Page 2
Royal Enfield Support 1800 - 210 - 0007 Roadside Assistance Product Update Feedback Dealer Locator To access dealer details scan the QR code Support@royalenfield.com @royalenfield www.royalenfield.com Download the ROYAL ENFIELD APP and explore more...
Page 3
FOREWORD Congratulations! Welcome to the Royal Enfield family. And to a world of motorcycling that has an enviable heritage, including being the world’s oldest motorcycle marque in continuous production. Since its introduction in 2008, the Classic 350 has captured the imagination of motorcycling enthusiasts across the world with its vintage inspired build, authentic styling and timeless appeal.
Pre-Operational Checks ........... 48 Emission Control System Warranty......95 Running in Period ............. 49 EVAP ................. 103 Starting ..............Service/ Maintenance Record ........105 Gear Shifting, Riding and Stopping ......56 Notes ................ 106 Royal Enfield All New Classic 350...
Indicates a potentially hazardous situation. Disregarding this message may result in injury to rider or other persons. CAUTION This message, if disregarded, may result in damage to the motorcycle. NOTE Indicates important and useful messages for better understanding. Royal Enfield All New Classic 350...
Email : Licence No. Valid till : Model Color : Engine No. VIN. No. Tyre make Front : Rear : Tyre Nos. Front : Rear : Battery make Battery No. Sold by Date of Sale Royal Enfield All New Classic 350...
Switch “OFF” mobile phones and other hand « bar controls, tyre pressures, fuel and oil levels, etc. held electronic devices. Use only genuine Royal Enfield spare parts and Do not smoke and please ensure that there are « approved accessories. Use of other manufacturer’s...
Page 9
WARNING familiar with its operation and handling character- istics under all conditions. Royal Enfield cautions you against the use of certain Do not exceed the legal speed imit or ride too nonstandard parts such as aftermarket and custom fast for existing conditions.
Page 10
suited for riding a motorcycle. Bright/light colours Rough or uneven road surfaces. « are best for greater visibility in traffic, especially at Slippery road surfaces. night. Avoid loose, flowing garments and scarves. « Royal Enfield All New Classic 350...
Page 11
Replace worn out parts. serious injury. Worn out parts can adversely affect stability and Exhaust gas contains poisonous carbon monoxide handling. and chemicals, known to cause cancer, birth defects or other reproductive defects. Royal Enfield All New Classic 350...
Page 12
Keep batteries and acid out of reach of cause loss of control of the motorcycle in the front, children. leading to an accident. Consult your Royal Enfield Authorised Service Centre regarding any questions or problems that occur in the operation of your motorcycle. Failure to do so may aggravate an initial problem, cause costly repairs and jeopardize your personal safety.
Watch for loose debris, such as leaves, slippery, turning either right or left, watch for pedestrians, substances or gravel that can hamper the stability animals, as well as other vehicles. of your motorcycle. Royal Enfield All New Classic 350...
Page 14
Never jump a traffic light. When parking your motorcycle, ensure that the steering a change is imminent from head is locked and then remove the ignition key. GO to STOP (or vice versa) at Royal Enfield All New Classic 350...
Page 15
However, vehicles and other objects seen in this type of mirror will look smaller and farther away than when seen in a flat mirror. Use care when judging the size or distance of vehicles/ objects seen in these mirrors. Royal Enfield All New Classic 350...
Royal Enfield may affect the performance or life of the components for which Royal Distribute weight evenly on both sides of the Enfield cannot be held responsible and Royal Enfield motorcycle.
Page 17
ACCESSORIES AND LUGGAGE Large surfaces such as fairings, windshields, Royal Enfield cautions you against use of non- backrests and luggage racks can adversely affect standard parts such as aftermarket and custom handling of the motorcycle. Use Royal Enfield...
Page 18
Do not exceed the maximum permissible overall wight or the axle loads. If your motorcycle is equipped with saddlebags, a windshield or a passenger backrest, be prepared to reduce operating speed to maintain stability. Royal Enfield All New Classic 350...
