Table of Contents
Advertisement
Quick Links
Advertisement
Table of Contents
Related Manuals for Quicksilver Activ 605 Open
Summary of Contents for Quicksilver Activ 605 Open
- Page 1 Activ 605 Open Owner’s Manual...
- Page 3 Welcome Congratulations on becoming a new owner of a Quicksilver® boat. This Owner’s Packet will provide important information about the features of your boat and should be, at all times, kept aboard your boat. Take time to carefully review the information in this packet to really get to know your boat.
- Page 4 Information in this publication is based upon the latest production specifications available at printing. Quicksilver® reserves the right to make changes at any time, without notice, in the colors, equipment, specifications, materials and prices of all models, or to discontinue models. Should changes in production models be made, Quicksilver®...
-
Page 5: Table Of Contents
Table of Contents Introduction 7. Steering ............20 1. Owner’s Manual ..........vi 8. Engine Controls ..........21 2. Your Responsibilities ........vi 9. Emergency Engine Shutdown Switch ... 22 3. Safety / Warning Labels ........ vi 10. SmartCraft™ System Gauges ......22 4. -
Page 6: Introduction
Introduction 1. Owner’s Manual The material here and the rest of the Owner’s manual packet: • Gives you basic safety information • Describes the fundamentals of boat use • Describes the features of your boat • Describes the equipment on your boat •... -
Page 7: Dealer Responsibilities
CIN Locations 6. Warranty You will find information regarding the Quicksilver® warranty following the introduction. A warranty information card is also included in the owner information packet. If for some reason this information is missing, contact your Quicksilver® dealer. - Page 8 This Limited Warranty does not apply to any Quicksilver® which has been salvaged or declared a total loss or a constructive total loss for any reasons not covered in this Limited Warranty. This Limited Warranty also does not apply to the following items: 1.
- Page 9 Limited Warranties stated. To the extent allowed by law neither Brunswick Marine in EMEA, not the selling dealer shall have any responsibility of the loss of use of the Quicksilver®, loss of time, inconvenience, commercial loss or consequential damages.
- Page 10 Limited Warranty, and the owner must notify Brunswick Marine in EMEA of any Quicksilver® being repaired by an authorized Brunswick Marine in EMEA dealer which has been at the dealership for fifteen (15) days, or of any claimed defect which was not corrected after one (1) repair attempt.
- Page 11 Limited Warranties stated. To the extent allowed by law neither Brunswick Marine in EMEA, not the selling dealer shall have any responsibility of the loss of use of the Quicksilver®, loss of...
- Page 12 Limited Warranty, and the owner must notify Brunswick Marine in EMEA of any Quicksilver® being repaired by an authorized Brunswick Marine in EMEA dealer which has been at the dealership for fifteen (15) days, or of any claimed defect which was not corrected after one (1) repair attempt.
-
Page 13: Basic Boat Dimensions & Specifications
Quicksilver 605OP — General Information 1. Basic Boat Dimensions & Specifications MAX OPTIONS Manufacturer: Brunswick Marine in EMEA Model: Quicksilver Activ 605OP Design Category: Overall Height (H 2.00m Length of Hull (L 5.75m Light Craft Mass (m 1245kg Length Overall (L 5.95m... -
Page 14: Vessel Stability
Quicksilver 605OP — General Information 2. Vessel Stability The following maximum load has been used for assessing the stability and buoyancy comprising • Manufacturer’s maximum recommended load per ISO 14946 744kg • Fuel, fresh water, other fluids to maximum capacity of fixed tanks... -
Page 15: Passenger Locations
Quicksilver 605OP — General Information 4. Passenger Locations Be aware of your footing while the boat is underway. Gelcoat surfaces are slippery when wet. Use extreme Slipping or falling could result in serious injury or death, caution when walking on wet surfaces. -
Page 16: Safety Label Locations
Quicksilver 605OP — General Information 6. Safety Label Locations... -
Page 17: Deck Layout (Standard Equipment)
Quicksilver 605OP — General Information 7. Deck / Cockpit Layout (standard equipment) Anchor roller Anchor hatch Bow rail (P&S) Navigation lights (P&S) Bow cleat (P&S) Bow hatch Cup holder (P&S) Console hatch Console windscreen Dash panel Helm bucket seats Fuel tank access plate Midship rail (P&S) -
Page 18: Deck Layout (Optional Equipment)
