Table of Contents
Advertisement
Quick Links
OPERATOR'S MANUAL
HWH TOUCH PANEL-CONTROLLED
325 SERIES LEVELING SYSTEM
SPACEMAKER ROOM EXTENSION SYSTEMS
Ph: 800/321-3494 (or) 563/724-3396 | Fax: 563/724-3408
AP29423
H H
W
CORPORATION
R
R
FEATURING:
Touch Panel Leveling Control
BI-AXIS Hydraulic Leveling
R
Straight-Acting Jacks
Pilot Operated Suspension Air Dump
Two Room Extensions
HWH HYDRAULIC LEVELING
LEVEL
STORE
OFF
CAUTION!
UNDERSTAND OPERATOR'S MANUAL BEFORE USING. BLOCK FRAME AND TIRES
SECURELY BEFORE REMOVING TIRES OR CRAWLING UNDER VEHICLE.
HWH CORPORATION
(On I-80, Exit 267 South)
2096 Moscow Road | Moscow, Iowa 52760
www.hwh.com
R
ML29424/MP05.9456
15SEP03
Advertisement
Table of Contents
Related Manuals for HWH SPACEMAKER 325 Series
Summary of Contents for HWH SPACEMAKER 325 Series
- Page 1 CORPORATION OPERATOR’S MANUAL HWH TOUCH PANEL-CONTROLLED 325 SERIES LEVELING SYSTEM SPACEMAKER ROOM EXTENSION SYSTEMS FEATURING: Touch Panel Leveling Control BI-AXIS Hydraulic Leveling Straight-Acting Jacks Pilot Operated Suspension Air Dump Two Room Extensions HWH HYDRAULIC LEVELING LEVEL STORE CAUTION! UNDERSTAND OPERATOR’S MANUAL BEFORE USING. BLOCK FRAME AND TIRES SECURELY BEFORE REMOVING TIRES OR CRAWLING UNDER VEHICLE.
-
Page 2: How To Obtain Warranty Service
HWH CORPORATION personnel will contact you to the problem quickly. If the dealer has difficulty solving determine whether or not your claim is valid. If it is, HWH the problem, he should immediately contact the Customer CORPORATION will authorize repair or replacement of the Service Department, at HWH CORPORATION. -
Page 3: Control Identification
CONTROL IDENTIFICATION FRONT RETRACT BUTTON HWH HYDRAULIC LEVELING FRONT EXTEND BUTTON LEVEL MODE LIGHT "LEVEL" BUTTON LEVEL WARNING LIGHTS (4-Red) STORE LIGHT RIGHT SIDE EXTEND BUTTON "STORE" BUTTON STORE RIGHT SIDE RETRACT BUTTON LEFT SIDE EXTEND BUTTON LEVEL LIGHTS (4-Yellow) "OFF"... - Page 4 CONTROL IDENTIFICATION ROOM EXTENSION OPERATOR’S PANEL HYDRAULIC ROOM EXTENSION EXTEND ROOM CONTROL UNIT MUST HAVE JACKS DOWN KEY SWITCH AND BE LEVEL BEFORE SWITCH OPERATING ROOM CAUTION! UNDERSTAND OPERATOR’S MANUAL BEFORE USING. KEEP PEOPLE AND OBSTRUCTIONS RETRACT CLEAR OF ROOM WHEN OPERATING. CONTROL FUNCTIONS KEY SWITCH: The KEY SWITCH controls power to the ROOM...
-
Page 5: Operating Procedures
OPERATING PROCEDURES GENERAL INSTRUCTIONS GENERAL INSTRUCTIONS Site selection - Maintain adequate clearance in all Read all room extension operating procedures before directions for vehicle, room extensions, awnings, doors, before extending or retracting any room. steps, etc. Vehicle may move in any direction due to jacks extending or retracting, settling of jacks or vehicle, It is the operator’s responsibility to check that the jacks are completely retracted and any room extension or... - Page 6 OPERATING PROCEDURES RETRACT PROCEDURE CAUTION: THE OPERATOR MUST BE SURE THAT 5. The system will stay in the STORE mode until the "OFF" THERE ARE NO OBJECTS UNDER THE VEHICLE AND button is pushed or the ignition key is turned. THAT ALL PEOPLE ARE CLEAR OF THE VEHICLE.
- Page 7 OPERATING PROCEDURES TRAVEL PROCEDURES Start the vehicle engine before retracting the jacks. Push During traveling if the STORE light is not on and the Jacks the "STORE" button to retract the jacks, the STORE light Down Warning Buzzer comes on, push the "STORE" button will come on.
- Page 8 KEEP PEOPLE AND OBSTRUCTIONS room. DO NOT reverse direction of the room, contact CLEAR OF ROOM WHEN OPERATING. HWH Customer Service for assistance 1-800-321-3494. NOTE: Make sure there is adequate clearance to fully NOTE: Releasing the ROOM CONTROL SWITCH will halt extend the room.
- Page 9 Use the manual valve release for retracting the jacks only removed to gain access. DO NOT turn the 1/4" valve if the STORE feature on the HWH control panel will not release nut more than 1 full turn . Turning the nut more retract the jacks.
- Page 10 Follow steps 2 and 3 and try pushing the room in. it to the room according to the vehicle manufacturer’s Contact the vehicle manufacturer or HWH Customer instructions. To extend the WINCH STRAP firmly grasp Service at 1-800-321-3494 or 563-724-3396 for assistance.
-
Page 11: Maintenance
Dexron automatic transmission fluid contains red dye and can cause staining should a leak occur. DO NOT USE All jacks and any HWH room extension cylinders should be brake fluid or hydraulic jack fluid. Use of these can damage completely retracted before checking the oil level. The oil seals. - Page 12 Move the adjustment for that light very, very, slightly in qualified RV repair center, your vehicle or coach the OPPOSITE direction that is given in the above manufacturer, or HWH CORPORATION for service or repair. instructions for LED’s A, B, C, and D. This will allow MP45.3259 07MAY09 MP44.1501...
- Page 13 BREATHER CAP - DIPSTICK - 1/4" NUT DRIVER 1 1/2" DIAMETER VALVE RELEASE SOLENOID VALVE NOTE: DO NOT turn the valve release nut more than 4 and 1/2 (four and one half) turns counter clockwise. Damage to the valve may result. VALVE RELEASE PLASTIC PLUG 2 1/4"...