Spark plug gap ..... 0.7 to 0.8 mm Max Power ......14.87 kW (20.21 PS) @ Spark plug ......YR7MES/Bosch 6100 rpm Max Torque ......27 Nm @ 4000 rpm Idle RPM ......1050 ± 100 rpm Royal Enfield All New Classic 350...
Page 20
Clutch ........Conventional wet clutch Secondary Sprocket Ratio ... 2.800:1 Primary drive ....... Gear Drive Chain links ....104 links Primary ratio......2.313 Gear box ......Constant mesh Gear ratio ......1 2.615 1.706 1.300 1.040 0.875 Royal Enfield All New Classic 350...
Page 21
Rear ......Twin tube emulsion Rear 120/80 - 18 - 62 P (Tube Type) shock absorbers with 6 step adjustable preload, 90 mm travel Brakes Front disc ....300 mm disc with twin piston floating caliper Royal Enfield All New Classic 350...
Page 22
Failure to use an inner tube in a spoked wheel will cause deflation of the tyre resulting in loss of * The above values are approximate and the actual fuel motorcycle control. filling capacity will vary from the values mentioned. Royal Enfield All New Classic 350...
Page 23
Modifications on the motorcycle which are not Turn signal tell tale ....12 V - LED approved by Royal Enfield may not only disqualify Turn signal ......12 V, 10 W x 2 nos for warranty, but also affects performance of the motorcycle.
Page 24
Do not use the vehicle beyond the allowed gross Saddle height ...... 805 mm weight. The suspensions and tyres are designed to perform only to the maximum gross vehicle weight. Royal Enfield All New Classic 350...
* DO NOT mix DOT 4 & other brake fluids together. CAUTION Use of wrong grade/mixed grade oil will reduce the life of the moving parts and seriously affect performance. NOTE Recommendation subject to change without notice. Royal Enfield All New Classic 350...
The VIN is a 17 digit number punched on the right side production details. It is illegal to tamper with the engine steering head tube in the form of label. number as it is the only means of identifications of the engine. Royal Enfield All New Classic 350...
5. Tripper or Badge (If fitted) 6. Handle Bar Instrument Cluster 8. Ignition Switch 9. Day Flash Switch 10. High Beam/Low Beam Switch 11. Info Button 12. Clutch Lever 13. Turn Signal Switch 14. Charger Port 15. Horn Button Royal Enfield All New Classic 350...
Page 28
Front Wheel* 8. Right Trafficator Front 9. Brake Lever Front 10. Spark Plug DISCLAIMER * The part displayed above are for reference purpose only. This will vary from the parts chosen using motorcycle configurator. Royal Enfield All New Classic 350...
Page 29
Tail lamp Left Trafficator Rear 9. Left Side Panel 10. Seat* 11. Fuel Tank* DISCLAIMER * The part displayed above are for reference purpose only. This will vary from the parts chosen using motorcycle configurator. Royal Enfield All New Classic 350...
Turn key clockwise to dent, resulting in serious injury to both rider and open. other road users, besides causing severe damage Press cap to lock with to the motorcycle. key in position. Royal Enfield All New Classic 350...
Page 31
Fuel Tank Mouth Gasoline vapour is highly explosive. Please ensure Splash Arrestor there are no open flames or sparks nearby while Maximum Fuel level refuelling and fill fuel only in a well ventilated area. Royal Enfield All New Classic 350...
Page 32
Wipe immediately incase fuel spills over as otherwise it will leave a permanent stain on the painted surfaces. CAUTION In case of prolonged stoppage of vehicle, please turn off ignition key to avoid discharge of battery. Royal Enfield All New Classic 350...
Page 33
High Low beam will be selected by toggling the switch. Press the horn button to High beam indicator tell tale located sound horn. in instrument cluster will glow when high beam is selected. Royal Enfield All New Classic 350...
Page 34
DAY FLASH Push the switch to operate high beam filament in head light. It is giving indication to vehicle coming from opposite side while overtaking. Royal Enfield All New Classic 350...
Page 35
4. 4 - LED based tell tales 5. Display Features 5A. Odometer 5B. Trip 1 and Trip 2 5C. Trip F TRIP AMPM kmiles 5D. Fuel Bar Graph 5E. ECO Mode 5A 5C 5F. Service Reminder 5G. Clock Royal Enfield All New Classic 350...
