Operation - Volvo Penta 3.0GXi-J Operator's Manual

Operation

This manual covers a wide range of instruments and controls, many of which will not be equipped on all boats.
The types of instruments and controls installed on your boat is determined by the boat manufacturer. This manual
provides information about equipment manufactured by Volvo Penta. If you have non Volvo Penta equipment
installed on your boat or if the Volvo Penta equipment installed is not covered in this manual, please refer to any
additional documentation that came with your boat.
DANGER!
Never allow an open flame or electric sparks near the battery or batteries. Never smoke in proximity to the
batteries. The batteries give off hydrogen gas during charging which, when mixed with air, can form an explosive
gas. This gas is easily ignited and highly volatile.
WARNING!
Never use the drive unit as a ladder or as a lift to board the boat. Personal injury could result from contact with
propellers.
WARNING!
Never board at the rear of the boat when the engine is running, even if the drive is in neutral. Personal injury
could result from contact with propellers.
WARNING!
Check that nobody is in the water before engaging ahead or astern. Never drive in or near areas where people
could be in the water.
CAUTION!
Be sure you have read and understand everything in the section entitled "Before Starting" prior to continuing with
this section.
CAUTION!
Avoid violent and unexpected changes in course and gear engagement. This could cause someone on the boat
to lose their balance and fall over or overboard.
CAUTION!
Avoid trimming the sterndrive too much as steering will be severely reduced.
For your safety and to ensure minimal interruption of your cruising pleasure, we strongly recommend that you
carry the following spare parts and tools aboard your boat.
Extra propeller & prop hardware
Impeller & glycerine
Fuel filters
Engine oil & oil filters
Fuses
Ignition, starter, and fuel pump relays
47700387 06-2009
Replacement Parts and Tools
Checklist
Thermostat & gaskets
Cap & rotor
Electrical & duct tape
Hose clamps
Tools, for any possible repairs
while underway
75