Table of Contents
Advertisement
Quick Links
This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a
building, garage, screened-in porch, gazebo or any other enclosed area.
!
WARNING!
CABINET FRAME, CABINET AND COUNTER TOP MUST BE MADE FROM NON-COMBUSTIBLE
MATERIAL WHEN THE APPLIANCE IS NOT INSTALLED WITH THE ZERO CLEARANCE LINER PART NO. BI-3323-ZCL.
!
DANGER
IF YOU SMELL GAS:
• Shut off gas to the appliance.
• Extinguish any open flame.
• Open lid.
• If odor continues, keep away from the
appliance and immediately call your gas
supplier or fire department.
Adults and especially children should be alerted to the hazards of high surface temperatures.
Young children should be supervised near the gas grill.
Notice to Installer: Leave these instructions with the grill owner for future reference.
N415-0541 JUL 17.20
Do not try to light this appliance without
reading the "LIGHTING" instructions section
of this manual.
Do not store or use gasoline or other
flammable liquids or vapors in the vicinity of
this or any other appliance. An L.P. cylinder
not connected for use must not be stored in
the vicinity of this or any other appliance.
If the information in these instructions is
not followed exactly, a fire or explosion may
result, causing property damage, personal
injury or death.
Wolf Steel Ltd.
214 Bayview Drive,
Barrie, Ontario, CANADA L4N 4Y8
grills@napoleon.com
APPLY SERIAL NUMBER LABEL FROM CARTON
Serial No.
XXXXXX000000
MODEL NO.
DO NOT DISCARD
BIPRO500-3
!
WARNING
www.napoleon.com
EN
FR
PG.31
PG.64
Advertisement
Table of Contents
Related Manuals for Napoleon BIPRO500RBSS-3
Summary of Contents for Napoleon BIPRO500RBSS-3
- Page 1 Adults and especially children should be alerted to the hazards of high surface temperatures. Young children should be supervised near the gas grill. Notice to Installer: Leave these instructions with the grill owner for future reference. Wolf Steel Ltd. 214 Bayview Drive, Barrie, Ontario, CANADA L4N 4Y8 grills@napoleon.com N415-0541 JUL 17.20 www.napoleon.com...
- Page 2 This Limited Warranty creates a warranty period as specifi ed in the aforementioned table, for products purchased through an authorized Napoleon dealer, and entitles the original purchaser (or gift recipient in the case where a new product is given as a gift) to the specifi ed coverage in respect of any component replaced within the warranty period, either by Napoleon or an authorized Napoleon dealer, to replace a component of such product that has failed in normal private use as a result of a manufacturing defect.
- Page 3 Napoleon in case we ever need to contact you. When making warranty claims, Napoleon representatives may request from you the bill of sale or copy, together with a serial number and a model number. Napoleon reserves the right to have its representative inspect any product or part prior to honoring any warranty claim.
-
Page 4: Safe Operating Practices
• Do not allow cold water (rain, sprinkler, hose, etc.) to come in contact with ceramic burners. • Do not use a pressure washer to clean any part of the unit. www.napoleon.com N415-0541 JUL 17.20... -
Page 5: General Information
Connect this flexible metal connector to the flare fitting on the end of the manifold. Connect the other end of the connector to the gas piping. Ensure that the connector does N415-0541 JUL 17.20 www.napoleon.com... - Page 6 NON LOCKING DOOR 1” (25.4mm) PARTITION TO ISOLATE MAXIMUM CYLINDER FROM GRILL 5” (127mm) MAXIMUM CYLINDER SIZE OPENING A AREA OPENING B AREA 20 lb (9.1kg) 20in (130cm 10in (65cm 30 lb (13.6kg) 30in (195cm 15in (100cm www.napoleon.com N415-0541 JUL 17.20...
- Page 7 Never remove the grounding plug or use with an adapter of 2 prongs. • Use only extension cords with a 3 prong grounding plug, rated for the power of the equipment, and approved for outdoor use with a W-A marking. N415-0541 JUL 17.20 www.napoleon.com...
-
Page 8: Lighting Instructions
Hold the burner control off. lit match down through the grill Wait 5 minutes. and sear plate while turning the Repeat. corresponding burner valve to high. WARNING! Do not use rear burner while operating main burner. www.napoleon.com N415-0541 JUL 17.20... -
Page 9: Cooking Instructions
This may cause the control panel to become extremely hot to touch and the knobs to deform. Napoleon includes a wind deflector with your unit. It will help prevent the possibility of improper heat build-up. - Page 10 OFF at any time. Double click again to turn it back on. • If the unit is powered OFF and ON again (main power switch), the logo light will return to its default mode. www.napoleon.com N415-0541 JUL 17.20...