Page 36
Do not run motorcycle incase the malfunction remains “ON” continuously as it can cause servere damage to the ECU & sensors. Please visit the nearest authorised Royal Enfield dealer to diagnose & rectify the defect in the EMS. Royal Enfield All New Classic 350...
Page 37
25 s Linked with stand switch to avoid re-set serious damage to the fuel pump. when in side stand condition. Service Reminder: In case service reminder symbol is “ON” please plan for a scheduled service at an authorized service centre. Royal Enfield All New Classic 350...
Page 38
Trip F reset may occur when riding in mid to rough roads conditions due to frequent fuel oscillations, this feature to be used for refer ence purpose only and on smooth road surfaces. Royal Enfield All New Classic 350...
Page 39
Enter into minutes mode (minutes to blink) setting info 0.2<t<1 Minutes to increment info t>3 Enter into unit mode (AM/PM) to blink info 0.2<t<1 Toggle between AM or PM info t>3 Save data and exit clock setting mode Royal Enfield All New Classic 350...
Page 40
OPERATION OF CONTROLS INFO BOT TON MANAGEMENT DETAILS If Trip F not enabled LCD SEQUENCE (Info switch press <1 sec):- If Trip F enabled NOTE For trip re-set press info button for T>3 sec. Royal Enfield All New Classic 350...
Page 41
RE Mobile app. Tripper is being provided to have turn by turn Navi- gation on motorcycle to help riders to have a hassle free riding without handling the smartphones. This device Royal Enfield All New Classic 350...
Page 42
Tripper unit display may look dull during sun Secondary directionor next to next turn overhead conditions this is normal and due to Distance to next turn impact of direct sunlight on the unit customers to refer during other riding conditions. Royal Enfield All New Classic 350...
Page 43
100 m, if there is no turn the display will be blank in this region. Distance to destination or ETA: Shows the total distance to destination or estimated time of arrival (based on used selection from RE Mobile app). Royal Enfield All New Classic 350...
Page 44
Google helmet lost/no input in paired mode tripper will show Clock clock a) If no connection is established b) If connection is established but no navigation input is observed c) Once destination is reached Royal Enfield All New Classic 350...
Page 45
Tripper as it may result in permanent damage to For first time pairing user needs to enter the the same. secured pin shown on tripper through RE Mobile Royal Enfield All New Classic 350...
Page 46
Calibrate mobile phones frequently for more GPS work in low battery mode. accuracy & location accuracy is dependent on. RE mobile app works only with android (Current Version (-2)) and iOS (Current Version (-1)) Royal Enfield All New Classic 350...
Page 47
USB charging port which may lead to short circuit. Recommended not to use in rainy conditions to avoid damages to smart phones and charger, RE shall not be liable for any damage to smart phones. Royal Enfield All New Classic 350...
Page 48
USB charger will function only when engine is in smart phone battery capacity, SoC and smart running condition. phone charging circuits. Use standard approved and high quality USB cables for proper functioning. Royal Enfield All New Classic 350...
Ensure the motorcycle is made upright and is on its center stand. Ensure gears are in correct neutral and the neutral lamp is glowing in the instrument console. Royal Enfield All New Classic 350...
Cable for fraying or crimping and free operation. Failure to do so may affect safe operation, damage your Engine oil level. motorcycle and could result in an accident causing Wheels for proper tightness. serious injury. Royal Enfield All New Classic 350...
RUNNING IN PERIOD Avoid full throttle operation and do not ride at The Royal Enfield motorcycle as you would be constant throttle continuously. Vary the speed by experiencing is capable of consistent high speeds. 10% while riding. However as with any new motorcycle, a “Running-In”...
Page 52
During the running-in period, do not exceed following speed limits. Motorcycle speed Gear First 500 km 501 - 2000 km 20 kmph 25 kmph 30 kmph 35 kmph 45 kmph 50 kmph 60 kmph 65 kmph 70 kmph 80 kmph Royal Enfield All New Classic 350...
