Page 1
INSTALLATION AND OPERATING INSTRUCTIONS for all Hydrocarbon LSR Refrigerator Models 809-200A Rev. 06/07/23 SEE BACK COVER FOR 3779 CHAMPION BLVD, WINSTON-SALEM, NC 27105 WARRANTY REGISTRATION Phone: (888) 845-9800 | Fax: (800) 253-5168 | Web:victoryrefrigeration.com...
Page 2
From the earliest stages of production design, to focused steps in fabrication and assembly, rigid standards of We thank you for your choice and confidence in Victory quality are maintained by our staff of skilled employees. Equipment.
Page 3
R290 equipment. • Clean a dirty condenser with a sharp object. • Use ONLY Victory factory service parts. Use of non • Store gasoline, kerosene or any other flammable OEM parts can be dangerous because of the design material near the cabinet.
Page 4
User Manual for LSR Refrigerators Victory SAFETY CAUTION: If it is necessary to move the Refrigerator after removal from the skid, CAUTION remove all doors and carefully push the unit at a point of no more than 36” from the bottom to avoid damage.
Page 5
User Manual for LSR Refrigerators Victory IMPORTANT INFORMATION This unit is intended to be used in a commercial application. That includes bars and restaurants. If installed in a residence some commercial service companies may not be able to service it on site.
Page 6
Load w x d x h (Inches) Plug Charge (g) / Charge (oz.) Amps (NEMA) LSR23HC 27 1/4 x 34 1/16 x 83 15/16 1 Full Glass R-290 / 90 / 3.04 LSR27HC 30 x 34 1/16 x 83 15/16...
Page 7
User Manual for LSR Refrigerators Victory CLEARANCE AND PLACEMENT 3" 3" LEFT/RIGHT SIDE LEFT/RIGHT SIDE 12" TOP MINIMUM 12" TOP MINIMUM MINIMUM MINIMUM CLEARANCE CLEARANCE CLEARANCE CLEARANCE 6" MINIMUM CLEARANCE 3" 3" REAR REAR MINIMUM MINIMUM CLEARANCE CLEARANCE 3" REAR...
Page 8
User Manual for LSR Refrigerators Victory UNPACKING AND SET UP Carefully inspect the shipping carton for damage. This is the only time that shipping damage may be claimed. If damage is suspected, open the carton immediately and, if there is damage, retain the carton and contact the shipper to make a claim.
Page 9
9. Do NOT overload the shelves. The unit is designed to need to be squeezed slightly during installation. use all shelves that are supplied in an equally spaced manner. Contact Victory customer service if fewer 4. Install all remaining clips. shelves or a different configuration to ensure shelf overloading will not occur.
Page 10
User Manual for LSR Refrigerators Victory ELECTRICAL This is a cord-connected unit, and must be connected to its own dedicated power supply. Check the dataplate on the machine to confirm the voltage and per the dataplate use the correct fuses or HACR circuit breakers.
Page 11
User Manual for LSR Refrigerators Victory USING THE UNIT USING THE UNIT - DANFOSS CONTROLLER Operation is simple, just keep it connected to the correct The refrigerator temperature was set at the factory at 38 º power supply and the refrigerator will maintain the but you can adjust it to your own selected temperature.
Page 12
User Manual for LSR Refrigerators Victory SEQUENCE OF OPERATIONS REFRIGERATOR 2 34 5 6
6
2 5 5 54 8 6
...
Page 13
User Manual for LSR Refrigerators Victory User Manual for UCR Refrigerators Beverage-Air DANFOSS CONTROLLER DEFROST (ESC) Electronic Controller SELECT (OK) DOWN Control Panel Display Note: Defrost is manual, LED indicator is inoperative. Defrost LED Alarm LED On fixed: Defrost active...
Page 17
Refrigerator with Eliwell Controller Refrigerator with Eliwell Controller Beverage-Air Beverage-Air User Manual for LSR Refrigerators Victory SEQUENCE OF OPERATIONS REFRIGERATOR The refrigerator operates based on the air temperature measured by the probe located at the return air. CONTROLLER CONTROLLER COMPONENT...
