Cal Spas Portable Spa Owner's Manual
  1. Manuals
  2. Brands
  3. Cal Spas Manuals
  4. Hot Tub
  5. Portable Spa
  6. Owner's manual

Cal Spas Portable Spa Owner's Manual

Cal flame portable spa owner's manual
Hide thumbs
Table of Contents

Advertisement

Quick Links

LTR20091000, Rev. C
6/8/09

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the Portable Spa and is the answer not in the manual?

Questions and answers

Related Manuals for Cal Spas Portable Spa

Summary of Contents for Cal Spas Portable Spa

  • Page 1 LTR20091000, Rev. C 6/8/09...

  • Page 2: Table Of Contents

    Spa Cover . . . . . . . . . . . . . . . . . . . . . . . . . . . 31 Draining Your Portable Spa . . . . . . . . . . . . 32 Cleaning and Replacing the Filter .

  • Page 3: Important Safety Instructions

    The effects of excessive hyperthermia may include: 2009 Portable Spa LTR20091000, Rev. C DANGER -- Risk of injury: The suction fittings in this spa are sized to match the specific water flow created by the pump. Should the need arise to replace the suction fittings, or the pump, be sure the flow rates are compatible.

  • Page 4: Save These Instructions

    WARNING: People with infectious diseases should not use a spa or hot tub. WARNING: To avoid injury, exercise care when entering or exiting the spa or hot tub. WARNING: Do not use drugs or alcohol before or during the use of a spa or hot tub to avoid unconsciousness and possible drowning.

  • Page 5: Preparing For Your New Portable Spa

    Preparing for Your New Portable Spa Most cities and counties require permits for exterior construction and electrical circuits. In addition, some communities have codes requiring residential barriers such as fencing and/or self-closing gates on property to prevent unsupervised access to the property by children. Your dealer can provide information on which permits may be required and how to obtain them prior to the delivery of your spa.

  • Page 6: 120 Volt Electrical Installation

    Reset the GFCI breaker by switching the breaker to the full OFF position, wait a moment, then turn the breaker back on. The spa should have power again. 2009 Portable Spa LTR20091000, Rev. C...
  • Page 7 SEE PAGES 6 AND 7 FOR INSTALLATION DIAGRAM. Fitness Pro 4700 spa SEE PAGES 6 AND 7 FOR INSTALLATION DIAGRAM. 2009 Portable Spa LTR20091000, Rev. C GFCI Required One 50 amp GFCI Four #8 AWG copper wires One 60 amp GFCI...
  • Page 8 Electrical Installation for 11 kW Heater This applies to Fitness spas with the 11 kW heater only. Two electrical services are required to heat the swim side of the Fitness Spa. www.calspas.com before wiring 2009 Portable Spa LTR20091000, Rev. C...

  • Page 9: Gfci Wiring Diagram

    GFCI Wiring Diagram 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...

  • Page 10: Gas Heater Hook Up

    Cut off both sides of the union and discard it. Create two 2½” diameter holes through the spa panel. Use two 2” couplings to connect the hoses to 10’ - 15’ 2-3/8” diameter PVC lines. Connect PVC lines to the gas heater. www.calspas.com 2009 Portable Spa LTR20091000, Rev. C...
  • Page 11 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...

  • Page 12: Filling And Powering Up Your Portable Spa

    Filling and Powering Up Your Portable Spa Never fill your spa with soft water. Soft water makes it impossible to maintain the proper water chemistry and may cause the water to foam, which will ultimately harm the finish of the spa and void your warranty.

  • Page 13: Operating Your Spa

    • and will alternate with spa temperature if measured temperature is current. 2009 Portable Spa LTR20091000, Rev. C • Economy mode will heat the water to the set temperature while Sleep mode, indicated by a...

  • Page 14: Automatic Time Outs

    30 seconds. The low speed pump will run for the duration of the filtering cycle and if an Ozone system is installed it will be activated. During filtering, FC will appear on the main display. 2009 Portable Spa LTR20091000, Rev. C...

