General Information - Volvo Penta D4 Service And Maintenance Manual

General Information

General Information
General information
This service and maintenance manual contains
descriptions and instructions for the service of the
above-mentioned Volvo Penta products in their
standard models. The design and servicing items may
vary between different products. Applicable service
intervals and service procedures are described in the
maintenance schedule for the product.
The product designation, serial number and
specification are indicated on the engine decals or
type plate. This information must always be provided
in all correspondence concerning the product.
The manual has been produced primarily for use in
Volvo Penta workshops. It is assumed that persons
using the manual have fundamental knowledge of the
product and are capable of carrying out mechanical
and electrical work to industry standards.
Volvo Penta continually develops its products. We
therefore reserve the right to make changes.
All of the information in the manual is based on
product data available when the manual was
published.
NOTICE! The owner is responsible for ensuring that
scheduled maintenance is carried out. Warranty
claims to Volvo Penta may be declined if neglected
maintenance results in faults in the specified product.
Refer to the warranty terms supplied with the engine.
14
Specific terms for the U.S. market
This engine is certified as being in compliance with
federal and Californian exhaust restriction
regulations. Parts related to exhaust restrictions are
covered by the warranty commitment for exhaust
restricting systems. Terms and the parts covered are
specified under "What is covered by the warranty
undertaking for emissions" in "Emission Control
System Warranty Statement". Repairs and service
covered by the warranty are carried out by an
authorized Volvo Penta distributor or dealer at no
charge for diagnostics, labor or parts using genuine
Volvo Penta parts in all areas of the exhaust restriction
system covered by the warranty and found to be
defective.
The use of the service and repair workshop other than
a Volvo Penta authorized distributor or dealer or the
use of exhaust-related components from other
manufacturers than Volvo Penta do not affect the
scope of the warranty undertaking for emission-
restricting systems. If emission-related components/
items are included in scheduled service, such parts
are marked with a diamond (♦) in the maintenance
schedule and service must be carried out at the
specified intervals in order to meet the requirements
of the warranty undertaking for emission-restricting
systems. The full warranty terms can be found in
"Emission Control System Warranty Statement".
47707967 09-2022 © AB VOLVO PENTA