Trina Solar DUOMAX Installation Manual

Trina Solar DUOMAX Installation Manual

Hide thumbs Also See for DUOMAX:

Advertisement

Quick Links

INSTALLATION MANUAL
IEC & UL version
THE
/
MODULE
TSM-PDG40.40
TSM-PDG40.47
TSM-PDG5.40
Duomax
TSM-PDG5.47
TSM-PDG14.40
TSM-PDG14.47
TSM-PEG40.40
TSM-PEG40.47
TSM-PEG5.40
Duomax
TSM-PEG5.47
TSM-PEG14.40
TSM-PEG14.47
TSM-DEG40.40
TSM-DEG40.47
TSM-DEG5.40
TSM-DEG5.47
TSM-DEG14.40
TSM-DEG14.47
Duomax M Plus
TSM-DEG40.40(II)
TSM-DEG40.47(II)
TSM-DEG5.40(II)
TSM-DEG5.47(II)
TSM-DEG14.40(II)
TSM-DEG14.47(II)

Advertisement

Table of Contents
loading
Need help?

Need help?

Do you have a question about the DUOMAX and is the answer not in the manual?

Questions and answers

Summary of Contents for Trina Solar DUOMAX

  • Page 1 INSTALLATION MANUAL IEC & UL version MODULE TSM-PDG40.40 TSM-PDG40.47 TSM-PDG5.40 Duomax TSM-PDG5.47 TSM-PDG14.40 TSM-PDG14.47 TSM-PEG40.40 TSM-PEG40.47 TSM-PEG5.40 Duomax TSM-PEG5.47 TSM-PEG14.40 TSM-PEG14.47 TSM-DEG40.40 TSM-DEG40.47 TSM-DEG5.40 TSM-DEG5.47 TSM-DEG14.40 TSM-DEG14.47 Duomax M Plus TSM-DEG40.40(II) TSM-DEG40.47(II) TSM-DEG5.40(II) TSM-DEG5.47(II) TSM-DEG14.40(II) TSM-DEG14.47(II)
  • Page 2: Table Of Contents

    Table of Content DISCLAIMER OF LIABILITY ......................- 3 - SAFETY PRECAUTIONS ........................- 3 - UNPACKING AND STORAGE ......................- 3 - PRODUCT IDENTIFICATION ......................- 4 - ENVIRONMENTAL CONDITIONS AND SITE SELECTION ............- 4 - 5.1 CLIMATE CONDITION ........................- 4 - 5.2 SITE SELECTION ..........................
  • Page 3: Disclaimer Of Liability

    Trina Solar assumes no responsibility for any infringement of patents or other rights of third parties that may result from use of the module. No license is granted by implication or under any patent or patent rights.
  • Page 4: Product Identification

    5400Pa Max from the front side, and 2400Pa from the rear. * Mechanical load bearing (include wind and snow loads) of the module is based on Trina Solar mounting methods. A professional system installer must be responsible for the mechanical load calculation based on the system design.
  • Page 5: Mounting Methods

    Racking Material: Q235B With hook (Supply By EPC or installation Racking suppliers) 6.2 MOUNTING METHODS Please read this chapter in its entirety to familiarize you with the process before beginning the installation. Also, be sure that the site has been completely prepared before beginning the installation. STEP 1: Install the specified bolts Setting the specified bolts into the hook.
  • Page 6: Remarks Of Installation

    Tighten the nut. (16N· m~20N· m) STEP 4: Install the module Repeat steps 1 ~ 3, install the module. 6.3 REMARKS OF INSTALLATION Keep more than 10 mm gap between each module Date: April, 2016 Doc No: PS-M-0433 Ver. A Page - 6 - of 10...
  • Page 7 Note: For PV module landscape installation, the supporting rails need change as shown in below;(add two rails) For 60 cell Duomax module For 72 cell Duomax module Note: Please consult with Trina Solar engineers to confirm whether the rail match Trina hook or not. Date: April, 2016 Doc No: PS-M-0433 Ver. A...
  • Page 8: Module Wiring

    8. MODULE TILT ANGLE Trina Solar PV modules connected in series should be installed at the same orientation and angle. Different orientation or angle may cause loss of output power because each module may be exposed to different amounts of solar irradiation.
  • Page 9: Maintenance And Care

    Cover the front surface of modules by an opaque material when repairing. Modules when exposed to sunlight generate high voltage and are dangerous. Trina Solar is a member of the European PV Cycle Association. Through the pre-financed PV Cycle program, Trina Solar PV modules will be taken back and treated in an environmentally sustainable manner.
  • Page 10: Warning

    These solar modules do not contain any user serviceable parts, If you suspect that your installation is not working properly, then contact your installer immediately. 1. Contact your installer 2. Contact Trina Solar after sales service team at: http://customerservice.trinasolar.com 3. Submit the Customer Feedback form at: , one of our technical service representatives will www.trinasolar.com...

This manual is also suitable for:

Duomax plus

Table of Contents