Turn ignition key to “ON” posi- tion and engine kill switch on CAUTION right hand side handle bar to Once the kill switch ON, then only N (neutral) tell tale will “RUN” position glow in instrument cluster Royal Enfield All New Classic 350...
Page 54
Push and hold electric Royal Enfield authorised service centre for start switch until engine rectification. starts for a maximum of Check the fuel level indicator in the cluster for 5 sec.
Page 55
10V. Please get the motor- In case vehicle not starting on multiple continuous cycle checked through an Royal Enfield Authorised attempts, please turn “OFF” and turn “ON” ignition Service Centre to identify and correct the reason switch and then start again.
Page 56
CAUTION Do not attempt to shift gears without moving the motorcycle back and forth as it will damage the gears mechanism. Royal Enfield All New Classic 350...
Page 57
Do not release the button before engine starts. Do not press the starter button more than 5 sec After three successive cranking, wait for 15 to 20 sec the battery to recover. Royal Enfield All New Classic 350...
(Engine rpm around idling to 2000 rpm) at 1st gear condition. In other gears and higher rpm avoid parts. Royal Enfield All New Classic 350...
Page 59
1st gear. appropriate lower gear to prevent the engine from stalling or straining to pull. GEAR SHIFT PATTERN 1 -- N -- 2 -- 3 -- 4 -- 5 Royal Enfield All New Classic 350...
Page 60
Recommended downshift speeds ing to an accident resulting in injury and or loss of Gear Change Kmph (mph) life to rider/other road users/passed by besides 31.1 damage to the motorcycle. 21.7 – 2 15.5 Royal Enfield All New Classic 350...
Page 61
When the engine speed decreases or while climbing tion and switch “OFF” engine kill switch. a gradient or running at a reduced speed, shift to the appropriate lower gear to prevent the engine from stalling or straining to pull. Royal Enfield All New Classic 350...
Parking in a soft ground may cause stand to sink and the stand and pull motorcycle backwards, gently. motorcycle to fall, causing injury to you or to others and damage to the motorcycle parts. Royal Enfield All New Classic 350...
Ring Spanner 24x14-24 (Eye Wrench) x 14 (Open End) Combination Open End Spanner 17 x 13 D/E Spanner 10 x 12 Screw Driver 06 x 120/135 C-Spanner Extension Tube 28x7 & 24 x 14 Royal Enfield All New Classic 350...
Sterilized gauze swab 5 cm x 5 cm Sterilized elastic plaster 7 cm x 6 cm Elastic gauze bandage 8 cm x 1 m First aid kit pouch NOTE Check the expiry date of the first aid kit items before usage. Royal Enfield All New Classic 350...
CONTROL CABLES oil on the pivots. Lubricate after water washing motorcycle or if used during rainy conditions. CENTER/SIDE STAND PIVOTS Apply a few drops of oil on the pivots after cleaning the area of dirt. Royal Enfield All New Classic 350...
Page 66
(approx 60 sec) Do not inspect the oil level window immediately Engine oil level should be max level. working up allow it to settle properly. Do not overfill the engine oil above “Max”. Royal Enfield All New Classic 350...
Page 67
24 mm ring spanner accumulation. and loosen the LH & RH Chain Adjuster by using Maintain drive chain slackness within the specified 6 mm Allen key. limits every 5000 km or early as required. Royal Enfield All New Classic 350...
Page 68
Check and set the electrode gap between 0.70 to 0.80 mm. Refit the spark plug on the cylinder head and refit the spark plug cap on the spark plug. Royal Enfield All New Classic 350...
Page 69
Place your motorcycle in an upright position on a firm, level surface. Front : Check that the brake fluid reservoir is horizontal and that the fluid level is above middle of the oil window. Oil window middle to be considered as “Min” mark. Royal Enfield All New Classic 350...
Page 71
Check proper seating of the tyre beading on the rim Royal Enfield, failure to adhere the same may result in tyre damage and may cause injury to the rider.
Page 72
Glazed area or noise during Wear Indicator brake application - Repair Royal Enfield has provided your new motorcycle with the optimum brake Sand the glazed areas with coarse sandpaper.
