Page 1
USER MANUAL WGen5300 Dual Fuel Portable Generator Gasoline: 5300 Running Watts | 6600 Peak Watts Propane: 4800 Running Watts | 5800 Peak Watts DO NOT RETURN THIS PRODUCT TO THE STORE If you have questions or need assistance, please call customer service at 855-944-3571.
The illustrations used in this manual are intended as representative reference views only. We reserve the right to make any specification or design change without notice. 2 | Westinghouse Outdoor Power Equipment, LLC...
Date of Purchase: Or scan the following QR code with your smartphone camera to be directed to the link. Model Number: Serial Number: Place of Purchase: IMPORTANT: Keep your purchase receipt for trouble-free warranty coverage. Westinghouse Outdoor Power Equipment, LLC | 3...
Note: Indicates a procedure, practice or condition that should be followed for the generator to function in the manner intended. 4 | Westinghouse Outdoor Power Equipment, LLC...
The connection must isolate the generator power from utility power and must comply with all applicable laws and electrical codes. Westinghouse Outdoor Power Equipment, LLC | 5...
Page 6
• Gas vapors can cause a fire if ignited. • Gasoline is a skin irritant and needs to be cleaned up immediately if it comes in contact with the skin. 6 | Westinghouse Outdoor Power Equipment, LLC...
Page 7
7” to 14” of water column. A certified plumber must ensure that the pressure is correct or install a step down regulator if needed. Westinghouse Outdoor Power Equipment, LLC | 7...
120V or 240V output. 11. Ground Terminal: The ground terminal is used to externally ground the generator. 6. 120 Volt AC, 30 Amp NEMA TT-30R Receptacle: Receptacle can supply a maximum of 30 Amps. Westinghouse Outdoor Power Equipment, LLC | 9...
Note: The wheels are only intended for hand transport. The wheels are not suitable for towing the generator either on or off-road. If any parts are missing, contact our service team at service@wpowereq.com or call 1-855-944-3571. Westinghouse Outdoor Power Equipment, LLC | 11...
ALWAYS mix the correct amount of fuel stabilizer to gasoline in an approved gasoline container before fueling the generator. Run the generator for five minutes to allow the stabilizer to treat the entire fuel system. 12 | Westinghouse Outdoor Power Equipment, LLC...
IMPORTANT: DO NOT use thread seal tape or any other type of sealant to seal the LPG/propane hose connection. 5. Tighten the LPG/propane hose connector to the generator with a 19 mm or adjustable wrench. DO NOT over-tighten. Torque: 5-10 lb-ft. Westinghouse Outdoor Power Equipment, LLC | 13...
Page 14
If the leak continues or if the leak is not at a fitting then DO NOT use the generator and contact customer service. IMPORTANT: Keep the propane tank valve in the fully closed position unless in use. 14 | Westinghouse Outdoor Power Equipment, LLC...
3. Remove the nut securing the neutral ground wire and and/or the muffler. DO NOT contain generators during operation. attach the bonded jumper wire. Reinstall the nut. Westinghouse Outdoor Power Equipment, LLC | 15...
The 120V only outlets will not output power when the Voltage Selector is in the 240V position. WARNING Only change the Voltage Selector Switch with the generator OFF. DO NOT switch the voltage while the generator is running or powering appliances. 16 | Westinghouse Outdoor Power Equipment, LLC...
1. Fully open the valve on the propane tank. 2. Turn the fuel selector switch to propane operation. 3. Turn the fuel tank valve to the OFF position. Westinghouse Outdoor Power Equipment, LLC | 17...
Total Running Watts 2590 resetting the AC circuit breaker ON. Highest Starting Watts + 1600 Total Starting Watts Needed 4190 *Wattages listed are approximate. Verify actual wattage. 18 | Westinghouse Outdoor Power Equipment, LLC...
ALWAYS use battery-powered carbon monoxide detector (s) that meet current UL 2034 safety standards when running the generator. Regularly check the detector (s) battery. Westinghouse Outdoor Power Equipment, LLC | 19...
Fire hazard. DO NOT up-end the generator or place it on its side. Fuel or oil can leak and damage to the generator may occur. 20 | Westinghouse Outdoor Power Equipment, LLC...
6. Slowly pour oil into the oil filler neck until oil the level is between the L and H marks on the dipstick. Stop frequently to check the oil level. DO NOT overfill. Maximum oil capacity: 0.74 Quart (0.7 Liter) 22 | Westinghouse Outdoor Power Equipment, LLC...
6 months or longer float bowl. Insulator 7. Carefully install the spark plug finger tight, then tighten as additional 3/8 to 1/2 turn with the spark plug wrench. 8. Attach the spark plug boot. Westinghouse Outdoor Power Equipment, LLC | 23...
Page 24
3. Place an appropriate gasoline container under the drain screw to catch the drained fuel. 4. Loosen the float bowl drain screw and allow the fuel to drain. Tighten the float bowl drain screw. 24 | Westinghouse Outdoor Power Equipment, LLC...
9. Replace the fuel line and secure with the clamp. Torque: 106 inch-pound (12 N•m) 8. Perform this procedure for the other valve. 9. Install the gasket, rocker arm cover, and spark plug. Westinghouse Outdoor Power Equipment, LLC | 25...
Gap or replace the spark plug. Reinstall. gapped. Fuel system malfunction, fuel pump failure, ignition malfunction, valves stuck, Contact Westinghouse customer service toll-free at 1 (855) 944-3571. etc. Choke partially open or closed. Fully open or close the choke. Out of fuel.
Page 27
Start the engine and allow the engine to run until the gasoline has been before switching to propane. consumed in the carburetor. Begin propane start up procedure. No power at AC receptacles AC circuit breaker/s tripped. Check AC loads and reset circuit breaker/s. Westinghouse Outdoor Power Equipment, LLC | 27...
Need help?
Do you have a question about the WGen5300DFv and is the answer not in the manual?
Questions and answers
Who manufactures the motor?
The motor for the Westinghouse WGen5300DFv is manufactured by Westinghouse. It features a 274cc 4-Stroke OHV Westinghouse Engine.
This answer is automatically generated
my generator electric start only works when the charging cord is plugged in to a power outlet. I replaced the battery.