Page 20
User Manual for LSR Refrigerators Victory CLEANING AND MAINTENANCE Cleaning Schedule: Cabinet Condenser coil Gaskets Routine maintenance Daily wipe down Monthly inspection, Daily inspection, check Annually cleaning as required that hinges are tight to Weekly interior the cabinet. Daily Exterior Cleaning It is much easier to clean on a regular basis than to have to remove stains once they have built up.
Page 21
User Manual for LSR Refrigerators Victory CONDENSER CLEANING Keeping the condenser coil clean is critical to efficient 4. Lower panel completely flat operation. 5. Examine condenser surface, if dusty, brush and 1. Unplug unit from power supply. vacuum the dust and lint from the surface of the coil.
Page 22
User Manual for LSR Refrigerators Victory METHODS FOR CLEANING STAINLESS STEEL Cleaning Needed Cleaning Agent Method of Application Affect on Finish Satisfactory for use on all Areal 20, Lac-O-Nu, Lumin Wash Rub with cloth as directed finishes. Smears and fingerprints O’Cedar Cream Polish, Stainless...
Page 23
User Manual for LSR Refrigerators Victory HELP Trouble Diagnosis for the User Malfunction Possible Cause Likely Solution Connect to proper voltage circuit Replace Unit not plugged in. fuse or reset breaker. No cooling - unit is silent Fuse or circuit breaker tripped.
Page 24
User Manual for LSR Refrigerators Victory FOR THE SERVICE TECH - R290 Refrigeration service should only be attempted by a trained trade professional certified to work on R290 systems. Here are some critical service items. Other Information: This list does not qualify anyone to service the unit. It is a Evacuation: It is critical that a refrigeration system be reminder and checklist for the service tech.
Page 25
User Manual for LSR Refrigerators Victory FOR THE SERVICE TECH - WIRING DIAGRAM FOR DANFOSS CONTROLLER CONDENSER FAN CURRENT RELAY *SEE CONTROLLER DETAIL S.C. COMP CONDENSER FAN CURRENT RELAY COMPRESSOR DETAIL SOME MODELS COMP DANFOSS CONTROLLER DETAIL *SEE CONTROLLER DETAIL...
Page 26
User Manual for LSR Refrigerators Victory FOR THE SERVICE TECH - WIRING DIAGRAM FOR ELIWELL CONTROLLER CNTRL *SEE CONTROLLER DETAIL CONDENSER FAN CURRENT RELAY S.C. COMP CONDENSER FAN CURRENT RELAY COMPRESSOR DETAIL SOME MODELS COMP *SEE CONTROLLER DETAIL ELIWELL CONTROLLER DETAIL...
Page 27
User Manual for LSR Refrigerators Victory UNITS WITH ELECTRONIC SMART LOCK FEATURE • Automatically locks during power loss or when a temperature drop is sensed LSR23HC -IQ & LSR27HC-IQ • Led indicator to quickly view status • Easy access test switch for health inspectors •...
Page 28
Victory® Refrigeration (Victory) warrants to the Proof of purchase must be supplied to Victory to validate original purchaser of Victory branded equipment, that the warranty. This warranty is valid only if equipment is such equipment is free from defects in material and properly installed, and started-up as outlined in the Owner’s...
Page 29
LIMITATION OF LIABILITY: are limited in coverage by this warranty. Any installation Victory or its affiliates shall not be liable for any indirect, that requires extra work, and/or travel, to gain access to the incidental, special or consequential damages, or losses of a...
Page 30
User Manual for LSR Refrigerators Victory Warranty Registration Register your product online at Victory.com/parts-service or fill out and mail the form below. Cabinet Model Number: _____________________________________________ Date Of Installation: _________________ Cabinet Serial Number: _____________________________________________ Location Of Product Business Name: ____________________________________________________...