Table of Contents
Advertisement
Quick Links
Installation/Owner's Manual
NOTICE: DO NOT discard this manual!
Lumonessen
Series
Models:
Outdoor Burner/Log Set
Appliance Setup, Care and Operation
GAS-FIRED
MH61458
Outdoor Lifestyles • Lumonessen Owner's /Installation Manual • 4629-900 Rev. A • 02/23
DANGER
FIRE OR EXPLOSION HAZARD
If you smell gas:
•
Shut off gas to the appliance.
•
Extinguish any open flame.
•
If odor continues, leave the area immediately.
•
After leaving the area, call your gas supplier or fire
department.
•
Failure to follow these instructions could result in fire
or explosion, which could cause property damage,
personal injury, or death.
WARNING
Do not store or use gasoline or other flammable va-
pors and liquids in the vicinity of this or any other
appliance
An LP-cylinder not connected for use shall not be
stored in the vicinity of this or any other appliance.
WARNING: For outdoor use only.
Installation and service must be performed by a
qualified installer, service agency, or the gas supplier.
WARNING:
If the information in this manual
is not followed exactly, a fire or explosion may
result causing property damage, personal injury, or
loss of life.
1
Advertisement
Table of Contents
Subscribe to Our Youtube Channel
Related Manuals for Hearth and Home Technologies outdoor lifestyles LUM-OD-NM
Summary of Contents for Hearth and Home Technologies outdoor lifestyles LUM-OD-NM
- Page 1 Installation/Owner’s Manual Appliance Setup, Care and Operation NOTICE: DO NOT discard this manual! DANGER FIRE OR EXPLOSION HAZARD If you smell gas: • Shut off gas to the appliance. • Extinguish any open flame. • If odor continues, leave the area immediately. •...
-
Page 2: Table Of Contents
Safety Alert Key: • DANGER! Indicates a hazardous situation which, if not avoided will result in death or serious injury. • WARNING! Indicates a hazardous situation which, if not avoided could result in death or serious injury. • CAUTION! Indicates a hazardous situation which, if not avoided, could result in minor or moderate injury. •... -
Page 3: Installation Standard Work Checklist
Installation Standard Work Checklist ATTENTION INSTALLER: Follow this Standard Work Checklist This standard work checklist is to be used by the installer in conjunction with, not instead of, the instructions contained in this installation manual. Customer: Date Installed: Lot/Address: Location of Fireplace: Installer: Dealer/Distributor Phone # Model... -
Page 4: Product Specific & Important Safety Information
Product Specific and Important Safety Information A. Appliance Certification NOTE: For LP models an external regulator is required to reduce supply pressure to a maximum of 13" w.c. LUM-OD-NM, LUM-OD-PM MODEL: LABORATORY: Underwriters Laboratory (UL) C. Gas Pressures TYPE: Outdoor Decorative Gas Appliance NATURAL PROPANE (LP) STANDARD: ANSI Z21.97-2017, CSA 2.41-2017... -
Page 5: Getting Started
Getting Started A. Design and Installation Considerations Before installing, determine the following: • Where the appliance is to be installed. Installation MUST comply with local, regional, state and – Clearances to side walls. national codes and regulations. Consult insurance carrier, –... -
Page 6: Appliance Location Requirements/Outdoor Living Space
C. Appliance Location Requirements in Outdoor Living Space How to Calculate the Minimum Opening Needed In an Outdoor Living Space 30% (or .30) of the outdoor living space periphery needs to be open. 1. Add lengths of the outside living space. 16’... -
Page 7: Inspect Appliance And Components
D. Inspect Appliance and Components E. Check Parts Verify contents to ensure you have received all parts. You • Carefully remove the appliance and components from should have the following: the packaging. LUM-OD-NM and LUM-OD-PM Models • Logs are packaged and sold separately. •... - Page 8 The log set should be placed against or as near as possible to the rear wall of the fireplace/firebox. 3” (76mm) Minimum Hearth Dimensions Inches Model Depth of fire- (660mm) (330mm) (457mm) (432mm) place/firebox (Refer to table) LUM-OD-NM, 22.25 (737mm) (330mm) (571mm) (432mm)
-
Page 9: Clearances & Height Requirements
Clearances and Height Requirements Heat resistant material (minimum requirements) with A. Clearances and Height Requirements no wooden mantel or other combustible projection: To install the gas logs into a fireplace with no wooden WARNING mantel, shelf or other combustible projection above the The dimensions shown in Figures 3.1 through fireplace opening, measure the heat resistant material 3.8 and defined in the fireplace manufacturer's... - Page 10 Heat resistant material (minimum requirements) with 12" (305mm) wooden mantel or other combustible projection: 10" (254mm) 8" (203mm) To install the heater with a wooden mantel, shelf or other 6" (152mm) combustible projection above, first measure the heat resis- 2¹⁄₂" tant material shown in Figure 3.3, then refer to Table B.
