Advertisement

Quick Links

FILTRATION
APOLLO DISC-KLEEN
FILTERS
OPERATION, INSTALLATION & MAINTENANCE GUIDE
ANGLE CONFIGURATION
TWIN CONFIGURATION

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the APOLLO DISC-KLEEN and is the answer not in the manual?

Questions and answers

Subscribe to Our Youtube Channel

Summary of Contents for Netafim APOLLO DISC-KLEEN

  • Page 1 FILTRATION APOLLO DISC-KLEEN FILTERS OPERATION, INSTALLATION & MAINTENANCE GUIDE ANGLE CONFIGURATION TWIN CONFIGURATION...
  • Page 2: Table Of Contents

    TABLE OF CONTENTS Specifications .........................3 Filter Dimensions......................4 Water Quality & Maximum Flow Rates ..............5 Filter Operation .......................5 Installation........................8 Filter Start-up ........................10 System Maintenance ....................10 Troubleshooting ......................13 Replacement Parts ......................15 • APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE...
  • Page 3: Specifications

    SPECIFICATIONS Netafim congratulates you on purchasing the Apollo Disc-Kleen filter. All Netafim filters are easy to install, use and service and don’t require special skills to operate. For operation and maintenance of the filter, please follow the instructions in this manual.
  • Page 4: Filter Dimensions

    47 6/16” 12 1/32” 29 29/32” 24 9/32” 63 31/32” 2,010 LBS. All measurements are approximate. For specific dimensions refer to the CAD Design Details located on the Netafim USA website. • APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE...
  • Page 5: Water Quality & Maximum Flow Rates

    Water flows from Water sprayed from outside to inside. the inside to the outside. which are flushed out through the drain. APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE •...
  • Page 6 The filtered water flows through the outlet manifold into the system. Air Release Vent Command Filter 4” Backflush Valve 4” Twin Apollo Filter FILTERS 1, 2 & 3 ARE IN FILTRATION MODE • APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE...
  • Page 7 After all the filters have been backflushed, the system returns to filtration mode until the next backflush cycle. Air Release Vent Command Filter 4” Backflush Valve DRAIN 4” Twin Apollo Filter FILTER 4 IS IN BACKFLUSH MODE APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE •...
  • Page 8: Installation

    Open the 1” brass ball valve found on the side of the filter 9. Netafim cannot accept responsibility for any changes or modifications to the body to release any pressure in the filter.
  • Page 9 Time or ∆ P Time or ∆ P Pressure Vent Comm Vent Vent. Vent. Vent. Command from Solenoid Vent Command to Valve Feed Command Water Com. Drain Drain Drain Command Water Filter Drain APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE •...
  • Page 10: Filter Start-Up

    • In order to prevent the filter from becoming damaged under freezing conditions, drain all the water from the filter and leave the drain valve open. Disconnect the hydraulic tubes from the PD Gauge. • APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE...
  • Page 11 • Place the filter cover on the filter body and secure it with a slight clockwise rotation. Reposition the clamp onto the cover and tighten the bolts with the clamp wrench. APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE •...
  • Page 12 • Flush the filter bank a few times to remove all chemicals. bank. • Flush the filter bank a few times to remove all chemicals. CAUTION: When blowing out with compressed air, make sure all parts are opened. • APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE...
  • Page 13: Troubleshooting

    • Push the reset button on the front panel and initiate a backflush again. • Flush a filter individually by turning the manual override of the solenoid 180 degrees. If that filter flushes, then the filter is working hydraulically and the problem is electric. APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE •...
  • Page 14 If the drain pipe needs to be longer than 50 feet, use a 6” pipe. There should not be a check valve or gate valve on the drain pipe. - Remove the discs from the spines and clean them manually. Refer to the Disc Cleaning Instructions on Pages 11 and 12. • APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE...
  • Page 15: Replacement Parts

    76400-005410 55P1210400-B 1/4” Plug (Bag 10) 8.80 40001-000382 15CONT8C50 8 mm Control Tube (50’ Roll) 9.00 Model Numbers will be different based on filter configurations. NOTE: Substitute *** with desired mesh. APOLLO DISC-KLEEN FILTER OPERATIONS, MAINTENANCE AND TROUBLESHOOTING GUIDE •...
  • Page 16 REPLACEMENT PARTS APOLLO DISC-KLEEN FILTER PARTS Twin Filter Item Number Model Number Description Price Each 70620-003432 25AP22000402 4” Twin Body 709.00 76000-002400 25AP50540112 3/4” Ball Valve 32.00 70620-007065 25AP50032311 O-Ring for 3/4” Ball Valve 6.20 70620-005100 25AP50060004 Gauge Port Seal 8.40...

Table of Contents