Engine Troubleshooting - Minuteman Mirage M220028K17X Parts And Instruction Manual

Note: When trouble occurs be sure to check for simple causes, which at first may seem too obvious to be
considered. For example, a starting problem could be caused by propane starvation due to an empty propane
cylinder or an unopened service valve.
SYMPTOM
Starter Motor Does Not Operate
Engine Turns Over But Does Not Start or Run Fuel Tank Not Connected
Engine Runs with Loss of Power or Excessive
Exhaust Fumes
Engine Running Hot or Over Heating
High Oil Consumption
Engine Knocks and Other Engine Noises
Electric Clutch Will Not Engage*
(*If Unit Is Equipped With This Option)
Parts and Instruction Manual - Mirage 27" Propane Burnisher
TROUBLESHOOTING GUIDE
POSSIBLE CAUSE
Weak or Dead Battery
Ignition Switch Faulty
Dead Man Switch Not Engaged*
Dead Man Switch Faulty*
For Additional Causes
Fuel Tank Empty
No Fire at Spark Plug
Engine Oil Pressure Low
Oil Pressure Switch Faulty*
For Additional Causes
Restriction in Air Cleaner
Ignition System Misfire
Poor Compression or Timing
Intake Screen or Bonnet Filter Clogged
Cooling Fins Clogged
Numerous Causes
Numerous Causes
Loose or Faulty Wiring
Clutch Switch Faulty
Clutch Out of Adjustment
CORRECTIVE ACTION
Recharge or Replace Battery
Check or Replace Switch
Engage Dead Man Switch Prior to Engaging
Starter
Check or Replace Dead Man Switch
See Engine Manual or Dealer
Disconnect and Reconnect Tank
Refill or Replace Tank
Replace Spark Plug
Check and Fill Oil To Correct Level
Check or Replace Oil Pressure Switch
See Engine Manual or Dealer
Service Air Cleaner
Check or Replace Ignition Coils
See Engine Manual or Dealer
Clean Screen and or Bonnet Filter
See Engine Manual for Cleaning
See Engine Manual or Dealer
See Engine Manual or Dealer
Check Wiring
Check or Replace Clutch Switch
See Your Dealer
Page 15