- Page 11 The gas log heater must be installed at least 1 ⁄ " above any Vinyl Flooring combustible flooring material, such as carpeting, which is Vinyl Flooring is sensitive to heat. A 14 inch minimum closer than 14" to the base of the fireplace. The minimum depth hearth extension is recommended when using vinyl distance must be maintained from the top surface of car- flooring up to the wall.
-
Page 12: Before Installing The Appliance
B. Before Installing the Appliance: WARNING • Turn off gas supply to fireplace or firebox. Before installing in a solid fuel burning fireplace, • The chimney flue and firebox must be cleaned of Have the fireplace floor and chimney professionally soot, creosote, ashes and loose paint by a qualified cleaned to remove ashes, soot, creosote or other chimney cleaner. -
Page 13: Assembly Procedure
D. Assembly Procedure WARNING 1. Center the burner assembly inside the fireplace or You must secure the gas log heater to the fireplace firebox. Make certain that the front of the burner floor. If not, the entire unit may move when you assembly sits inside the front edge of the fireplace or adjust the controls. -
Page 14: Gas Information
Gas Information WARNING WARNING Connecting directly to an unregulated propane/ Use new black iron or steel pipe. Internally tinned LPG tank can cause an explosion. copper or copper tubing can be used per National Fuel Code, section 2.6.3, providing gas meets hydrogen sulfide limits, and where permitted by local The heater gas inlet connection is a 3/8"... -
Page 15: Gas Service Access
Note: Have the gas supply line installed in accordance with local codes, if any. If not, follow ANSI Z223.1. Installation should be done by a qualified installer approved and/or licensed as required by the locality. (In the Commonwealth of Massachusetts installation must be performed by a licensed plumber or gas fitter). -
Page 16: Electrical Information
Electrical Information A. General Information Label all wires before disconnecting when WARNING! Risk of Shock or Explosion! DO NOT wire servicing controls. Wiring errors can cause 110-120 VAC to the valve or to the appliance wall switch. improper and dangerous operation. Incorrect wiring will damage controls. -
Page 17: Gas Log Set
Gas Log Sets A. Grate and Log Installation BEFORE YOU BEGIN This unit requires the use of concrete logs. Do not handle WARNING these logs with your bare hands. Always wear gloves to prevent skin irritation from ceramic fibers. After The positioning of the logs is critical to the safe and handling the logs, wash your hands gently with soap and clean operation of this heater. -
Page 18: Log Placement (Mezmer)
Top Left Log #5 Top Center Log #6 Front Log #3 Figure 6.2 - Place Front Log Figure 6.5a - Mezmer Bark Log Set Place Top Left and Middle Logs Middle Log #2 Top Left Log #5 Top Center Log #6 Top Right Log #4 Figure 6.3 - Place Middle Log... -
Page 19: Log Placement Mountain Oak-18
C. LOG PLACEMENT MOUNTAIN OAK-18 LOGS 1. Place Rear Log (#1) on rear support. Figure 6.6 2. Place Middle Log (#2) on middle support. Figure 6.7 3. Place Front Log (#3) in between burner and grate. Figure 6.8 4. Rest Top Log (#4) in front and middle log cutouts. Figure NOTE: Logs #1, #2 and #3 have ridges on the bottom which secure the logs to burner frame. -
Page 20: Log Placement Mountain Oak-24/30
