Volvo Penta D3-130A-A Operator's Manual page 9

Carbon monoxide poisoning
Only start the engine in a well-ventilated area. If oper-
ating the engine in an enclosed space, ensure that
there is proper ventilation in order to remove exhaust
gases and crankcase ventilation emissions from the
working area.
Chemicals
Most chemicals such as antifreeze, rustproofing
agent, inhibiting oil, degreasing agent etc. are hazard-
ous to health. Read and follow the instructions on the
packaging.
Some chemicals such as inhibiting oil are inflammable
and dangerous if breathed in as well. Ensure good
ventilation and use a protective mask when spraying.
Read and follow the instructions on the packaging.
Store chemicals and other hazardous materials out of
the reach of children. To protect the environment
please dispose of used or leftover chemicals at a
properly designated disposal site for destruction.
Cooling system
There is a risk of flooding when working on the seawa-
ter system. Turn off the engine and close the sea
cock (where installed) before starting work on the sys-
tem.
Avoid opening the coolant filler cap when the engine is
hot. Steam or hot coolant can spray out and cause
burns.
If work must be carried out with the engine at operat-
ing temperature and the coolant filler cap or a cock
open or a coolant hose disconnected, open the cool-
ant filler cap carefully and slowly to release pressure
before removing the cap completely. Note that the
coolant may still be hot and can cause burns.
Lubrication system
Hot oil can cause burns. Avoid skin contact with hot
oil. Ensure that the lubrication system is not under
pressure before commencing work on it. Never start or
operate the engine with the oil filler cap removed, oil
can spray out.
Fuel system
Always use protective gloves when tracing leaks. Liq-
uids ejected under pressure can penetrate body tissue
and cause serious injury. There is a danger of blood
poisoning.
Always cover the alternator if it is located under the
fuel filter. The alternator can be damaged by spilled
fuel.
Electrical system
Cutting off power
Always stop the engine and break the current using
the main switches before working on the electrical
system. Disconnect shore current to the engine block
heater, battery charger, or accessories mounted on
the engine.
Batteries
The batteries contain an extremely corrosive electro-
lyte. Protect your skin and clothes when charging or
handling batteries. Always use protective goggles and
gloves.
If battery electrolyte comes into contact with unpro-
tected skin wash off immediately using plenty of water
and soap. If battery acid comes into contact with the
eyes, flush immediately with plenty of water and ob-
tain medical assistance without delay.
Safety Information
7