Recommended Spare Parts; Trouble Shooting - Numatic Edco HBG 3045 Owner's Instructions Manual

Part No.
606028 550 mm Polyscrub Brush
606550 550 mm Nyloscrub Brush
606551 550 mm Long Life Brush
900526 500 mm NuLoc2 Drive Board
606203 450mm Polyscrub Brush
606204 450mm Nyloscrub Brush
606306 450mm Longlife Brush
900525 400mm NuLoc2 Drive Board
Part No.
903281 Red Squeegee Knob
215006 Squeegee Castor Wheel
606319 Squeegee Castor Assembly Set
900518 Squeegee 650 Blade Set
903486 Complete 650 Squeegee Assembly
900519 Squeegee 750 Blade Set
904699 Complete 750 Squeegee Assembly
206953 Detent Pin
Part No.
PROBLEM
Machine will not operate
Vacuum will not operate
Poor water pick-up
No brush / scrub function
Little or no water flow
Machine just 'stops' while
operating
Failure to rectify the problem or in the event of a breakdown contact your Numatic dealer or
BRUSHES
SQUEEGEE
FILTERS
CAUSE
Missing or blown fuses
Low battery charge
Machine is connected and charging
Waste water tank full
Check fuse
Waste water tank full
Clogged / blocked vacuum hose
Loose hose connections
Debris basket filter clogged / blocked
Separator filter clogged / blocked
Poor separator seal
Damaged separator seal
Damaged / split vacuum hose
Damaged floor tool blades
Low battery charge
No brushes fitted
Check fuse
Clean water tank empty
Clean water tank filter blocked / clogged
Water flow not on
Brush deck raised
Too much load on the brush system
Numatic Technical helpline +44 (0)1460 269268
Part No.
903341 Hose Closure (Bottom Tank)
903341 Hose Closure ( Filling Hose)
900903 Hose Closure (Top Tank)
Part No. GENERAL PARTS
221091 20 Amp Maxi Fuse (VAC)
230104 30 Amp Maxi Fuse (Brush)
221047 40 Amp Maxi Fuse (Battery)
221107 50 Amp Maxi Fuse (Battery Traction)
903066 2.5 Amp Handle Fuse
903736 24v Contactor
903542 Grit Filter Basket (Red)
208888 (CWF) Clean Water Filter (Complete)
208827 CWF Strainer Base Moulding
208830 CWF Strainer Gasket
208889 CWF Extended Strainer 50 Mesh Screen
208890 CWF 68mm Extended Strainer Clear Bowl
208638 160mm Rear Wheel
220386 Charging Lead (V17 - UK)

Trouble Shooting

SOLUTION
Fit or replace fuse (page 5)
Charge batteries (page 13 / 14)
Take off charge (page 13)
Empty waste water tank (page 11)
Check fuse (page Page 5)
Empty waste water tank (page 11)
Remove and clean (page 11)
Push tight connections (page 7)
Remove and clean (page 11)
Remove and clean (Page 11)
Clean and refit (page 11)
Renew (contact service dept)
Renew (contact service dept)
Renew (contact service dept)
Re-charge batteries (page 13 / 14)
Check and fit (page 6)
Check fuse (page Page 5)
Fill clean water tank (page 7)
Remove and clean (11)
Switch on water flow (Page 9)
Lower brush deck (page 9)
Decrease the brush load to best suit the
floor type.
Spare Parts
HOSES
21
T 01460 68600