D. LOG PLACEMENT MOUNTAIN OAK-24/30 Front Log #3 LOG SETS 1. Place Rear Log (#1) on rear support. Figure 6.10 2. Place Middle Log (#2) on middle support. Figure 6.11 3. Place Front Log (#3) in between burner and grate. Figure 6.12 4. -
Page 21: Flame Appearance
F. Operating Instructions E. Flame Appearance Avoid any drafts that alter burner flame patterns. Do Flames from the pilot and burner should be visually checked as soon as the heater is installed. In addition, not allow fans to blow directly into the fireplace. Do not place a blower inside the burn area of the firebox. -
Page 22: Owner's Manual
Owner’s Manual Care & Operation Owner’s Manual Care and Operation NOTICE: DO NOT discard this manual! DANGER FIRE OR EXPLOSION HAZARD If you smell gas: • Shut off gas to the appliance. • Extinguish any open flame. • If odor continues, leave the area immediately. •... -
Page 23: Congratulations
Read this manual before operating this appliance. Please retain this Owner’s Manual for future reference. Read the Installation Manual before making any installation or finishing changes. A. Congratulations This owner’s manual should be retained for future reference. We suggest that you keep it with your other Congratulations and thank you for selecting a Outdoor important documents and product manuals. -
Page 24: Limited Lifetime Warranty
B. Limited Lifetime Warranty Outdoor Lifestyles by Hearth & Home Technologies™ Limited Lifetime Warranty Hearth & Home Technologies (“HHT”) extends the following warranty for all Outdoor Lifestyles by HHT™ brand products (“Products”) that are purchased from an HHT authorized dealer. WARRANTY COVERAGE: HHT warrants to the original owner of the Product at the site of installation, and to any transferee taking ownership of the Product at the site of installation within one year following the date of original purchase,... - Page 25 B. Limited Lifetime Warranty (continued) Damages resulting from: (1) failure to install, operate, or maintain the Product in accordance with • the installation instructions, operating instructions, and listing agent identification label furnished with the Product; (2) failure to install the Product in accordance with local building codes; (3) shipping or improper handling;...
-
Page 26: Application Certification
Product Specific Information A. Appliance Certification B. BTU Specifications and Weight Maximum Minimum Weight Models LUM-OD-NM, LUM-OD-PM MODEL: Input Input Orifice Pounds BTU/h BTU/h LABORATORY: Underwriters Laboratory (UL) .136 in LUM-OD-NM (0-2000 FT) 38,000 19,000 (3.45mm) TYPE: Outdoor Decorative Gas Appliance STANDARD: ANSI Z21.97-2017, CSA 2.41-2017 .0.78 in LUM-OD-PM... -
Page 27: Important Safety & Operating Information
Important Safety and Operating Information A. Appliance Safety Clear Space WARNING! DO NOT place combustible objects in front WARNING! DO NOT operate gas log set before read- of the fireplace. High temperatures may start a fire. See ing and understanding operating instructions. Failure Figure 9.1. - Page 28 Important Safety and Operating Information (continued) OWNER Please retain these instructions for future reference. WARNING • Any change to this heater or its controls can be dangerous. • Improper installation or use of the heater can cause serious injury or death from fire, burns, explosion or carbon monoxide poisoning.