Page 73
For checking the battery voltage check with multi- The poor contact or loose fitments of battery terminals meter in voltage mode or contact Royal Enfield may cause electrical/electronic parts failure. authorised service centre or battery service center. Royal Enfield All New Classic 350...
Page 74
Disconnection in the wrong sequence increases the risk of short-circuits. Always proceed in the correct sequence. Royal Enfield All New Classic 350...
Page 75
Aiming adjusting screw direction only. This may be required to increase the visibility and to help prevent the other riders/vehicles passing nearby. Royal Enfield All New Classic 350...
Page 76
F6 F5 F4 F3 F2 F1 25 A Charging system 25 A Main fuse 15 A Ignition system 10 A Signaling fuse 10 A Horn fuse 15 A Lighting system 25 A 15 A Spare fuse 10 A Royal Enfield All New Classic 350...
Page 77
Any attempt to jumper a defective fuse gives rise to the risk of a short-circuit and fire. Always replace a defective fuse with a new fuse of the same rating. NOTE Make sure the ignition switch is in “OFF” position when replacing the bulbs, fuses and electrical parts. Royal Enfield All New Classic 350...
Make the same adjustments on both sides, uneven are clear of all dirt adjustment may lead to discomfort to the rider. and debris before adjusting, if they have dirt or debris please clean it suitably before adjusting Royal Enfield All New Classic 350...
Page 79
Laden / Two up / Rider + Pillions / payload (Inc of rider weight, Rider + Pillion + Accessories pillion weight and accessories) *Ensure the preload is set equally on the LH and RH rear suspension. Royal Enfield All New Classic 350...
Working of all lights and horn. COMMENCEMENT OF A LONG JOURNEY Proper drive chain tension. Service the motorcycle at Royal Enfield authorised Clutch cable free play. service centre. Ensure sufficient quantity of fuel is always available ...
& exhaust outlets. cold condition. Do not apply any corrosive solvent on painted sur- Do not remove side panel while washing to avoid faces or rubber parts. water entry. Royal Enfield All New Classic 350...
Page 82
(not in jet mode). not use warm water for washing as it may damage the motorcycle due to chemical reaction with the salt. After washing process once the motorcycle Royal Enfield All New Classic 350...
Page 83
Polish the painted and plated surfaces using recommended automobile polishing wax. Start the engine and allow to run at an idling speed for a few minutes to warm up engine. Royal Enfield All New Classic 350...
For re-use after storage, it is preferable to get Drain the fuel completely from the fuel tank and the motorcycle prepared through a Royal Enfield induction system. Authorised Service Centre to ensure the motor- Remove spark plug, Pour in about 5 ml of clean ...
BE AN ENVIRONMENTALLY CONSCIOUS RIDER You’ve ridden through some beautiful places on your Royal Enfield. Won’t you like to keep them that way? Here are some tips to help you keep those places unspoilt so that others can enjoy them too:...
The frequency of the maintenance must be shortened depending upon the severity of the driving condition or if the motorcycle is used in a very dusty environment. Contact the nearest Royal Enfield authorised dealer/service centre for expert advice and to carry out the required maintenance.
Page 87
& drain the overfilled by removing plug. Spark plug C&A C&A C&A HT lead for crack Air filter element Clean/Replace more frequently if operated in dusty condition Vent pipe under air filter box Starter motor & starter relay connections Royal Enfield All New Classic 350...
Page 88
Fuel filter in fuel pump Front fork oil Inspect/adjust, if required lubricate for every 5000 km Steering ball races play or earlier as required. Replace if necessary. Spokes tightness/wheel rim run out front & rear Royal Enfield All New Classic 350...
Page 89
Front wheel cush drive rubbers I&R I&R Front brake hose & banjo bolt Brake fluid level, front disc Adjust every 1000 km or earlier as required & Clutch lever/cable free play replace if required. Royal Enfield All New Classic 350...
Page 90
Pivot-side stand, center stand, pillion foot rest, gear shifter, brake pedal, levers Throttle cable Adjust every 5000 km or earlier if required Brake pads - front Side stand switch operation All mounting fasteners in vehicle for tightness Royal Enfield All New Classic 350...
