Table of Contents
Advertisement
Quick Links
Homestead
Hearth Mount (#8570H) & Freestanding (#8570F)
NON-CATALYTIC WOODSTOVE
Owner's Manual
Installation and Operating
Instructions
Save these instructions
for future reference!
Please read this entire Owner's Manual
before
you
install
and
use
your
new
Homestead Wood Stove. To reduce the risk of
fire, follow the following instructions. Failure
to follow these instructions may result in
property damage, bodily injury, or even
death.
Contact local authorities having jurisdiction (your local building department or fire officials) about the
required permits, any restrictions, and an installation inspection
Homestead Model 8570
Manual: 6400-40416
Revised: 3/13/12
Advertisement
Table of Contents
Troubleshooting
Related Manuals for HearthStone Homestead 8570F
Summary of Contents for HearthStone Homestead 8570F
- Page 1 Homestead Hearth Mount (#8570H) & Freestanding (#8570F) NON-CATALYTIC WOODSTOVE Owner’s Manual Installation and Operating Instructions Save these instructions for future reference! Please read this entire Owner’s Manual before install your Homestead Wood Stove. To reduce the risk of fire, follow the following instructions. Failure to follow these instructions may result in property damage, bodily injury, or even death.
- Page 2 Intentionally Blank...
-
Page 3: Table Of Contents
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Table of Contents Introduction ..........................4 Codes ....................................... 5 Safety Information ..................................5 Specifications .................................... 6 Installation ..........................8 Unpacking ....................................8 Installing Your Stove ................................. 8 Hearth Requirements and Floor Protection ..........................9 Fireplace Install For Hearth Mount Stove (#8570H) with 4-inch Legs .................. -
Page 4: Introduction
19 inches long! You SAFETY NOTICE: A HOUSE FIRE MAY RESULT IF can be proud to join the Hearthstone family. THIS STOVE IS NOT INSTALLED PROPERLY. FOR YOUR... -
Page 5: Codes
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Make sure the removable ash lip is in place — Codes as it was certified for operation — while using When you install your Homestead, it is imperative the stove. -
Page 6: Specifications
Heat-Life: Twelve hours Heat-Life is a trademark of Check door seals using the “dollar bill test” — Hearthstone and is defined as thermal capacitance or quantity of heat stored. Used here, it refers not when the fire is out and the stove cool, shut the just to burn time, but also to hours of usable heat door on a dollar bill. - Page 7 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Crated Dimensions: Height (#8570H with 4” legs or Optional Equipment for Model #8570F: Rear Heat #8570F with 6” legs): 34½” (876 mm); Width: 31 ” Shield Kit, Blower Fan Kit, Outside Air Kit, Hearth (790 mm);...
-
Page 8: Installation
You can reduce some clearances by adding the information.) optional Rear Heat Shield Kit manufactured by Owner’s Manual Hearthstone and available through your local dealer. (See page 45 for a description; a companion Blower If any parts are damaged or missing, please contact also... -
Page 9: Hearth Requirements And Floor Protection
4” or 6” legs. For 4” legs, the surround is 44” wide and 32” high; for 6” legs, the surround is 44” wide and 34” high. The Surround Kit is available from your Hearthstone dealer, and comes complete with all mounting hardware and instructions. (Please see “Optional Accessories”... - Page 10 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H A floor protector with an R-value of 6.6 or more If a K-factor is given with a required thickness that you obtain from your dealer. (A floor (T) in inches, use this formula: R-value = 1/K x T...
-
Page 11: Fireplace Install For Hearth Mount Stove (#8570H) With 4-Inch Legs
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Total R-value 2.82 Wall Clearances (4-inch legs, without surround) ½” mineral wool insulation 1.56 ” horizontal still air 0.92 1” cement mortar 0.20 Total R-value 2.68 Fireplace Install For Hearth Mount... -
Page 12: Dimensions And Clearances For Hearth Mount (#8570H) Stove With 4-Inch Legs And Surrounds
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Dimensions and Clearances for Fireplace Clearances (4-inch legs, without surround) Hearth Mount (#8570H) Stove with The Homestead stove with 4-inch legs fits uniquely 4-Inch Legs and Surrounds under a 22-inch lintel. - Page 13 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Wall Clearances (4-inch legs, with surround) Mantle Clearances (4-inch legs, with surround)
- Page 14 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Hearth Clearances (for stoves with 4-inch legs) The following three illustrations describe the clearance to combustible requirements for three different hearth heights: Hearths raised less than 2 inches...