-
Page 29: General Operating Parts
B. General Operating Parts 20. The appliance must be isolated from gas supply piping system by closing its equipment shutoff valve during Figure 9.2 references the general operating parts of the any pressure testing of the gas supply piping system at appliance. -
Page 30: Manual Valve
Lighting Instructions A. Manual Valve FOR YOUR SAFETY READ BEFORE LIGHTING WARNING If you do not follow these instruction exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance is equipped with a piezo ignition device which lights the pilot. If piezo is not working properly see Match Lighting Instructions. - Page 31 Lighting Instructions (continued) MANUAL CONTROL LIGHTING INSTRUCTIONS 1. STOP! Read the safety information label. 2. Make sure the manual shutoff valve is fully open. 3. This gas log set is equipped with an ignition device (piezo) which automatically lights the pilot. If piezo ignitor does not light the pilot, refer to instructions for Match Lighting Instructions.
-
Page 32: Lighting Instructions
B. Lighting Instructions WARNING FOR YOUR SAFETY READ BEFORE LIGHTING WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. This appliance has a standing pilot. When lighting the pilot, follow these instructions exactly. BEFORE LIGHTING smell all around the appliance area for gas. - Page 33 Lighting Instructions (continued) Removal of this plate will void the compliance with ANSI Z21.97 OPERATING INSTRUCTIONS - VARIABLE MANUAL CONTROL 1. STOP! Read the safety 7. With control knob pushed in, push information label. and release the piezo ignitor button 2.
-
Page 34: Initial Use
C. Initial Use Initial Break-in Procedure • The burner should run three to four hours continuously on high. • Turn the burner off and allow it to completely cool. This cures the materials used to manufacture the burner. NOTICE! Allow air circulation during heater break-in. •... -
Page 35: Maintenance & Service
11 11 Maintenance and Service C. Burner Ignition and Operation Any safety screen removed for servicing must be replaced prior to operating the unvented room heater. Frequency: Annually When properly maintained, your fireplace will give you By: Qualified Service Technician many years of trouble-free service. -
Page 36: Cleaning & Servicing
D. Cleaning and Servicing Annual inspection and cleaning by your dealer or qualified service technician is recommended to pre- vent malfunction and/or sooting. WARNING Turn off heater and allow to cool before cleaning. Remove logs, handling carefully by holding gently at each end. -
Page 37: Troubleshooting
Troubleshooting WARNING Turn appliance OFF and allow to cool before servicing. Only a qualified service person should service and repair the heater. With proper installation, operation, and maintenance your gas appliance will provide years of trouble-free service. If you do experience a problem, this troubleshooting guide will assist a qualified service technician in the diagnosis of a problem and the corrective action to be taken. -
Page 38: Service Parts & Accessories
IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor. - Page 39 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 40 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 41 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 42 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 43 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 44 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 45 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 46 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
- Page 47 IMPORTANT: THIS IS DATED INFORMATION . Parts must be ordered from a dealer or Stocked Hearth and Home Technologies does not sell directly to consumers distributor. . Provide model number and serial number when requesting service parts from your dealer or distributor.
-
Page 48: Massachusetts Residents Only
B. MASSACHUSETTS RESIDENTS ONLY Please read and follow these special requirements NOTE REGARDING VENTED PRODUCTS 2. Approved Carbon Monoxide Detectors. Each carbon This product must be installed by a licensed plumber or monoxide detector as required in accordance with the above gas fitter when installed within the Commonwealth of provisions shall comply with NFPA 720 and be ANSI/UL 2034 Massachusetts. -
Page 49: Contact Information
C. Contact Information Hearth & Home Technologies 7571 215th Street West Lakeville, MN 55044 www.hearthnhome.com Please contact your dealer with any questions or concerns. For the location of your nearest dealer, please visit www.hearthnhome.com - NOTES - ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________ ________________________________________________________________________________...
Need help?
Do you have a question about the outdoor lifestyles LUM-OD-NM and is the answer not in the manual?
Questions and answers