Fuel Safety - Westinghouse WGen5300DFv User Manual

SAFETY

FUEL SAFETY

Gasoline and liquid petroleum gas (LPG)
are highly explosive and flammable.
Explosions and fire can cause severe
burns or death.
Gasoline and gasoline vapor (Gas)
• Gasoline is highly flammable and explosive.
• Gas expands and contracts with different temperatures.
• In case of a gas fire, do not attempt to extinguish the
flame if the fuel shutoff valve is in the on position.
Introducing an extinguisher to a generator with an open
fuel valve could create an explosion hazard.
• Gas has a distinctive odor, this will help detect potential
leaks quickly.
• Gas vapors can cause a fire if ignited.
• Gasoline is a skin irritant and needs to be cleaned up
immediately if it comes in contact with the skin.
Liquid Petroleum Gas (Propane/LPG)
• LPG/Propane is highly flammable and explosive.
• Flammable gas under pressure can cause a fire or
explosion if ignited.
• LPG/Propane can settle in low places because it is
heavier than air.
• LPG/Propane has a distinctive odor added to help
detect potential leaks.
• Always keep LPG/Propane tank in an upright position.
• When exchanging LPG/Propane tanks, be sure the tank
value is the same type.
• In case of a LPG/Propane fire, do not attempt to
extinguish unless the fuel supply can be shut off.
• LPG/Propane will burn the skin. Prevent skin contact at
all times.
Never use a gas container, LPG
connector hose, LPG tank or any other
fuel item that appears to be damaged.
When starting generator:
• Make sure that the gas cap, air filter, spark plug, fuel
lines and exhaust system are properly in place.
• If you spill any gasoline on the tank, allow it to fully
evaporate before operating.
• Make sure the generator and propane tank are on a flat
surface before operating.
• If there is a propane odor do not start the unit because
there may be a potential leak.
• Never place propane tank near engine exhaust.
DANGER
WARNING
When transporting or servicing the generator:
• Make certain the fuel shutoff valve is off and the fuel
tank is empty.
• Make sure the LPG tank and LPG hose is not attached
to the generator.
• Disconnect the spark plug wire.
When storing the generator:
• Store away from sparks, open flames, pilot lights, heat
and other sources of ignition.
• Do not store gas or LPG tank near furnaces, water
heaters or any other appliances that produce heat or
have automatic ignitions.
Only use approved LPG tanks with OPD
(overfilling prevention device) valve.
Always keep the tank in a vertical position
with the valve on top and installed at
ground level on a flat surface. Do not allow
tanks to be around any heat source and
make sure it is not exposed to the sun,
rain and dust. When transporting and
storing, turn off the tank valve and fuel
valve, and disconnect the tank. Make sure
to always cover the generator and tank
outlet with protective plastic caps.
Do not allow children to tamper or
play with the propane tank or hose
connections.
If there is a strong smell of propane while
operating the generator close the valve on
the propane tank immediately. Once the
propane is off, use soapy water to check
for leaks on the hose and connections on
the tank valve and the generator. Do not
smoke or light a cigarette or check for
leaks using any open flame source such
as a match or lighter. If a leak is found
contact a qualified technician to inspect
and repair the LPG system before using
the generator.
Westinghouse Outdoor Power Equipment, LLC | 9
CAUTION
CAUTION
WARNING