Polaris RZR 200 EFI 2021 Owner's Manual page 92

MAINTENANCE
Vehicles subjected to severe use must be serviced at 50% of the stated interval.
Examples of Severe Use: Frequent immersion in mud, water, or sand, constant
high RPM use, prolonged low-speed heavy load operation, extended idle, and
short trip cold weather operation.
EVERY 100 HOURS / 1000 MILES (1600 KM) OR YEARLY
Air Filter
Battery
Brake Pads, Brake Lines /
Hoses
Brake System
Clutches (Drive and
Driven)*
Drive Belt
Drive Chain
Engine Mounts
Engine Oil and Filter
Exhaust Silencer / Pipe
Front / Rear Suspension
Fuel System / Filter*
General Lubrication
Shift Cable / Linkage
Spark Arrestor
Spark Plugs
Steering Components
90
Replace air filter. Ensure proper installation of
filter and airbox cover. Inspect ducts and
screens; clean as necessary.
Check terminals; terminals should be tight and
free of corrosion. Clean, test, and replace as
necessary.
Inspect; replace as needed.
Inspect for fluid leaks; add recommended brake
fluid from a sealed container if needed.
Inspect; clean; replace as needed.
Inspect; replace as needed.
Inspect; adjust; lubricate.
Inspect.
Change the engine oil and filter.
Inspect for leaks or damage.
Lubricate.
Inspect; cycle key to pressurize fuel pump;
check for leaks at fuel system connections,
check for leaks at fill cap. Replace filter.
Locate all applicable fittings and grease.
Inspect; adjust; lubricate.
Inspect; clean.
Inspect; replace as needed.
Lubricate.