Limited use/limited application elevator (28 pages)
Summary of Contents for Savaria Vuelift Mini
Page 1
Vuelift Mini Residential Elevator Owner’s Manual...
Page 2
IMPORTANT Ensure that only an authorized Savaria Dealer installs and services the Vuelift Mini Residential Elevator. Under no circumstances is anyone other than a dealer with Savaria training and authorization to install, adjust, service or modify any mechanical or electrical device on this equipment. Failure to follow this warning can result in safety system compromises or defeat;...
• Ensure that only qualified personnel perform maintenance and service on the unit. • When replacing parts, be sure that only genuine Savaria parts are used. • This unit is intended for use by a mature person who understands its proper operation as set out in this manual.
1. DESCRIPTION Figure 1 shows the components of the Vuelift Mini Residential Elevator. Figure 1 Hall call button operating panel Hoistway (COP) door lock Hoistway door Cab with manual rotating sliding door Part No. 001254, 26-m4-2022 Vuelift Mini Owner’s Manual...
Weight of ropes: 0.243 lb/ft (3.616 g/cm) Travel cable weight: 0.228 lb/ft (3.393 g/cm) Type: Winding drum Motor: 1.77 HP (1.32 kW) @ 60 Hz with integrated brake Drive train Motor control: Preprogrammed variable frequency drive Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
Page 7
Buck boost transformer Up to 6 stops; balcony attachment or thru-floor configuration Cab shipped disassembled Landing door handle painted to match unit Top header ring in sheet metal painted to match unit Part No. 001254, 26-m4-2022 Vuelift Mini Owner’s Manual...
• Press the blue VOL key on the keypad to raise or lower the volume. • Press the red ON/OFF Emergency phone button on the keypad to turn off the phone. Speaker Figure 3 Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
DO NOT leave the area unattended. If a power failure occurs, a battery lowering system will bring the Vuelift Mini to the bottom level. If the battery fails while operating, there is a manual lowering device that can be used to bring the Vuelift Mini to a lower landing level as described below.
Dusting (Metal Surfaces) Dust the metal rings and painted surfaces with a soft, damp microfiber cloth or chamois. Dry, gritty or previously used cloths may cause surface scratches. Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
Apply a thin, even coat with a soft clean cloth and polish slightly with cotton flannel or a microfiber towel. Then wipe with a damp cloth to help eliminate electrostatic charges that can attract dust particles. Part No. 001254, 26-m4-2022 Vuelift Mini Owner’s Manual...
For glass panels, use a normal glass cleaner such as Windex® or equivalent. These above lists are for reference only and are not comprehensive. If you have any questions about the acceptability of a specific cleaner, please contact your authorized dealer. Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
These above lists are for reference only and are not comprehensive. If you have any questions about the acceptability of a specific cleaner, please contact your authorized dealer. Note that damage caused by inappropriate cleaners and techniques is not covered under warranty. Part No. 001254, 26-m4-2022 Vuelift Mini Owner’s Manual...
Beep code Action to take Service codes Contact your authorized Savaria dealer for service. There is a problem in one of 1 long beep (2 seconds) followed by the following areas: overload trip, run...
Rail lubrication is NOT allowed for the Vuelift hoistway or car rails. The Vuelift Mini elevator is designed to require minimal maintenance. A 6-month inspection of certain components is required to maintain the Factory Warranty. The first required service of the drive train components (motor/gearbox, drums, etc.) is after 2,000 operational hours (approximately...
Page 16
Condition of contacts and remaining contact material • Fuses for correct size and fit in holders and corrosion in fuse holder • Relays for worn shunts and signs of overheating • Evidence of overheating Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
Page 17
Leaving the Car Top • Clean up and dispose of debris properly. Return the car to normal operation and the stop switch to the RUN position. Part No. 001254, 26-m4-2022 Vuelift Mini Owner’s Manual...
Page 18
Do not use harsh chemicals on the overspeed components; use only mild detergents. BRAKES Verify proper operation of the safety brakes and the motor brake. Check with full load every 12 months. Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
Page Intentionally left blank Maintenance Schedule and Record on next pages Part No. 001254, 26-m4-2022 Vuelift Mini Owner’s Manual...
Page 20
• Leaving the pit OVERSPEED • Overspeed belt 6 months • Overspeed system BRAKES 6 months • Safety brakes and motor brake BRAKES (WITH FULL LOAD) 12 months • Safety brakes and motor brake Vuelift Mini Owner’s Manual Part No. 001254, 26-m4-2022...
Page 21
Maintenance Record Date Time Reason for call Comments Dealer...