  • Page 15: Operation

    “MODE/PROG” programming. Press the “DOWN” button to cycle through to the desired mode. Press “MODE/PROG” to confirm selection. 2009 Portable Spa LTR20091000, Rev. C Auxiliary Control Operation The auxiliary control option is available with the 9800 controls only. It is a small panel with four buttons that control certain spa functions, such as primary or additional jets, TV, or lights.

  • Page 16: Sounds Good" System Operation

    SOUNDS GOOD panel: Once All sounds play at full volume Twice All sounds play at half volume Three times One sound plays for all controls Four times All sounds are off 2009 Portable Spa LTR20091000, Rev. C...

  • Page 17: Periodic Reminder Messages

    Every 30 days Every 90 days Every 180 days Every 365 days 2009 Portable Spa LTR20091000, Rev. C the air channels. The lowest speed of pump 2 and pump 3 will run for five minutes. In the event of power...

  • Page 18: Diagnostic Messages

    DO NOT ENTER THE WATER. Remove the spa cover and allow water to cool. At 107°F, the spa should automatically reset. If spa does not reset, shut off the power to the spa and call your dealer or service organization. 2009 Portable Spa LTR20091000, Rev. C...
  • Page 19 Mode. Stby Pressing a button combination on the user panel has activated Standby Mode. 2009 Portable Spa LTR20091000, Rev. C Action Required DO NOT ENTER THE WATER! Remove the spa cover and allow spa to cool below 107˚F (42˚C). Press any button on the topside display to reset spa.

  • Page 20: Jets

    (clockwise). Aromatherapy This optional accessory is very easy to use. Unscrew the cap on the aromatherapy chamber and drop in a bag of scented aromatherapy beads and replace the cap. 2009 Portable Spa LTR20091000, Rev. C...

  • Page 21: Adjustable Therapy System

    Operates spa light and LED mood lighting Temp Display or adjust the set temperature control Jet 1 Turn on or off jet 1 Mode Switch between Standard, Economy, and Sleep Modes 2009 Portable Spa LTR20091000, Rev. C Time Reset Mode Pulse mode will...

  • Page 22: Led Perimeter Lighting

    Spas with exterior corner LED lighting work in the same modes as described above but do not light up when the interior perimeter lights are yellow/green, green or red. www.calspas.com 2009 Portable Spa LTR20091000, Rev. C...

  • Page 23: Clear Water Plan

    See page 23 for learn how to use sanitizer. aut alit lut lore tin hent adiam iustrud molor sustis essit wis- cilit wisi. 2009 Portable Spa LTR20091000, Rev. C Contents of this section: Testing and Adjusting Spa Water...

  • Page 24: Testing And Adjusting Spa Water

    Up Liquid Hardness Increaser pH-Alkalinity Up Need to lower the pH level Need to raise the pH level Chemicals To Use: To Raise To Lower pH-Alkaliity Down Stain and Scale Defense pH-Alkaliity Down 2009 Portable Spa LTR20091000, Rev. C...

  • Page 25: Sanitation

    Place three or four bromine tablets in the chamber inside the filter cartridge as shown in the figure at right. Follow the maintenance schedule on page page 27. 2009 Portable Spa LTR20091000, Rev. C Adding Sanitizer Tablets to the Chemical Chamber...

  • Page 26: Shocking The Water

    Failure to provide a proper area for chemical storage may result in serious injury, sickness, fire explosion and even death. Do not store your chemicals inside the equipment area of your spa. Chemicals To Use: To Lower 2009 Portable Spa LTR20091000, Rev. C...

  • Page 27: About The Cal Pure Uv Water Sanitizer

    All versions of the Cal Spas Clear Water Plan are designed for spas with average bather load (3 to 4 people, 15 minutes of usage, three times a 2009 Portable Spa LTR20091000, Rev. C week at 100 degrees) If your bather load exceeds...

  • Page 28: Starting The Spa With Fresh Water

    Add 2 Cal Spas “Bromine Tablets” to bromine floater. Set floater opening at #2. Turn on jets for 15 minutes. Leave spa uncovered during this time. Put cover on spa and allow to heat up to desired temperature. 2009 Portable Spa LTR20091000, Rev. C...

