Wendy's EVOLUTION ELITE EEG-15 Series Service Manual page 12

Problem
Filter motor runs but
pumps oil slowly
Filter motor will not run
"IS POT FILLED" filter error
prompt
"CHECK PAN" prompt
"FILTER PAN MISSING"
prompt appears
"CHANGE FILTER PAD"
prompt appears
May 2012
Cause
FILTER MOTOR SECTION
• Filter line connections
loose
• Filter paper or pad clogged
• Power cord for vat #1
is not plugged-in
• the thermal reset button on
the rear of the pump motor
is tripped
DISPLAYED PROMPT SECTION
• All oil did not completely
return after a filter cycle
• Filter pad clogged
• Drain pan not completely in
place
• Faulty drain pan switch
• Drain pan missing
• Drain pan not completely in
place
• Faulty drain pan switch
• Filter pad has not been
changed within a 24hr time
period; Main power switch
was turned off during filter
pad change
• Drain pan switch stuck
1-6
Model EEG-153, 154
Correction
• Tighten all filter line connections
• Change filter paper or pad
• Plug power cord into receptacle
• Remove the right side panel and
allow time for the motor to cool
and then, using a screwdriver,
press hard against the button
until it clicks
• Have manager follow prompts
• Is JIB full? If not, fill JIB
• Replace filter pad/clean pan.
• Push drain pan in place
• Check drain switch
• Find pan and replace
• Push filter pan in place
• Check drain switch
• Replace old filter pad with NEW
filter pad with main power switch
turned on.
*NOTE* 24/7 store replace
filter twice a day.
• Check drain switch