Minuteman Mirage M220028K17X Parts And Instruction Manual page 16

WORK PLACE/INDUSTRY GUIDELINES FOR CO EXPOSURE LIMITS
Limits for permissible exposure to CO vary substantially from region to region, City, State, and Industry
requirements should be consulted prior to use of any equipment. The current Occupational Safety and Health
Administration (OSHA) Permissible Exposure Limit (PEL) for CO is 50 ppm, as an 8-hour time-weighted-average
(TWA), This is computed by making measurements at intervals over 8 hours, then adding the sums of the
concentrations and the intervals, and dividing by 8 hours, For example:
The current National Institute for Occupational Health and Safety (NIOSH) has determined that concentrations
above the recommended level for CO of 1,200 ppm are Immediately Dangerous to Life and Health (IDLH). NIOSH
defines the IDLH exposure level as the concentration that could result in irreversible health effects or death, or
prevent escape from the contaminated environment within 30 minutes.
DEFINITION OF CO EFFECTS
The toxic effects of carbon monoxide in the blood are the result of tissue hypoxia (lack of oxygen) carbon
monoxide combines with hemoglobin to form carboxyhemoglobin. Since CO and oxygen react with the same group
in the hemoglobin molecule, carboxyhemoglobin is incapable of carrying Oxygen. The affinity of hemoglobin for CO
is 200 to 240 times greater than for oxygen. The extent of saturation of hemoglobin with CO depends on the
concentration of the gas, the quantity of inspired air and on the time of exposure. The severity depends on the
state of activity of the individual and his tissue oxygen needs.
According to Harrison's Principles of Internal Medicine 7th edition, no symptoms will develop at a concentration of
0.01 % CO (100ppm) in inspired air, since this will not raise blood saturation above 10 %. Exposure to 0,05%
(500ppm) for 1 hour during light activity will produce a blood concentration of 20% carboxyhemoglobin and result
in a mild or throbbing headache. Greater activity or longer exposure causes a blood saturation of 30 to 50 %. At
this point headache, irritability, confusion, dizziness, visual disturbance, nausea, vomiting, and fainting can be
experienced. Exposure for one hour to concentrations of 0.1 % (1000ppm) inspired air the blood will contain 50 to
80% carboxyhemoglobin which results in coma, convulsions, respiratory failure and death. On inhalation of high
concentrations of CO, saturation of the blood proceeds so rapidly that unconsciousness may occur suddenly
without warning.
Parts and Instruction Manual - Mirage 27" Propane Burnisher
Time
8:00-9:00
9:00-10:00
10:00-11:00
11:00-12:00
12:00-1:00
1:00-2:00
2:00-3:00
3:00-4:00
ANY 8 HR PERIOD 8HR
400ppm/8HR=50ppm (TWA)
Interval
1HR 100
1HR 25
1HR 25
1HR 50
1HR 50
1HR 50
1HR 50
1HR 50
400 PPM
Page 9