Table of Contents
Advertisement
SILVER M
MONTAŻ – EKSPLOATACJA - KONSERWACJA
Check pocket type filters and frames for
4.1
Check filter seat for leak-tightness and visually
4.2
Check filter insert for obvious contamination,
4.3
4.4
4.5
4.6
4.7
5
Allow the heat exchanger to cool down to the
5.1
5.2
Check lamella-fins for contamination
5.3
Check lamella-fins and piping for damage
5.4
Check heat exchanger leak-tightness
5.5
Check feed/return lines for function
5.6
Check the frost protection for function
Check condensation drain at the cooling
5.7
5.8
6
Check droplet separator and condensate tank
6.1
7
7.1
7.2
7.3
7.4
8
8.1
Decalcification of entire spray humidifier
Decalcification of the humidifier nozzles and
8.2
nozzle fittings, under no circumstances may
the nozzle bore holes be cleaned with hard
Check list for a hygienic operating method and maintenance of ventilation and air conditioning equipment
activity
contaminants and damage
inspect for damage
odours or leakage
Check differential pressure
Filter change at the latest 1st level
Filter change at the latest 2nd level
Perform odour check
ambient temperature
radiator
Check siphon for function
for contaminants and damage
Clean lamella-fin surfaces
Check compressor oil level
Check condensate drainage
Leak test
I NSTALLATIO N – OPERAT ING - MAI NT ENANCE
measure (if necessary)
cleaning and repair
repair
replace
replace filter insert when final resistance
is reached
Activated carbon filter
activated carbon filter cartridge to be
replaced
Heat exchanger (see Chapter 5.6)
cleaning and repair
comb out bent or warped lamella-fins
repair
thermostat by means of coolant spray
Cleaning
clean and refill (at the start of the cold
period)
Droplet separator (see Chapter 5.7
when cleaning the droplet separator,
remove the cartridges and lamella-fins
(remove bio-film)
Cooling system (see Chapter 5.8)
Evaporator and condenser
the oil should cover at least half of the
viewing glass with the compressor
switched off
clean (be aware of unusual odours or
operating conditions)
By certified refrigeration specialists
Spray humidifier (see Chapter 5.9)
add in the lime solvent to the circulation
water and operate the circulation pump
until the lime is dissolved. The entire
spray humidifier must be subsequently,
thoroughly rinsed
cleaning and repair
month
1
3
6
12
24
x
x
x
x
x
x
x
x
x
x
x
x
at the start of the cooling period
x
x
x
x
x
x
x
x
x
31
Advertisement
Table of Contents
