service center every 4-5 months, in order to guarantee its life in time.
Tornado Naked Tre 1130 6.14 Prolonged inactivity If the motorcycle is not to be used for a long period, contact a Benelli Q.J. authorized service center to have the following operations carried out: - Empty the fuel tank. - Remove the battery and store it in a suitable place.
Tornado Naked Tre 1130 Technical information Benelli Q.J. reserves the right to make any changes to its models on the purpose of constantly conform them to the technological advance. Therefore the technical data that are shown below, can be different from those that can be checked on the vehicle.
Page 45
Tornado Naked Tre 1130 101 KW (135CV) Maximum net power IGNITION - POWER SUPPLY to 9500 rpm “VALBRO TDD“ 110 Nm to Maximum net torque integrated 7750 rpm Type ignition-injection system.Inductive FUEL discharge electronic Recommended fuel Lead-free premium ignition, “Multipoint” petrol electronic injection.
Page 46
Tornado Naked Tre 1130 Rear Rear Type Single steel disc Progressive, with mono Disc diameter 240 mm (9.5 in) shock absorber which Caliper 2-piston can be in extension Calipers, piston 32 mm (1.3 in) Type regulated, diameters spring-loaded. RIMS Front Swingarm Steel trestle Type...
Tornado Naked Tre 1130 Variants This section is dedicated to all the variants included in the Tornado Naked Tre Sport ,Titanium and Cafè racer. Tornado Naked Tre 1130 8.1 Adjusting the front suspension Rebound damper hydraulic device Spring preload Compression damper hydraulic device Adjustments valid for models: SPORT - TITANIUM.
Tornado Naked Tre 1130 8.1.1 Adjusting front suspension spring preload Adjusting of the spring preload is performed by counting the rule turns (A), either clockwise and anticlockwise. turns Giri Turn clockwise for stiffer preload adjustment. Turn anticlockwise for softer preload adjustment. WARNING It is essential that the adjusters of both fork rods are adjusted to the same posi-...
Page 49
Tornado Naked Tre 1130 Adjusting the rear suspension Tornado Naked Tre Sport / Titanium Compression damper hydraulic device Hydraulic system braking at high speed compression Spring preload Rebound damper hydraulic device Tornado Naked Tre 1130 WARNING The high temperature of the exhaust pipes can cause burns.
Tornado Naked Tre 1130 8.2.1 Adjusting rear suspension spring preload Adjust the spring preload by means of the two ring nuts (A and B) shown in the figure. Unloose the ring nut (A) and adjust the preload using the ring nut (B). Turn clockwise for a stiffer preload.
Tornado Naked Tre 1130 Power Control System Activation This system allows to select two different settings of the tune: STANDARD: With botton in OFF position (light on) the engine performs 137hp (101 KW * **) ECONOMY: With button in ON position (light off) the engine performs 112 hp (82 KW*) allowing a more linear distribution, a decreased fuel consumption included between 10% and 20 % depending on the road.
Page 53
This warranty extends to the first person who buys this exhaust system for purposes other than resale, and to all subsequent buyers. Warranty claims should be directed to: Benelli America, LLC - Tel. +1 7245936208 Tornado Naked Tre 1130...
Page 54
Otherwise, the owner may become subject to penalties under state and local ordinances. Problems that may affect motorcycle emissions If you are aware of any of the following symptoms, have the vehicle inspected and repaired by a Benelli’s autorized centre. Symptoms: •...
Page 55
Don’t drink and ride. Vehicle identification number (VIN): The vehicles identify by anumber (see chapter number 1.2) Z B N T N T 000000 Vehicle Variants Check Model Factory Frame BENELLI type digit year place number versions...
Page 56
Tornado Naked Tre 1130 Evaporation emission system This system consists of 1) Left intake manifold; 2) Jet; 3) Carbon canister; 4) Fuel tank; 5) Fuel tank - bottom view Tornado Naked Tre 1130 TnT Labels USA...
Page 57
Warranty on emission control system Benelli Q.J. s.r.l. - Strada della Fornace Vecchia s.n. - 61100 Pesaro - Italy warrants that each new 2005 and later Benelli motorcycle, that includes as standard equipment a headlight, tail-light and stoplight, and is street legal: A) is designed, built and equipped so as to conform at the time of initial retail purchase with all applicable regulations of the United States Environmental Protection Agency, and the California Air Resources Board;...
Page 58
This warranty does not cover inconvenience or loss of use of the motorcycle or transportation of the motorcycle to or from the Benelli dealer. Benelli shell not be liable for any other expenses, loss or damage, whether direct, incidental, consequential or exemplary arising in connection with the sale or use of or inability to use for any purpose.
Page 59
Tornado Naked Tre 1130 Any total or partial reproduction is forbidden. Benelli Q.J. is continuously looking for advanced solutions to be used in product design and for the constant improvement of product quality. Therefore, although this CD ROM contains the most updated information on and photos of the motorcycle available on the date of its publication, there could be slight discrepancies between the motorcycle and the CD ROM.
Need help?
Do you have a question about the Tornado Naked Tre Sport Cafe 1130 Racer and is the answer not in the manual?
Questions and answers