Clean Unit - Gravely Promaster 100 Service Manual

Service Position
WARNING: ALWAYS block wheels and know
that jack stands or blocks used are stable,
strong, or secure and will hold the weight of
the unit during maintenance.
WARNING: ROTATING PARTS can amputate
body parts. Keep hands and feet away. Loose
clothing, long hair or scarves can get caught
in rotating parts and cause death or serious
injury.
Place unit on flat, level surface. ALWAYS stop engine
and disengage clutches. Assure unit is secure and will
not tip over. Strap and clamp onto lift, if used.
To ensure the unit is positioned in the proper service
position:
1. Place jack stands under rear transaxles only.
2. If jacks are not available, place support blocks
under both transaxles at the rear of unit.
CAUTION: Remove enough fuel so that no
spills will occur.
Maintenance
ALWAYS maintain unit in safe operating condition.
Damaged or worn out muffler can cause fire or
explosion.
Check the conditions of the unit at the end of each day
and repair any damage or defects.
ALWAYS block wheels and know all jack stands are
strong and secure and will hold weight of unit during
maintenance.
Keep nuts and bolts tight and keep equipment in safe
operating conditions.
Before maintenance, adjustments, or service (except
where specifically recommended), shut off engine.
Allow hot parts to cool.
Keep unit free of dirt, stones, and other debris. Clean
up oil or fuel spills.
Storage
DO NOT store unit inside a building with fuel in the fuel
tank where any ignition sources are present. Allow unit
to cool completely.
ALWAYS clean unit before extended storage. See
Engine Manual for proper storage.
Spark Arrester
This product is equipped with an internal combustion
engine. DO NOT use on or near any unimproved,
forest covered or brush covered land unless the
exhaust system is equipped with a spark arrester
meeting applicable local, state or federal laws. A spark
arrester, if used, must be maintained in effective
working order by the operator.
Battery
Avoid Electric Shock. DO NOT reverse battery
connections.
Explosive Gases! Poisonous battery fluid contains
sulfuric acid and its contact with skin, eyes, or clothing
can cause severe burns.
No flames. No sparks. No smoking near battery.
Always wear safety glasses and protective gear near
battery.
DO NOT TIP battery beyond a 45
direction.
ALWAYS KEEP BATTERIES OUT OF REACH of
children.
Transport
Use extra care when loading or unloading unit onto
trailer or truck. Secure unit chassis to transport vehicle.
NEVER secure from rods or linkages that could be
damaged.
DO NOT transport with attachment in raised position.
Lower attachment when unit is parked or stored unless
a positive mechanical lock is used.
Attachments and Accessories
Use only attachments or accessories designed for your
unit.

2.9 CLEAN UNIT

Brush grass, dirt and debris off of unit with a soft brush.
Clean packed grass out from under mower deck. Apply
paint or oil to exposed, bare metal surfaces to prevent
rust.
Inspect unit for visible signs of wear, breakage, or
damage. Order any parts required and make
necessary repairs to avoid delays when beginning use
again.
IMPORTANT: Never spray unit with water or store unit
outdoors. Water can seep into sealed bearings, which
are sealed against dirt and debris only, causing
reduced component life.
Clean seat regularly, using a vinyl cleaner (not solvent).
Extreme temperatures can damage seat when left
unprotected against weather. If seat should tear, apply
vinyl repair tape to protect damaged area.
Transaxle cooling fins must be kept clean to prevent
damage from overheating. Use a cloth or brush to
remove grass, chaff and debris.
Unless there are indications of leakage, transaxle does
not have to be checked for proper oil level. If leak
occurs, have it repaired by your Gravely Dealer.
2 - 6
o
angle in any