-
Page 11: Cleaning Instructions
Cleaning The Outer Grill Surface: Do not use abrasive cleaners or steel wool on any painted, porcelain or stainless steel parts of your Napoleon Grill. Doing so will scratch the finish. Exterior grill surfaces should be cleaned with warm soapy water while the metal is still warm to the touch. To clean stainless surfaces, use a stainless steel or a non-abrasive cleaner. -
Page 12: Maintenance Instructions
Slide the burner back and up wards to remove. Cleaning: Use a flexible venturi tube brush to clean the inside of the burner. Shake any loose debris from the burner through the gas inlet. Check the www.napoleon.com N415-0541 JUL 17.20... - Page 13 Regulator Hose (when applicable): Check for abrasions’, melting, cuts, and cracks in the hose. If any of these conditions exist, do not use the gas grill. Have the part replaced by your Napoleon Gas Grill dealer or qualified gas installer.
-
Page 14: Troubleshooting
This is not a defect. The finish on the lid and hood is peeling inside lid or hood. porcelain and will not peel. The peeling is caused by hardened grease, which dries into paint-like shards, that flake off. Regular cleaning will prevent this. See cleaning instructions. www.napoleon.com N415-0541 JUL 17.20... - Page 15 Allow burner to cool and inspect very closely Cracked ceramic tile. for cracks. If any cracks are found, contact your authorized Napoleon dealer to order a replacement burner assembly. Contact your authorized Napoleon dealer for Leaking gasket surrounding the...
-
Page 16: Ordering Replacement Parts
3. A concise description of the problem (‘broken’ is not sufficient). 4. Proof of purchase (photocopy of the invoice). In some cases, Napoleon could request to have the parts returned to the factory for inspection before providing replacement parts. Before contacting Napoleon dealer, please note that the following items are not covered by the warranty: •... -
Page 17: Getting Started
If you have any questions about assembly or grill operation or if there are damaged or missing parts please call our Customer Solutions Department at 1-866-820-8686 between 9 AM and 5 PM (Eastern Standard Time). TOOLS REQUIRED FOR ASSEMBLY (tools not included) 3/8” (10 mm) N415-0541 JUL 17.20 www.napoleon.com... - Page 18 WARNING! A propane tank can not be stored below the gas grill. WARNING! CABINET FRAME, CABINET AND COUNTER TOP MUST BE MADE FROM NON-COMBUSTIBLE MATERIAL WHEN NOT INSTALLED WITH THE ZERO CLEARANCE LINER PART NO. BI-3323-ZCL www.napoleon.com N415-0541 JUL 17.20...
- Page 19 NOTES BIP / BIPRO500 WITH 33 ” 22 9/16” 9 1/16” ZERO CLEARANCE SHELL 840 mm 573 mm 230 mm BI-3323-ZCL KNOCK OUT 34”(864mm) RECOMMENDED WARNING! A propane tank cannot be stored below the gas grill. N415-0541 JUL 17.20 www.napoleon.com...
- Page 20 3. Lower the unit in place, the wings on the rear trim should be under the side mounting brackets. Connect the flex supply line to the fitting at the end of the manifold. 4. The entire installation must be leak tested before operating the unit. APPLY A DAB OF SILICONE TO EACH FLANGE TO SECURE IN PLACE. www.napoleon.com N415-0541 JUL 17.20...
- Page 21 Heat shield Drip pan N415-0541 JUL 17.20 www.napoleon.com...
- Page 22 4” (102 mm) below the bottom of the grill as illustrated. Fasten the electrical box to the inside of the enclosure, making sure the ventilation holes are not obstructed. Plug the power supply into a Ground Fault Interrupter (GFI) protected circuit. Never remove the ground- ing plug or use with an adapter of 2 prongs. www.napoleon.com N415-0541 JUL 17.20...
- Page 23 NON-METALIC CABINET ONLY LOCATED INSIDE CABINET N415-0541 JUL 17.20 www.napoleon.com...
- Page 24 IM-UGC500 N570-0038 (1/4”-20 X 1/2”) N450-0008 (1/4”-20) www.napoleon.com N415-0541 JUL 17.20...
- Page 25 (Pre-installed at factory.) N570-0087 (1/4” -20 X 7/8”) COUNTER TOP REQUIRED. (NOT INCLUDED) IM-UGC500 N415-0541 JUL 17.20 www.napoleon.com...
- Page 26 LOCATED INSIDE CABINET www.napoleon.com N415-0541 JUL 17.20...
- Page 27 N415-0541 JUL 17.20 www.napoleon.com...
- Page 28 N415-0541 JUL 17.20...
-
Page 29: Leak Testing Instructions
Bubbles will indicate a gas leak. Either tighten the loose joint or have the part replaced with one recommended by the Napoleon Customer Solutions department and have the grill inspected by a certified gas installer. STOP If the leak cannot be stopped, immediately shut off the gas supply, disconnect it, and have the grill inspected by a certified gas installer or dealer. - Page 30 Rotisserie Kit Assembly Instruction (optional) Assemble rotisserie kit components as shown. Ensure stop bushing is tightened on the inside of hood casting. www.napoleon.com N415-0541 JUL 17.20...