Summary of Contents for Groen SmartSteam OM-SSB-3E
Page 1
important information i keep for operator i important information om-ssb-3e/5e/10ef operator manual part number 145145 rev. D Domestic moDels: ssb-3e/5e/10ef, (2)ssb-3e/5e/10ef smartsteam ™ boilerless steamer self-contained electric-Heated capacity` 3, 5 or 10 pans steamer pans [per cavity] (12” x 20” x 2 1/2”) Use for steamers with Serial Numbers ending with “MSD”...
Page 2
HyDroXiDe or tHat is alKaline. warning: use of any replacement parts otHer tHan tHose supplieD by groen or tHeir autHoriZeD Distributor voiDs all warranties anD can result in boDily inJury to tHe operator anD Damage tHe equipment. service by otHer tHan factory-autHoriZeD personnel will voiD all warranties.
Description Your Groen SSB-E/5E/10E or ()SSB-E/5E/10E Electric SSB-E/5E/10E units are distinguished from Smartsteam Boilerless Steamer is designed to the rear by the addition of a fuse box, which lets give years of service. It has a stainless steel cavity operators change fuses without removing panels.
om-ssb-3e/5e/10ef installation and startup warning tHe unit must be installeD by personnel wHo are qualifieD to worK witH electricity anD plumbing. improper installation can cause inJury to personnel anD/or Damage to tHe equipment. tHe unit must be installeD in accorDance witH applicable coDes. caution Do not install tHe unit witH tHe rear vents blocKeD or witHin 2 incHes of a Heat source sucH as a braising pan, Deep fat fryer, cHarbroiler or Kettle.
Page 6
om-ssb-3e/5e/10ef warning to avoiD Damage or personal inJury, follow tHe wiring Diagram eXactly Current and power demands for each unit are as shown below. electrical supply connections rateD current DemanD per cavity SSB Steamer (KW RATING) 08 P 08 1p 0 1p 0 1- 0 p...
Page 7
om-ssb-3e/5e/10ef Install the drain line with a constant downward pitch. electrical supply connection important: Do not allow water traps in the line. Separate electrical connections will be A trap can cause pressure build-up in the cavity, required for each steamer to be stacked. Each which may cause the door gasket to leak.
Page 8
om-ssb-3e/5e/10ef initial startup After the SmartSteam Boilerless Steamer has been 6. To shut down the unit, press the ON/OFF touch installed, test it to ensure that the unit is operating pad. The steam generating reservoir will then correctly. drain. 7. If the SSB-E/5E/10E behaves as described Remove all literature and packing materials the unit is functioning correctly and ready for from the interior and exterior of the unit.
om-ssb-3e/5e/10ef operation warning any potential user of tHe equipment must be traineD in safe anD correct operating proceDures. a. controls The unit will automatically shut off and cannot be turned on again until the Operator controls are on the front right of the unit. steam generator cools and the HI TEMP The SmartSteam Boilerless Steamer control panel indicator light goes out.
Page 10
Close the door. With the READY indicator lit, White Service Light appears and does not go away take one of the following steps: after 0-5 minutes, you should call your local Groen Authorized Service Agent to service the control timeD steaming cooling fan, which is not functioning properly.
This regular cleaning will reduce the effort required to clean the steam generator and cavity. Suggested Tools warning Disconnect tHe power supply Mild detergent before cleaning tHe outsiDe of Stainless steel exterior cleaner Groen tHe steamer. Spray DeGreaser (Part Number 1080WS) Keep water...
Page 12
5 - Remove right fan shroud and rack assembly by lifting rack up and pulling away from cavity wall. • Groen approved delimer may be used to step 6 - Clean steam lid, left pan rack and rack/ remove excessive scale build-up.
However, the following is a list of checks to make in the event of a problem. Wiring diagrams are furnished inside the service panel. If an item on the check list is marked with (x), it means that the work should be done by a Groen Authorized Service Agent.
Page 14
om-ssb-3e/5e/10ef 8. Any unusual User a. Press ON/OFF pad to turn steamer off. Momentarily turn operation. circuit breaker off and then on or unplug from power. Turn unit back on. 9. Door pops open. User a. Ensure drain and vent are not plugged. No more than two units should be attached to a single drain line.
om-ssb-3e/5e/10ef Service Log Model No. ___________________________ Purchased From ______________________ Serial No. ___________________________ Location _____________________________ Date Purchased _______________________ Date Installed _________________________ Purchase Order No. ____________________ For Service Call _______________________ Date Maintenance Performed Performed by...
Page 16
(ii) twenty-four () months from the date of installation or (iii) twenty-seven (27) months from the date of shipment from Groen, whichever first occurs. This warrants Groen Vortex Connectionless Steamers that were shipped after March 15, 00 and SmartSteam Boilerless Steamers that were shipped after May 1, 00.
Page 17
During the Warranty Period, Groen, directly or through its authorized service representative, will either repair or replace, at Groen’s sole election, any Groen Equipment determined by Groen to have a defect in material or workmanship. As to any such warranty service during the Warranty Period, Groen will be responsible for related reasonable labor and portal to portal transportation expenses (time &...
Page 18
(d) Vortex Connectionless Steamers Five percent (5.0%) of the LIST PRICE of the Groen Equipment to be covered by the Limited Extended Warranty for each additional twelve (12) months of limited extended warranty coverage. The five percent (5.0%) of the LIST PRICE charge will be the net invoice amount for each year of Limited Extended Warranty Coverage purchased.
Page 20
1055 Mendell Davis Drive Jackson, MS 97 om-ssb-3e/5e/10ef Telephone 601 7-90 Fax 601 7-9587 revised 09/05 www.groen.com part number 145145 rev. D...