Table of Contents
Related Manuals for Cornelius IDC 2XX
Summary of Contents for Cornelius IDC 2XX
- Page 1 ® 2XX with Cold Carbonation Operator’s Manual Release Date: October 18, 2005 Publication Number: 621057403OPR Revision Date: August 3, 2010 Revision: F Visit the IMI Cornelius web site at www.cornelius.com for all your Literature needs.
-
Page 2: Contact Information
Product and is subject to all of the restrictions and limitations contained in the Commercial War- ranty. Cornelius will not be responsible for any repair, replacement or other service required by or loss or damage resulting from any of the following occurrences, including but not limited to, (1) other than... -
Page 3: Table Of Contents
TABLE OF CONTENTS Safety Instructions ............1 Read and Follow all Safety Instructions . -
Page 4: Safety Instructions
Only trained and certified electrical, plumbing and refrigeration technicians should service this unit. ALL WIRING AND PLUMBING MUST CONFORM TO NATIONAL AND LOCAL CODES. FAILURE TO COMPLY COULD RESULT IN SERIOUS INJURY, DEATH OR EQUIPMENT DAMAGE. © 2005-2010, IMI Cornelius Inc. AFETY NSTRUCTIONS... -
Page 5: Safety Precautions
Publication Number: 621057403OPR ARNING OUNTER - 2 - gas leaks in the entire CO © 2005-2010, IMI Cornelius Inc. -
Page 6: Start-Up And Operating Instructions
© 2005-2010, IMI Cornelius Inc. F. This could cause damage to the unit. - 3 - IDC Operator’s Manual... -
Page 7: Cleaning And Maintenance Instructions
IDC Operator’s Manual CLEANING AND MAINTENANCE INSTRUCTIONS These instructions are used on all Cornelius ice drink dispensers. Some models may have additional cleaning requirements. Those models will have addition procedures listed later in the manual. WARNING: Disconnect power to the unit before cleaning or servicing following all lock out / tag out procedures established by the user. -
Page 8: Monthly Cleaning
6. Install and properly position the access covers on the cold plate. 7. Install the splash panel in the reverse order it was removed. 8. Rinse cold plate surface by pouring potable water through hopper openings. © 2005-2010, IMI Cornelius Inc. - 5 - IDC Operator’s Manual... -
Page 9: Dispensing Valves ( Daily Cleaning)
9. Remove the sanitizing fittings from the B–I–B disconnects and connect the disconnects to the appropri- B–I–B container. Operate the valves until all sanitizer has been flushed from the system and syrup is flowing freely. Publication Number: 621057403OPR system. - 6 - © 2005-2010, IMI Cornelius Inc. -
Page 10: Replenishing Co2 Supply
(back-seating the valve prevents gas leakage around the valve shaft). Check CO connections for leaks. Tighten any loose connections. © 2005-2010, IMI Cornelius Inc. cylinder valve. cylinder cylinder. regulator assembly coupling nut, then install the regulator... - Page 12 IMI Cornelius Inc. www.cornelius.com...
Need help?
Do you have a question about the IDC 2XX and is the answer not in the manual?
Questions and answers