Daikin DPICX A Series Installation Instructions Manual

DPICX-*A, DPICX-*B
COIL INSULATION KIT
INSTALLATION INSTRUCTIONS
A I
TTENTION NSTALLING
As a professional installer, you have an obligation to know the prod-
uct better than the customer. This includes all safety precautions
and related items.
Prior to actual installation, thoroughly familiarize yourself with this
Instruction Manual. Pay special attention to all safety warnings.
Often during installation or repair, it is possible to place yourself in
a position which is more hazardous than when the unit is in op-
eration.
Remember, it is your responsibility to install the product safely
and to know it well enough to be able to instruct a customer in its
safe use.
Safety is a matter of common sense...a matter of thinking before
acting. Most dealers have a list of specific good safety
practices...follow them.
The precautions listed in this Installation Manual are intended as
supplemental to existing practices. However, if there is a direct
conflict between existing practices and the content of this manual,
the precautions listed here take precedence.
S P
AFETY RECAUTIONS
The following symbols and labels are used throughout this manual
to indicate immediate or potential safety hazards. It is the owner's
and installer's responsibility to read and comply with all safety in-
formation and instructions accompanying these symbols. Failure
to heed safety information increases the risk of personal injury,
property damage, and/or product damage.
PROP 65 WARNING
FOR CALIFORNIA CONSUMERS
Cancer and Reproductive Harm
www.P65Warnings.ca.gov
HIGH VOLTAGE !
D ALL
ISCONNECT POWER BEFORE SERVICING
M
ULTIPLE POWER SOURCES MAY BE PRESENT
TO DO SO MAY CAUSE PROPERTY DAMAGE
.
INJURY OR DEATH
D
O NOT USE ANY PARTS THAT ARE NOT DESIGN CERTIFIED BY THE
MANUFACTURER FOR USE WITH THIS UNIT
, ,
DAMAGE PERSONAL INJURY
HAZARDOUS CONDITIONS MAY RESULT FROM THE USE OF SUCH NON
.
APPROVED PARTS
IOD-7090
10/2018
P
ERSONNEL
-
WARNING
.
. F
AILURE
,
PERSONAL
WARNING
. S
ERIOUS PROPERTY
REDUCED UNIT PERFORMANCE AND
Only personnel that have been trained to install, adjust, service
or repair (hereinafter, "service") the equipment specified in
this manual should service the equipment. The manufacturer
will not be responsible for any injury or property damage
arising from improper service or service procedures. If you
service this unit, you assume responsibility for any injury or
property damage which may result. In addition, in jurisdictions
that require one or more licenses to service the equipment
specified in this manual, only licensed personnel should service
the equipment. Improper installation, adjustment, servicing
or repair of the equipment specified in this manual, or
attempting to install, adjust, service or repair the equipment
specified in this manual without proper training may result in
product damage, property damage, personal injury or death.
WHEN INSTALLING OR SERVICING THIS EQUIPMENT
INCLUDING HAND AND EYE PROTECTION
IF INSTALLING IN AN AREA THAT HAS SPECIAL REQUIREMENTS
, )
HATS ETC
D
ESCRIPTION
The DPICX Coil Insulation Kit is applied to the bottom of the drain
pan and top of the coil top plate in order to prevent possible con-
densation from forming. They can be used with cased and uncased
coils, in applications where the unit is installed in a space where
the temperature and humidity may exceed 86ºF and 80% RH.
DPICX-*A
0140M00513-A
(1) Insulation D
DPICX-*B
(1) Insulation A
/
OR
-
INSTALLATION INSTRUCTIONS
CAUTION
,
IS STRONGLY RECOMMENDED
OBSERVE THESE REQUIREMENTS
(1) Insulation B
(5) Top Plate Insulation
(1) Insulation B
(5) Top Plate Insulation
, ,
SAFETY CLOTHING
.
(
HARD
.
(1) Insulation C