Quicksilver 605OP — General Information 8. Deck / Cockpit Layout (optional equipment) Bow windlass Starboard extended swim platform Bow conversion cushion Console backrest Bow table Console cushion Leaning post Port sun lounge extension cushion Transom shower Starboard sun lounge extension cushion... -
Page 19: Cockpit Storage
Quicksilver 605OP — General Information 9. Cockpit Storage Anchor locker Do not store any equipment containing petrol (outboard Bow storage engines, portable petrol tanks, etc.) in any cockpit storage Console storage areas. These compartments were not designed to store Bench seat storage petrol and do not have adequate ventilation. -
Page 20: Dash Layout
Quicksilver 605OP — General Information 11. Dash Layout (standard equipment) SC1000 speedometer SC1000 tachometer Hydraulic steering Steering wheel Air temperature sensor Helm switch panel Engine shutdown switch Engine key Engine throttle shift control 12V receptacle Cup holder Dash Layout (optional equipment) -
Page 21: Navigation Lights
Quicksilver 605OP — General Information Dash Switch Panel Bilge pump Anchor/ navigation light Fresh water (optional) 12. Navigation Lights Your boat comes equipped with navigation lighting for use at night or in low visibility conditions. Prior to running at night, you must install the stern pole light into the socket located on the transom. A three position switch, located at the helm switch panel, controls the navigation lights. -
Page 22: Engine
Operator’s Manual. Refer to the Engine Owner’s Manual for operating instructions and warranty information. The engines are warranted directly by Mercury, not by Quicksilver®. 14. Trailering Quicksilver® does not offer a trailer for this boat, however, if you plan on purchasing one from another vendor, please consider the following: •... - Page 23 Quicksilver 605OP — General Information Strong Points Bow cleat (P&S) Stern cleat (P&S) Anchor cleat Bow eye Stern eye (P&S) It is the owner’s/operators responsibility to ensure that Towing or being towed can lead to fatigue of the boat’s mooring lines, towing lines, anchor chains, anchor lines and hardware and lines.
-
Page 24: Fuel System
Quicksilver 605OP — System & Component Overview and Operation 1. Fuel System Your boat’s petrol fuel system consists of a fuel tank, a fuel tank fill, a fuel tank vent fitting, an anti- siphon valve, a sending unit, and an engine fuel supply line. In addition, there is an extra fuel port for an optional pickup, if needed. - Page 25 Your boat was manufactured, and shipped from the factory with ethanol compatible materials. Before introducing petrol with ethanol into your fuel tank, ask your dealer if any components have been added or replaced that are not recommended by Quicksilver, Mercury or may not be ethanol- compatible.
-
Page 26: Fresh Water System (Optional)
Quicksilver 605OP — System & Component Overview and Operation Storage Long periods of storage and/or non-use, common to boats, create unique problems. When preparing to store a boat for extended periods, disconnect the fuel line. REFER TO THE ENGINE MANUFACTURER’S MANUAL IN YOUR OWNER’S MANUAL PACKAGE FOR COMPLETE INSTRUCTIONS AND WARRANTY INFORMATION. -
Page 27: Bilge Pump
Quicksilver 605OP — System & Component Overview and Operation Fresh Water Water pump strainer Water tank fill Water pump Water tank vent Water pump distribution hose Water tank vent hose Transom shower hose Water tank fill hose Transom shower Water tank... -
Page 28: Fire Prevention
Quicksilver 605OP — System & Component Overview and Operation If water does not come out of the discharge hose: 1. Remove the motor module to see if the impeller rotates with the power on. 2. Remove any debris that may have accumulated in the nozzle section or strainer base. -
Page 29: Carbon Monoxide Monitor
5. Carbon Monoxide Monitor Quicksilver® boats are equipped with carbon monoxide (CO) monitors in the cabin and enclosed berths or staterooms. Carbon Monoxide is an odorless, colorless, and tasteless, extremely toxic gas produced by engines, heaters, stoves or generators. When inhaled it combines with hemoglobin in the blood, preventing absorption of oxygen and is unlikely to be noticed until the person is overcome. - Page 30 Quicksilver 605OP — System & Component Overview and Operation or around your boat at dangerous levels even if your engine is no longer running. To minimize the risk of Carbon Monoxide poisoning, consider the following: • Make sure that at all times, there is good ventilation throughout the boat. Open all hatches, portlights, or canvas openings to let fresh air circulate.
