Table of Contents
Advertisement
GENRERAL OPERATION AND SERVICE
Operating
•
Read and understand all the operating and safety
precautions before operating machinery.
•
In addition to equipment configuration and design,
hazard control and accident prevention depend on
awareness, concern, prudence and proper training of
personnel in the operation, maintenance, transport
and storage of equipment.
•
Always raise implement, shut off tractor engine, set
the parking brake, shift to park position (or neutral)
remove the key and install cylinder lockup channels
before working around the machine.
•
Avoid working under the planter. However, if it
becomes unavoidable to do so, make sure the planter
is securely blocked and the cylinder lockup channels
are in place.
•
Do not attempt to lubricate or adjust the planter while
the machine is in operation.
•
Machinery operation can be performed only by
persons who are responsible and delegated to do so.
•
Only the operator must be permitted on the tractor
(unless tractor has a factory-installed instructor seat)
when the tractor and the planter are moving. Never
permit anyone to ride on the planter.
•
Avoid wearing loose-fitting clothing and jewelry.
Always tie up long hair that can be caught in moving
parts.
•
Wear personal protective equipment (PPE) such as,
but not limited to, protection for eyes, lungs, ears,
head, hands and feet when operating, servicing or
repairing equipment.
•
Make sure bystanders are clear before operating
tractor or machine.
•
Do not leave tractor or implement unattended with
the engine running.
•
Never attempt to operate the planter unless seated in
the operator's seat on the tractor.
4283411M1
•
Tractor must be equipped with rollover protective
structure (ROPS), and a seat belt. Use seat belt
during operation.
•
Make sure the tractor is in good operating condition,
and has adequate braking capabilities.
•
Do not dismount from a moving tractor.
•
Regulate ground speed to field conditions, and
maintain control at all times.
•
When working around discs, be careful to not get cut
on sharp edges.
•
Watch for overhead wires or other obstructions when
raising markers, and when moving the planter with
marker(s) raised.
•
Disconnect and store planter where children do not
normally play. Stabilize the planter by using suitable
supports, and block the wheels.
•
Always lower the planter when not in use and relieve
the pressure in hoses and cylinders.
•
Do not allow children to ride on, play on, or operate
equipment. Always keep children away from
equipment operating, servicing, and storage areas.
•
Do not stand between the tractor and the planter to
install hitch pin when the tractor engine is running.
Safety
01-7
Advertisement
Table of Contents