  • Page 29: Maintenance Schedule

    When empty, your spa should be cleaned with a non-abrasive cleaner, such as Cal Spas™ All Surface Cleaner, and then rinsed thoroughly. 2009 Portable Spa LTR20091000, Rev. C Follow the section “Starting the Spa with Fresh Water”.

  • Page 30: Cal Zone Quest Ozonator

    The Cal Clarity bromine generator automatically generates and releases free bromine into the spa water. You will still need to test for bromide and occasionally replenish it to return the bromine level to the baseline. www.calspas.com 2009 Portable Spa LTR20091000, Rev. C...
  • Page 31 Turn the dial on the bromine generator clockwise until the LED display reads 10. 2009 Portable Spa LTR20091000, Rev. C This will initiate the build up of a bromine bank. Set the filtration cycle to “continuous” (F-C) for the first 24 hours.

  • Page 32: Troubleshooting Water Clarity Problems

    Use a stain and scale inhibitor • Adjust total alkalinity and pH – if scale requires removal, drain the spa, scrub off the scale, refill the spa and balance the water • Use a stain and scale inhibitor 2009 Portable Spa LTR20091000, Rev. C...

  • Page 33: Cleaning And Maintenance

    • Covering your spa helps prevent children from drowning in the spa. 2009 Portable Spa LTR20091000, Rev. C See the manual enclosed with your cover for instructions on mounting the locks and how to lock and unlock the cover.

  • Page 34: Draining Your Portable Spa

    Draining Your Portable Spa Your spa should be drained every four to six months, and refilled with fresh tap water. The following is the recommended method for draining your spa. Turn off the power at the breaker. Remove all filters.

  • Page 35: Winterizing (Cold Climate Draining)

    Allow spa cover to dry completely. Spray Vinyl and Leather Cleaner to cover evenly and wipe dry. Allow spa cover to dry completely. Reinstall cover on spa. 2009 Portable Spa LTR20091000, Rev. C Pillows Wipe pillows dry with a soft cloth.
  • Page 36 Buff clean with a soft cloth, rotating frequently. IMPORTANT: Cal Spas™ Fast Sheen should not be used on spas full of water. Only apply to clean, cool, dry surfaces. Incorrect product usage may cause water clarity issues. 2009 Portable Spa LTR20091000, Rev. C...

  • Page 37: Using The Entertainment System

    Functions for the Aeware DVD player 2009 Portable Spa LTR20091000, Rev. C • Always close the CD / DVD protective door. • Do not place wet CD’s or DVD’s into this unit at any time.

  • Page 38: Playing A Cd

    LED will blink twice. If not, repeat steps 2 and 3. Device Manufacturer Sony CDX-GT10M Sony CDX-HS70MW Aeware Samsung 42” plasma River Park 20” www.calspas.com Device Code Type 1440 1440 1866 1312 1530 2009 Portable Spa LTR20091000, Rev. C...

  • Page 39: Raising And Lowering The 20" Tv

    DVD player to navigate DVD menus on the TV screen. 2009 Portable Spa LTR20091000, Rev. C DVD menu will appear on the TV screen or the movie will begin playing automatically. To navigate the DVD menu on the TV screen, press the TRACK UP or TRACK DOWN buttons on the Ae- ware DVD player (not the remote control).

