Operating Instructions; Turn Off Gas To Appliance - UTICA BOILERS SVB Series Installation, Operation & Maintenance Manual

LIGHTING PROCEDURE FOR BOILER WITH
INTERMITTENT PILOT SYSTEM
For Your Safety, Read Before Operating!!
!
WARNING
If you do not follow these instructions
exactly, a fire or explosion may result
causing property damage, personal injury
or loss of life�
• This appliance is equipped with an ignition
device which automatically lights burner. Do
NOT try to light this burner by hand�
• Before operating smell all around appliance area
for gas. Be sure to smell next to floor because
some gas is heavier than air and will settle to
the floor.
• Use only your hand to turn the gas shutoff
valve. Never use tools. If valve will not turn
by hand, do not try to repair it, call a qualified
service technician. Force or attempted repair
may result in fire or explosion.
• Do not use this appliance if any part has
been under water. Immediately call a qualified
service technician to inspect appliance and to
replace any part of control system and any gas
control which has been under water.
! !
CAUTION
WHAT TO DO IF YOU SMELL GAS
• Do not try to light any appliance.
• Do not touch any electrical switches; do not use
any phone in your building.
• Immediately call your gas supplier from a
neighbor's phone. Follow the gas supplier's
instructions.
• If you cannot reach your gas supplier, call the fire
department.
14 - STARTING YOUR BOILER
14�2 Operating Instructions
1.
2.
3.
4.
5.
Figure 13
6.
7.
8.
9.
10.
11.
12.
14�3 Turn Off Gas To Appliance
1.
2.
3.
4.
5.
28
STOP! Read Safety Information on previous page.
Set the thermostat to lowest setting.
Turn off all electric power to the appliance.
This appliance is equipped with an ignition device which
automatically lights the burner. Do not attempt to light
pilot by hand.
Remove front panel, if necessary.
- Gas Control Knob
INLET
GAS CONTROL KNOB
SHOWN IN "ON" POSITION
Turn gas control knob clockwise
Wait five (5) minutes to clear out any gas. Then smell
for gas, including near floor. If you smell gas, STOP!
Follow WHAT TO DO IF YOU SMELL GAS found on
operating instruction label. If you don't smell gas, go to
next step.
Turn gas control knob counterclockwise
Replace front panel, if removed.
Turn on all electric power to the appliance.
Set thermostat to desired setting.
If appliance will not operate after several tries, turn gas
control knob to "OFF" and call your service technician
or gas supplier.
Turn off all electric power to the appliance if service is
to be performed.
Set the thermostat to lowest setting.
Remove front panel, if necessary.
Turn gas control knob clockwise
force.
Replace front jacket panel, if removed.
PN 240013095, Rev. A [08/15/2020]
ON
OFF
to "OFF".
to "ON."
to "OFF". Do not