-
Page 31: Bow Anchor Windlass
In the event that there is a loss of power, the windlass can still be used to raise or lower the anchor manually. If there is a loss of power, check the windlass breaker to see if it needs to be reset. If you reset the breaker and it continues to trip, have your authorized Quicksilver® dealer inspect the system. -
Page 32: Steering
Quicksilver 605OP — System & Component Overview and Operation To manually raise the anchor, loosen the clutch by turning the handle counter-clockwise, and pull the anchor up into the boat. Make sure to properly feed the rode and chain through the windlass when pulling up the anchor. -
Page 33: Engine Controls
Quicksilver 605OP — System & Component Overview and Operation Hydraulic Steering Steering wheel Hydraulic fluid fill Helm pump Steering hose Steering cylinder 8. Engine Control Your boat comes with a mechanical gear shift/throttle control unit, located to the starboard of the steering wheel, which activates both the shifting and throttle for the engine. -
Page 34: Emergency Engine Shutdown Switch
In addition, Quicksilver® offers an optional factory installed GPS along with Mercury’s Vessel Link system. If both are installed, the same engine data that you see on your SmartCraft gauges can be displayed on your GPS. -
Page 35: Stereo (Optional)
Bluetooth® settings. In certain countries, radio signals are broadcasted digitally. Quicksilver® offers a DAB antenna, where required, for reception of digital broadcast signals. -
Page 36: Transom Door
Quicksilver 605OP — System & Component Overview and Operation 13. Transom Door To enter your boat, there is a hinged transom door on the port side of the boat. To open, lift up the door by the grab rail and rotate inboard. To close it, rotate it back, lift it and drop it in the deck detail to lock it into place. -
Page 37: Leaning Post (Optional)
Quicksilver 605OP — System & Component Overview and Operation Bow Sun Lounge Kit and Extension Bow sun lounge kit Console back rest Console seat cushion Bow conversion cushion Bow seat filler cushion Sun lounge filler panel Starboard extension cushion Starboard extension panel... -
Page 38: Ski Pole (Optional)
When the ski pole is not in use, it can be stored inside the aft bench seat. The ski pylon is only used for water skiing or wakeboarding. If you are tubing or engaging in other recreational towing, Quicksilver® recommends that you attach the tow rope to the stern eyes at the transom of your boat. -
Page 39: Canvas (Optional)
Quicksilver 605OP — System & Component Overview and Operation The deck plate is a downflooding point. When the ski pole is Remove the ski pylon from the base before raising engine to not in use, verify that the deck plate is properly installed. -
Page 40: Dc Electrical
The DC electrical system is powered by a single battery, and is kept charged by the engine driven alternator. 2. Battery Quicksilver® recommends AGM type starting or a deep cycle battery for you boat. The battery must meet the minimum capacity required by the engine manufacturer. Refer to your engine owner’s manual for exact battery requirements. -
Page 41: Fuses And Breakers
Quicksilver 605OP — Electrical Systems 5. Fuses and Breakers Your boat will either have fuses or breakers protecting the DC electrical system. If you have to replace a fuse or electrical breaker, replace only with a fuse or breaker of the same rating. The amperage will be marked on the fuse or breaker, and it is recommended that you carry spare fuses or breakers. -
Page 42: Electrical Schematics
These electrical schematics were generated by the Electrical Engineering Department for technical reference and service technicians. Quicksilver® does not recommend that you attempt to work on the boat’s electrical system yourself. Instead, we recommend that you take your boat to your local authorized Quicksilver®... - Page 43 Quicksilver 605OP — Electrical Systems DC Wiring...
- Page 44 Quicksilver 605OP— Electrical Systems Bow Windlass Schematic...
-
Page 45: Maintenance
If the growth is more severe, you may need to enlist the services of a professional hull cleaning company. Check with your Quicksilver® dealer for recommendations on a compatible rubbing compound for your boat or a professional hull cleaning company in your area. -
Page 46: Component Maintenance
Frequent routine cleaning of your stainless steel will help maintain the finish. Quicksilver® recommends that you wash stainless steel components with mild soap and cold or lukewarm water after every use of the boat. If added protection is necessary, apply a cleaning wax. - Page 47 Do not store any of the canvas pieces while wet. The effects of ultraviolet light can sometimes be reduced by chemical treatment of canvas items. Consult your Quicksilver® dealer or check your canvas manufacturer’s manual before using any chemical treatments on your canvas.
- Page 48 Quicksilver 605OP — Maintenance Dry the window with a soft cloth or chamois to prevent water spots. Polish with a separate cloth. Don’t leave cleaners on for long periods; immediately wash the window. Finally, don’t apply cleaners in direct sunlight or at elevated temperatures.
- Page 49 Quicksilver 605OP — Maintenance THIS PAGE INTENTIONALLY LEFT BLANK...
- Page 50 OWNER’S MANUAL RECEIPT Please fill out the following form, sign it, and give it to the dealer in order to ensure full warranty coverage: Name: _______________________________________________________ Address: _______________________________________________________ _______________________________________________________ _______________________________________________________ _______________________________________________________ Certify that I have received the Owner’s Manual for the following boat: Brand: __Quicksilver ________ Model:...