  • Page 40: Replacement Parts

    Standard gray PLU21703433 Stainless steel PLU21703632 OZ 2” Ozone Injector Standard gray PLU21700818 PSA 5 .5” Power Storm Acupressure Standard gray PLU21703668 Stainless steel PLU21703449 psa 4” Polystorm Acupressure Standard gray PLU21703448 Stainless steel PLU21703667 2009 Portable Spa LTR20091000, Rev. C...
  • Page 41 Standard gray PLU21703424 Stainless steel PLU21703623 T 5 .25” Tornado Standard gray PLU21703428 Stainless steel PLU21703629 W 4” Whirlpool Stainless steel PLU21703609 2009 Portable Spa LTR20091000, Rev. C Valves 1” LED Diverter Valve with Swoosh Logo PLU21300450 2” LED Diverter Valve with...
  • Page 42 The complete selection of replacement cabinets for all models is very extensive and too lengthy for this owner’s manual. See your Cal Spas deal to order replacement panels for your spa, or call 1-800-CAL- SPAS. 2009 Portable Spa LTR20091000, Rev. C...
  • Page 43 Deluxe Slate Deluxe Palomino A969L Standard Rust Standard Gray Standard Slate Standard Palomino Deluxe Rust Deluxe Gray Deluxe Slate Deluxe Palomino 2009 Portable Spa LTR20091000, Rev. C Classic Series 84” X 64” CA-36/CBA-36/CD-46/CM-47/ CA-50/CBA-50/CBA-64/CA-65 ACC01200460 Standard Rust ACC01200461 Standard Gray ACC01200464...
  • Page 44 ACU02200509 ACU02200513 ACU02200514 ACU02200515 96” x 169” ACU02200420 ACU02200421 ACU02200422 ACU02200423 ACU02200424 ACU02200425 ACU02200426 93” x 206” ACU02200400 ACU02200401 ACU02200402 ACU02200406 ACU02200403 ACU02200404 ACU02200405 96” x 202” ACU02200407 ACU02200408 ACU02200409 ACU02200410 ACU02200411 ACU02200412 ACU02200413 2009 Portable Spa LTR20091000, Rev. C...
  • Page 45 Deluxe Slate Deluxe Palomino Deluxe Teal Deluxe Navy Deluxe Hunter FII730/FII745 Standard Rust Standard Gray Standard Slate Standard Palomino 2009 Portable Spa LTR20091000, Rev. C Deluxe Rust Deluxe Gray 78” ROUND Deluxe Slate Deluxe Palomino Deluxe Teal Deluxe Navy Deluxe Hunter...
  • Page 46 78” x 84” ACC01200520 ACC01200521 ACC01200522 ACC01200523 84” x 84” ACC01200410 ACC01200411 ACC01200412 ACC01200419 ACU02200250 ACU02200251 ACU02200256 ACU02200257 ACU02200252 ACU02200253 ACU02200254 93” x 93” ACC01200420 ACC01200421 ACC01200422 ACC01200423 ACU02200260 ACU02200261 ACU02200266 ACU02200267 ACU02200262 ACU02200263 ACU02200264 2009 Portable Spa LTR20091000, Rev. C...
  • Page 47 Cover PLU21400197 Bottom Drain Filtration Return Assembly OZO18300005 Cover Lifts Cover Lift Kit, Bottom Mounting ACC01600116 2009 Portable Spa LTR20091000, Rev. C Cover Lifts Cover Lift Adjustable (Top Mount) ACC01600117 Hand Rails Swivel Hand Rail (Black) FIX12400002 Swivel Hand Rail (Chrome)
  • Page 48 Leg Streching and Strength Training Attach an ankle band to your ankle and attach a 62” exercise band to any exercise anchor. Lift your leg to the side or back as the band provides tension. 2009 Portable Spa LTR20091000, Rev. C...
  • Page 49 Connecting the Exercise Equipment The drawings below show different ways the exercise kit can be connected depending on the exercises you wish to do. 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...

  • Page 50: 2009 Warranty

    Portable Spas Family series, Avalon, Classic, Escape and Victory Fitness and Xtreme spas Galaxy spas 3 Years 5 Years 3 Years 5 Years 3 Years 5 Years 3 Years 5 Years 3 Years 5 Years 2009 Portable Spa LTR20091000, Rev. C...
  • Page 51 • Damage caused by direct sunlight. Spas should always be covered when not in use. 2009 Portable Spa LTR20091000, Rev. C • Damage caused as a result of failure to follow operating instructions as defined within this owner’s manual.
  • Page 52 Cal Spas™ Chemicals 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...
  • Page 53 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...
  • Page 54 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...
  • Page 55 2009 Portable Spa LTR20091000, Rev. C www.calspas.com...
  • Page 56 Locating the product serial number The serial number of your spa is located on a metal plate attached to the lower right front panel of the spa.You will need this number to properly register your spa and activate coverage. Write this information in the space provided below.

Table of Contents