Table Of Contents - Cal Spas Inground Spas Owner's Manual

Preparing for Your New Inground Spa
Inground Spa Installation Checklist . . . . . . . 4
Planning the Best Location For Your Spa . . . 4
Planning the Best Place for the Outdoor
Equipment Pack . . . . . . . . . . . . . . . . . . . . . . . 5
Inground Spa Site Preparation . . . . . . . . . . . 5
Electrical Requirements - US and Canada . . 6
GFCI Wiring Diagram . . . . . . . . . . . . . . . . . . 7
Electrical Installation -- Europe . . . . . . . . . . 8
RCD Wiring Diagram . . . . . . . . . . . . . . . . . . . 9
Installing the Inground Shell . . . . . . . . . . . 10
Equipment Pack Plumbing Connections . . . 11
Plumbing Connections . . . . . . . . . . . . . . . . 11
Electrical and Electronic Connection . . . . . 13
Pouring the Deck . . . . . . . . . . . . . . . . . . . . . 16
9800 Electronic Control Operation
Diagnostic Messages . . . . . . . . . . . . . . . . . . 20
Adjustable Jets . . . . . . . . . . . . . . . . . . . . . . 22
Diverter Knobs . . . . . . . . . . . . . . . . . . . . . . . 22
Waterfalls . . . . . . . . . . . . . . . . . . . . . . . . . . 22
Air Venturis . . . . . . . . . . . . . . . . . . . . . . . . . 22
Copyright 2008-2009 LMS, Inc. All rights reserved. Duplication without written consent is
strictly prohibited.
Cal Spas is a registered trademark.
®
Due to continuous improvement programs, all models, operation, and/or specifications are
subject to change without prior notice.
LTR20091002, Rev. B
1/30/09
Clear Water Plan
The Key to Clear Water . . . . . . . . . . . . . . . . 23
Testing and Adjusting Spa Water . . . . . . . . 24
Sanitation . . . . . . . . . . . . . . . . . . . . . . . . . . . 25
Filter Cleaning . . . . . . . . . . . . . . . . . . . . . . . 27
Bather Load . . . . . . . . . . . . . . . . . . . . . . . . . 27
Starting the Spa with Fresh Water . . . . . . . 28
Maintenance Schedule . . . . . . . . . . . . . . . . 29
Del Zone Eclipse Ozonator . . . . . . . . . . . . . 30
Troubleshooting Water Clarity Problems . . 31
Cleaning and Maintenance
Removing and Reseating the Pillows . . . . . 32
Spa Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . 32
Draining Your Spa . . . . . . . . . . . . . . . . . . . . 33
Cleaning and Replacing the Filter . . . . . . . . 33
Winterizing (Cold Climate Draining) . . . . . 33
Cleaning the Cover, Shell and Pillows . . . . 34
Appendix
Replacement Parts . . . . . . . . . . . . . . . . . . . 36
Keeping Fit with your Cal Spa . . . . . . . . . . . 37
Cal Spas™ Chemicals . . . . . . . . . . . . . . . . . . 39
CONTACT INFORMATION
For customer service, please contact
your authorized dealer immediately. If
you need additional information and/
or assistance, please contact:
LMS Customer Service Department
1462 East Ninth Street
Pomona, CA 91766.
Toll Free: 1-800-CAL-SPAS
Fax: 1-909-629-3890
www.calspas.com