Joyner Dirt Devil 250 2004 Owner's Manual And Parts Manual page 17

d. Engine stop button
Important - stop button test.
Before driving this vehicle, test the Engine Stop Button to assure that it is operating properly. With
the engine running, push and hold the Engine Stop Button for two seconds for the engine to shut down.
B. Pre-Drive Inspection
a.
Check for Engine Oil Level. Check for leaks, add oil if required.
b.
Check for Fuel Level. Add fuel as necessary and do not overfill. Check for leaks.
c. Check for Brakes. Depress the rear brake pedal several times, then check for proper brake pedal
free play. Make sure there is no brake fluid leakage. Adjust if necessary.
d. Check Tires. Check tires condition and pressure. The pressure on both Front and Rear tire is
15kpa and 20kpa.
e. Check Drive Chain, Check for drive chain's condition and tension. Lubricate if necessary.
f.
Check Throttle. Check for smooth operation. Assure throttle "snaps" back to idle.
g. Check Engine Stop Button. Perform engine stop button test. Repair as necessary.
h.
Check all Nuts, Bolts, and fasteners. Check wheels to see that all axle nuts and lug nuts are
lightened property. Check and tighten as necessary all other fasteners to specified condition.
i.
Check Roll Cage Bar. Ensure all protective roll cage bar are in place before operating the Go-Kart.
j.
Check Brake Light. Check for proper operation.
k. Check Wheels. Check for tightness of wheel nuts and axle nuts; check that axle nuts
are secured by cotter pins.
l. Check Steering. Check for free operation for any unusual looseness in any area.