Page 91
10000 km/12 months or earlier as required. Rear brake pedal free play Adjust every 1000 km or earlier if required Brakes shoe - Rear Rear brake cam Rear brake cable Rear wheel - Hub Royal Enfield All New Classic 350...
Page 92
Contact a nearest Royal Enfield authorised dealer/service centre for expert advice and to carry out the periodical maintenance.
In order to avail warranty benefits by second or subsequent owner, the second/subsequent owner should inform the nearest Royal Enfield Service Centre about the purchase of the bike and shall fill in the requisite details in the form as requested by Royal Enfield.
Page 94
(c) Failures occurred due to use of non recommended grade lubricants, fuel or improper level. (d) Damages due to use of non-genuine parts, lack of proper maintenance, incorrect riding habits. Royal Enfield All New Classic 350...
Page 95
(j) Motorcycle used for competitions/racing/stage rallying etc. (k) Electrical component like bulbs, fuses etc. and electronic components failure including ECU due to repairs by arc welding. Motorcycle found with tampering/drilling/welding mark on any part of the frame. Royal Enfield All New Classic 350...
Page 96
Ride sure with Royal Enfield’s annual maintenance contract, extended warranty and roadside assisance. To know more, visit our website or your nearest Royal Enfield store. Call us at 1800210007 to get in touch with us. Royal Enfield All New Classic 350...
The method/s of examination to determine the warranty conditions of the emission warranty related components will be at the sole discretion of Royal Enfield and/or our authorised service centre and results of such examination will be final and binding. If on examination the warranty conditions of the part/s is/are not established, Royal Enfield...
Page 98
In case any of the components covered under emission warranty or the associated parts are not independently replaceable. Royal Enfield will have the sole discretion to replace either the entire assembly or parts of the assembly through suitable repairs.
Page 99
Royal Enfield and/or their authorised service centre. Royal Enfield will not be responsible for any penalties that may be charged by statutory authorities on account of failure to comply with the in-use emission standards.
Page 100
Under all circumstances uses lubricants and fuel as recommended by Royal Enfield. Regularly obtains and carries out maintenance in accordance with Royal Enfield guidelines and enters the details in the log book. Immediately approaches the nearest RE authorised dealer/service centre upon discovery of failure to ...
Page 101
The motorcycle is not serviced by RE authorised dealer/service centre as per the service schedule described in the maintenance chart. The motorcycle has been subjected to abnormal use, abuse, neglect and improper maintenance or has met with an accident. Royal Enfield All New Classic 350...
Page 102
The motorcycle has been used for competitions, races and rallies or for the purpose of establishing records. On examination by Royal Enfield or its authorised dealer/service centre, if the motorcycle shows that any of the conditions stipulated in the Owner’s manual with regard to use and maintenance have been violated.
Page 103
Always get your motorcycle checked to meet the emission regulations through an authorised emission checking centre. Always carry a valid “Pollution Under Control” certificate with you, as and if applicable by law. Royal Enfield All New Classic 350...
Page 104
Use only Unleaded petrol (91 RON or higher) from reputed fuel pumps. Ensure the fuel used is not adulterated. Use correct spark plug as recommended in the owner’s manual. Use lubricants as per recommendations given on grade/brand in the Owner’s manual. Royal Enfield All New Classic 350...
The following warranty applies to the evaporative emission control system. Royal Enfield Motors warrants the first owner and each subsequent owner, that this motorcycle is designed and built so as to conform, at the time of sale, with applicable regulations specified by the evaporative emission control system related parts fitted to this motorcycle are free from defects in materials and workmanship which may cause this motorcycle not to meet applicable regulations period of 24 months from the date of first use of the motorcycle.
Page 106
It is recommended that the routine maintenance of the motorcycle be carried out at specified intervals and any maintenance to the evaporative emission control systems should be performed only by an authorised Royal Enfield service centre and using only genuine Royal Enfield spare parts.
*Labour is free for this services alone. NOTE Cost of parts, lubricants, filters and other consumables are chargeable to the customer on their respective service activities. Refer the Periodic maintenance chart for the respective service activities. Royal Enfield All New Classic 350...
Need help?
Do you have a question about the Classic 350 2008 and is the answer not in the manual?
Questions and answers