Section 9 − Parts List; Recommended Spare Parts - Miller Big Blue 500 Pro Owner's Manual

Trouble
Engine suddenly stops.
Engine slowly stopped and cannot be
restarted.
Battery discharges between uses.
Engine idles, but does not come up to
weld speed.
Engine does not run at idle speed.
Engine uses oil during run-in period;
wetstacking occurs.

9-1. Recommended Spare Parts

Dia.
Mkgs.
. . . . . . . . . . . . . . . . . . . . 276418
. . . . . . . . . F1, F2 . . . 085874
. . . . . . . . . . . . . . . . . . . . 273293
. . . . . . . . . . . . . . . . . . . . 273283
. . . . . . . . . . . . . . . . . . . . 273284
. . . . . . . . . . . . . . . . . . . . 273285
. . . . . . . . . . . . . . . . . . . . 273286
. . . . . . . . . . . . . . . . . . . . 273287
. . . . . . . . . . . . . . . . . . . . 273288
. . . . . . . . . . . . . . . . . . . . 273289
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
To maintain the factory original performance of your equipment, use only Manufacturer's Suggested
Replacement Parts. Model and serial number required when ordering parts from your local distributor.
.
Complete Parts List available at www.MillerWelds.com
Check oil level. Automatic shutdown system stops engine if oil pressure is too low or engine temperature
is too high (see Section 5-5). Automatic shutdown system is inhibited for 30 seconds after start-up.
See engine manual.
Check fuel level.
Check engine air and fuel filters (see Sections 8-4 and 8-10).
See engine manual.
Turn Engine Control switch off when unit is not running.
Clean top of battery with baking soda and water solution; rinse with clear water.
Recharge or replace battery if necessary.
Periodically recharge battery (approximately every 3 months).
Have engine Factory Authorized Service Agent check speed control.
Circuit breaker CB14 may be open. CB14 automatically resets when fault is corrected (see Section
8-11). Have engine Factory Authorized Service Agent check speed control.
Have Factory Authorized Service Agent check control relays CR3 and CR4.
Dry engine according to run-in procedure (see Section 12).
SECTION 9 − PARTS LIST
Part
No.
. . USB Flash Drive
. . Fuse, Mintr Cer Slo-blo 10. Amp 250 Volt
. . Kit, Filters Kubota (V2403) Engine (Consisting Of)
. . . . Filter, Air Element Primary
. . . . Filter, Air Element Safety
. . Filter, Fuel Primary Cartridge
. . Filter, Fuel/Water Separator Secondary Cartridge
. . . . Filter, Oil Cartridge
. . Belt, Fan . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . Separator, Oil W/o Ring
Battery, Stor 12v 925 Crk 195 Rsv Gp 31 Maint Free
Remedy
Description
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . . .
. . . . . . . . . . . . . . . . .
OM-278739 Page 55
Quantity
1
2
1
1
1
1
1
1
1
1
1