- Page 15 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Hearths Raised From 2 Inches to 9 Inches (Model #8570H shown) Hearths Raised 9 Inches or More (Model #8570H shown)
-
Page 16: Fireplace Install For Freestanding Stove (Model #8570F) With 6-Inch Legs
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Wall Clearances (6-inch legs, without surround) Fireplace Install for Freestanding stove (model #8570F) with 6-Inch Legs Before installing your Freestanding stove with 6-inch legs and a bottom heat shield, understand the... - Page 17 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Dimensions and Clearances for Freestanding Stove with 6-Inch Legs and Surrounds The following four illustrations depict the stove’s dimensions and fireplace, mantle, and wall clearances for a stove with 6-inch legs, a bottom heat shield, with a surround. (Please refer to “Surround Kit” on page 9 for information about this option.)
- Page 18 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Wall Clearances (6-inch legs, with surround) Mantle Clearances (6-inch legs, with surround)
- Page 19 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Hearth Clearances (for stoves with 6-inch legs) The following three illustrations describe the clearance to combustible requirements for three different hearth heights: Hearths not raised Hearths raised less than 7 inches ...
- Page 20 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Hearths Raised Less Than 7 Inches (Model #8570F shown) Hearths Raised 7 Inches or More (Model #8570F)
-
Page 21: Freestanding Install For Hearth Mount Stove (#8570H) With 4 Inch Legs And For Freestanding Stove (#8570F) With 6 Inch Legs
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Freestanding Install for Hearth Mount Stove (#8570H) With 4 Inch Legs and For Freestanding Stove (#8570F) With 6 Inch Legs Clearances to Hearths for Hearth Mount Stoves (#8570H) with 4-inch Legs... - Page 22 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Hearths Raised From 2 Inches to 9 Inches (Model #8570H shown) Hearths Raised 9 Inches or More (Model #8570H shown)
- Page 23 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Clearances to Hearths for Freestanding Stoves (#8570F) with 6-inch Legs The following three illustrations (while similar in appearance to the previous ones) describe the clearance to combustible requirements for stoves with 6-inch legs to three different hearth heights: ...
- Page 24 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Hearths Raised Less Than 7 Inches (Model #8570F shown) Hearths Raised 7 Inches or More (Model #8570F shown)
- Page 25 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Clearances to Combustible Surfaces for Clearances from Stovepipes Both Heart Mount (4” legs) and This table and illustration lists the minimum Freestanding (6” legs) Stoves clearances from your single- and double-wall...
- Page 26 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Clearances from a Stove to a Corner This table and illustrations list the minimum clearances from the back of your stove to the walls in a corner, both when your stove is parallel and angled to the corner, and to unprotected and NFPA 211 protected walls.
-
Page 27: Venting Components And Configuration
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Venting Components and Configuration installing a chimney connector through a Components of a Venting System combustible wall to the chimney. The complete venting system consists of several A wall pass-through (or chimney support components: chimney connector, wall thimble, wall package) also keeps walls from igniting. - Page 28 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Extended Roof Chimney Cap Chimnet Cap Support Bracket Storm Collar (Conduit Storm Collar Adjustable Roof not included) Adjustable Roof Flashing Flashing Attic Insulation Shield Firestop Radiation Twist-Lock Shield...
-
Page 29: Connecting Your Wood Stove
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Installing a Venting System Installing in a Fireplace Attach stovepipe sections to the stove and to each You can install the Homestead in a masonry or zero other with the crimped end toward the stove. If clearance fireplace. - Page 30 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H described floor protection requirements when Connecting to a Masonry Chimney installing into a zero clearance fireplace. Consider two primary elements when connecting your stove to a masonry chimney: the chimney itself...
