Safety Instructions; Installation; Use; Maintenance & Cleaning - Winterwarm DXE80 Installation Manual

2. Safety instructions

Always follow the safety instructions in this chapter when
installing, using or performing maintenance on this air
heater:

2.1. Installation

CAUTION! This air heater must be installed and
maintained by an authorized, qualified and competent
installer, using calibrated equipment.
NOTICE This air heater must be installed and maintained
in accordance with this manual, national and local building
regulations and local health and safety regulations.
2.1.1. Protection against dust
CAUTION! Cover the air heater while spreading sawdust
on the floor. This prevents large amounts of dust from
accumulating on the heater.
CAUTION! The air heater can be used in a dusty
environment (e.g. a poultry shed) if they are cleaned and
maintained more frequently.
2.1.2. Temperature
CAUTION! Do not install the heater in places where the
temperature can rise above 40°C. Higher temperatures
cause the internal components to degrade much faster.
2.1.3. Corrosive vapours
WARNING! Do not install the air heater in areas that
contain any corrosive or explosive vapours. Corrosive
vapours (e.g. containing Chlorine) that are sucked into the
air intake will cause corrosion of the heat exchanger and a
leakage of condensate and flue gas. This is also the case
for the room thermostat.

2.2. Use

CAUTION! Make sure the area around the air heater is
dry when performing maintenance on the air heater.
CAUTION! Always close the doors and inspection hatches
of the air heater, except when adjusting and checking the
appliance.
4
2.3. Maintenance & Cleaning
Frequent maintenance and cleaning of the air heater is
necessary to ensure safe and proper operation. Failure
to do so could lead to damage to the heater or its
surroundings and void the warranty.
CAUTION! Air heaters installed in a dusty and/or wet
environment must be maintained and cleaned more
frequently.
CAUTION! Air heaters installed in poultry sheds must be
maintained and cleaned after every breeding cycle.
2.3.1. Protection from water (IP class)
WARNING! Never use water when cleaning electrical
parts.
This air heater is protected against splash water and has
an IPX4D classification.
WARNING! Do not use a pressure washer to clean parts
that contain electronics, such as the electric motor or the
machine cover.
2.3.2. Disinfecting fluids
CAUTION! Some aggressive disinfection fluids can
damage the heater. When using such fluids, cover the
heater while disinfecting the shed.

2.4. Children and vulnerable users

WARNING! This air heater can be used by children aged
8 years and above and by persons with reduced physical,
sensory or mental capabilities or lack of experience and
knowledge, if they are supervised or instructed concerning
use of the appliance in a safe way and understand the
hazards involved.
WARNING! Children shall not play with the air heater.
WARNING! Children shall not clean and maintain this air
heater without supervision.