Table of Contents
Advertisement
Quick Links
Commercial Countertop
Griddles, Charbroilers & Ranges
Models: 177CAG15TG, 177CAG24TG, 177CAG36TG, 177CAG48TG,
177CAG60TG, 177CAG15MG, 177CAG24MG, 177CAG36MG,
177CAG48MG, 177CAG60MG, 177CAG24RC, 177CAG36RC,
177CAG48RC, 177CAGR212, 177CAGR424, 177CAGR636
07/2021
Please read and keep these instructions. Indoor use only.
www.AvantcoEquipment.com
User Manual
User Manual
1
Advertisement
Table of Contents
Related Manuals for Avantco Chef Series
Summary of Contents for Avantco Chef Series
- Page 1 User Manual User Manual Commercial Countertop Griddles, Charbroilers & Ranges Models: 177CAG15TG, 177CAG24TG, 177CAG36TG, 177CAG48TG, 177CAG60TG, 177CAG15MG, 177CAG24MG, 177CAG36MG, 177CAG48MG, 177CAG60MG, 177CAG24RC, 177CAG36RC, 177CAG48RC, 177CAGR212, 177CAGR424, 177CAGR636 07/2021 Please read and keep these instructions. Indoor use only. www.AvantcoEquipment.com...
-
Page 2: Table Of Contents
User Manual User Manual Index IMPORTANT SAFETY INFORMATION • Please observe all local and national codes and ordinances. Important Safety Information . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . 3 •... -
Page 3: Installation
User Manual User Manual Installation • Do not repair or replace any part of the equipment unless specifically recommended in the manual. • Clean the product daily after use using neutral detergent. Use abrasive materials only for work Upon receipt of the equipment, make sure that the product is not defective. For assembly, verify first surface cleaning. -
Page 4: Rating Plate
User Manual User Manual Gas Pressure Regulator Rating Plate The gas pressure regulator (which accompanies the product) is of utmost importance for its Information on this plate includes the model, serial number, BTU/hour input of the burners, operating operation and is indispensable. The pressure regulator must be installed in the product supply gas gas pressure in inches WC, and whether the appliance is orificed for natural or propane gas. -
Page 5: Gas Conversion Instructions
User Manual User Manual Gas Conversion Instructions 6 . In place of the removed gas injectors (4), place the new injectors that are included with the kit shipped with the product. But first apply some pipe sealant to the valve thread and then screw-in the new injectors to the correct gas type. - Page 6 User Manual User Manual LGP Gas Installation at Low Pressure COUNTERTOP RADIANT GAS CHARBROILER For conversion the following guidelines should be followed: To use the product with LPG gas at low pressure, it is necessary that the product is checked with the injector for use of LPG gas, if it is not with the appropriate injector, the gas conversion should be 1 .
- Page 7 User Manual User Manual First-Time Use COUNTERTOP GAS GRIDDLE, THERMOSTATIC 1. Open the manual gas supply valve (which will release gas Against shock damage or rocking from transportation, the sides and waste tray have a protective into the product); PVC film. Remove any plastics, straps, or protective film from the product before operating the equipment.
-
Page 8: Cleaning
User Manual User Manual Cleaning COUNTERTOP RADIANT GAS CHARBROILER 1. Open the manual gas supply valve (which will release gas into the product); IMPORTANT 2. Immerse in alcohol the lighter (wick) that accompanies the product and light it; Note: Make sure that the container Do not use toxic or high chemical cleaning materials. -
Page 9: Maintenance
User Manual User Manual Maintenance Technical Specifications Maintenance is one of the precautions to be taken for a good equipment life. Proper cleaning, COUNTERTOP GAS GRIDDLE, THERMOSTATIC installation, checking and product life all contribute to reduced maintenance. Before any maintenance, verify that the gas connections, regulators or check valves must be completely closed and disconnected from the product. -
Page 10: Technical Data
User Manual User Manual User Manual Technical Data COUNTERTOP RADIANT GAS CHARBROILER COUNTERTOP GAS GRIDDLE, THERMOSTATIC Gas Supply Manifold Pressure MODEL # BURNERS GAS TYPE NOZZLE BTU/HR KCAL/HR TUBE PRESSURE (in . W .C .) NAT. GAS 35,000 8,820 177CAG15TG L.P . -
Page 11: Parts Diagrams
User Manual User Manual User Manual Technical Data PARTS DIAGRAM COUNTERTOP GAS GRIDDLE, THERMOSTATIC COUNTERTOP RADIANT GAS CHARBROILER Gas Supply Manifold Pressure MODEL # BURNERS GAS TYPE NOZZLE BTU/HR KCAL/HR TUBE PRESSURE (in . W .C .) NAT. GAS 60,000 15,129 177CAG24RC L.P . - Page 12 User Manual User Manual User Manual User Manual PARTS LIST PARTS DIAGRAM COUNTERTOP GAS GRIDDLE, THERMOSTATIC COUNTERTOP GAS GRIDDLE, MANUAL PART QUANTITY BY MODEL (SIZE) PART # DESCRIPTION 15" 24" 36" 48" 60" 8.09.03.00000400 LEG ASSEMBLY 8.01.53.00002000 GAS VALVE ASSEMBLY 8.01.53.00001900 KNOB ASSEMBLY 8.01.53.00000060...
- Page 13 User Manual User Manual User Manual User Manual User Manual PARTS LIST PARTS LIST PARTS DIAGRAM COUNTERTOP GAS GRIDDLE, THERMOSTATIC COUNTERTOP GAS GRIDDLE, MANUAL COUNTERTOP RADIANT GAS CHARBROILER User Manual PART QUANTITY BY MODEL (SIZE) PART QUANTITY BY MODEL (SIZE) PART # PART # DESCRIPTION...
- Page 14 User Manual User Manual User Manual PARTS LIST PARTS DIAGRAM COUNTERTOP RADIANT GAS CHARBROILER COUNTERTOP GAS HOT PLATE CRUMB/DRIP PAN CODES Model 24" 8.01.52.00000796 Model 36" 8.01.53.00000088 Model 48" 8.01.53.00000103 www.AvantcoEquipment.com www.AvantcoEquipment.com www.AvantcoEquipment.com...
-
Page 15: Warranty
COUNTERTOP GAS HOT PLATE Avantco warrants its equipment to be free from defects in material and workmanship for a period of 1 year. This is the sole and exclusive warranty made by Avantco covering your Avantco brand equipment. A claim under this warranty must be made within 1 year from the date of delivery of the equipment.
Need help?
Do you have a question about the Chef Series and is the answer not in the manual?
Questions and answers