- Page 31 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Exterior chimney requirements At least 1” (25 mm) clearance to combustible structure. Chimney height requirements (see illustrations) At least 3 feet (0.9 meters) higher than the highest part of the roof opening through which it passes.
-
Page 32: Installing In A Mobile Home
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Installing in a Mobile Home Follow these special requirements for installing your stove in a mobile home: Install the stove in accordance with 24 CFR, Part 3280 (HUD). -
Page 33: Operation
Once your Homestead is set in place, connected, and assembled, you are ready to light a fire. Hearthstone Stoves tests each wood stove before we ship, so you should be able to easily light your first fire. You may, however, have to make a few small adjustments to compensate for altitude and other factors particular to your installation. -
Page 34: Wood Heat Value
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Maple, Red 2,924 18.7 Wood Heat Value Fir, Douglas 2,900 18.1 Common Name Lb/ cord MBTU/ cord High Medium Low Osage Orange (Hedge) 4,728 32.9 Boxelder 2,797 17.9... -
Page 35: Building A Fire
Some of these impurities can To enhance the combustion efficiency and reduce be cleaning solvents, paint solvents, cigarettes, the emissions of the fire in your stove Hearthstone smoke, pet hair, dust, adhesives, a new carpet, and has developed an advanced THERMO-CERAMIC new textiles. - Page 36 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H 3. Using a match, light the paper under the kindling. 4. Close the door and allow the fire to burn. Keep Leave the front door slightly ajar momentarily...
-
Page 37: Operating Your Stove Efficiently
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H established fire. Next, pull the primary air control Operating Your Stove Efficiently fully open, and then completely load the firebox with Your Homestead stove is designed to burn firewood wood. - Page 38 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Inappropriate Fuel: Do not burn coal; kiln dried ash grate using a poker or other suitable implement. lumber, wax logs, or anything other than natural Spin the ash grate closed—remember to close the cordwood.
-
Page 39: Maintenance & Cleaning
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Maintenance & Cleaning designed for your type of chimney. Strongly consider Stove’s Interior hiring a certified chimney sweep to clean your chimney. Contact your dealer for the name of a Monitoring Your Stove’s Temperature... -
Page 40: Stove's Exterior
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H You can clean most deposits by following the Reversible Flue: 32” (1016 mm) long; ¼” (9.5 mm) instructions provided with the cleaner. To clean diameter; low density, black rope heavier deposits, first remove the door from the stove. - Page 41 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H covered with an enamel finish in various colors that You can clean the enamel castings with a standard creates a porcelain finish. glass cleaner. With time and use, a very fine, subtle...
-
Page 42: Troubleshooting
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Troubleshooting home. Outfitting your stove with the optional outside Your Heating Needs air supply adapter, connected to an air duct leading Nearly everyone who uses a woodstove experiences to the outside of your home, should correct this basic common problems at one time or another. -
Page 43: Troubleshooting Guide
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Troubleshooting Guide Symptom Possible Cause Corrective Action Your stove smokes Operating technique Fully open the primary air control one minute before opening the doors. Cold chimney Preheat the chimney when first starting a fire. -
Page 44: General Information
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H General Information Parts and Accessories Replacement Part Castings 5570-122 Secondary Air Tube #2 Part Number Description 5570-123 Secondary Air Tube #3 2510-730 Ash Grate 5570-150 Top Heat Shield... -
Page 45: Optional Accessories
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Optional Accessories Part Description Picture Explanation Number 90-57000 Blower Fan Kit Not for use in an enclosure (such as a fireplace or alcove). Must be installed with the Rear Heat Shield Kit. -
Page 46: Safety Label
® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Safety Label... - Page 47 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H WARRANTY REGISTRATION The Original Purchaser may complete their registration online on our website (www.hearthstonestoves.com), or send a completed and signed Warranty Registration Form, which is enclosed in the Stove Owner’s Packet, to the following address: Hearthstone Quality Home Heating Products, Inc.
- Page 48 ® Hearthstone Quality Home Heating Products, Inc. Homestead Models #8570F and #8570H Notes:...